TOYO TIRES Complaints

TOOK CAR FOR SERVICE AND WAS TOLD THAT AT 12,500 MILES THE TIRES ON OUR 2007 TOYOTA HIGHLANDER WHERE WORN OUT AND NEEDED TO BE REPLACED THE TIRES ARE A TOYO TRANPATH A11 225 70 R 16. *TR

I INSTALLED WINTER TIRES AND WHEELS WITH OEM TPMS AND WAS NOT ABLE TO RESET THE CAR TO RECOGNIZE THESE NEW SENSORS. I'M TOLD THAT I HAVE TO HAVE THE DEALER RESET THE SYSTEM TWICE A YEAR WHEN I CHANGE WHEELS AND TIRES OR LET THE SYSTEM READ FAILURE UNTIL I SWAP BACK THE ORIGINAL WHEELS AND TIRES. THE CAR IS A TOYOTA HIGHLANDER. I THINK THE TPMS IS A GREAT SYSTEM BUT THE MANUFACTURES NEED TO UPDATE THE CARS SOFTWARE TO ALLOW THE DRIVER TO UPDATE THE SYSTEM. THE DEALER CHARGES 125.00 EACH TIME FOR THIS SERVICE. THE LAW MANDATING TPMS DIDN'T INTEND TO MAKE THIS A CASH COW FOR THE DEALERSHIP. *TR

TL*THE CONTACT OWNS A 2000 COUNTRY COACH ALLURE. THE VEHICLE HAS TOYO TIRES, SIZE 275/70R M102Z (NA). THE CONTACT EXPERIENCED THREE BLOWOUTS WITH THREE OF THE SIX TIRES ON HIS MOTOR HOME. ALL THREE BLOWOUTS WERE APPROXIMATELY ONE TO TWO MONTHS APART. HE WAS DRIVING APPROXIMATELY 60 MPH WHEN HE NOTICED THE BLOWOUTS. NO CRASH OCCURRED. HE INSPECTED THE TIRES AND NOTICED THAT THEY APPEARED TO HAVE EXPLODED AND BARELY ANYTHING REMAINED IN THE TIRES. THE CONTACT REPLACED ALL SIX TIRES AT THE COST OF $263 PER TIRE. HE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER (TIRES) APPROXIMATELY A YEAR AFTER REPLACING THE TIRES. THE MANUFACTURER STATED THAT THEY WOULD HAVE TO REIMBURSE THE CONTACT FOR THE MONEY HE SPENT FOR THE TIRE REPLACEMENT. HE HAS BEEN UNABLE TO GET IN TOUCH WITH THE MANUFACTURER TO CLAIM REIMBURSEMENT. THE CONTACT DID NOT HAVE THE DOT NUMBER FOR THE TIRES BECAUSE THEY EXPLODED DURING THE FAILURE. THE CURRENT MILEAGE WAS 31,475 AND FAILURE MILEAGE WAS 30,119.

BOUGHT FOUR TOYO Z800 ULTRA TIRES AS A SET ON MARCH 22, 2003, WHEN MY 1995 NISSAN SENTRA GLE HAD 134492 MILES. CAR WAS PROPERLY ALIGNED, WHEELS PROPERLY BALANCED, AND TIRES PROPERLY INFLATED AT ALL TIMES. REPLACED ONE TIRE DECEMBER 21, 2007 AT 177988 MILES; BECAUSE OF SIDEWALL CRACKS AND A THROWN CHUNK OF TREAD (ROUGHLY QUARTER-SIZED). REPLACED OTHER THREE TIRES DECEMBER 13, 2008 WHEN MY CAR HAD 189006 MILES; BECAUSE OF TREAD AREA CRACKS AND LIGHT CRACKING ON SIDEWALLS (PICTURES AVAILABLE). (NOTE: THOSE THREE Z800S HAD IDENTICAL DOT NUMBERS AND TO THE BEST OF MY KNOWLEDGE, THE FOURTH DID ALSO.) A REPRESENTATIVE OF THE ORIGINAL DEALER IS GIVING ME A PRORATED REFUND OF THE ORIGINAL PURCHASE PRICE, WHICH I CONSIDER TO BE A SATISFACTORY RESOLUTION. *TR

TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE VEHICLE HAS TOYO OPEN COUNTRY AT TIRES, SIZE P22570R15 (NA). THE TIRES WERE PURCHASED BRAND NEW IN MAY OF 2007 FROM JENSEN TIRE COMPANY WHILE DRIVING 15 MPH. AT 36,000 MILES, THE REAR PASSENGER TIRE BLEW OUT IN JUNE OF 2008. THE REPAIR SHOP STATED THAT THE TIRE WAS WORN DOWN TO THE STEEL. THE TIRE COMPANY FROM WHERE THE TIRE WAS PURCHASED IS PROVIDING REIMBURSEMENT FOR THE FAILED TIRE. THE REMAINING TIRES WERE INSPECTED BY OTHER SHOPS AND EACH SHOP RECOMMENDED THAT THE REST OF THE TIRES BE REPLACED. TOYO STATED THAT THE TIRES NEEDED AN ALIGNMENT. THE CONTACT STATED THAT AN ALIGNMENT HAD JUST BEEN PERFORMED; HOWEVER, THE MANUFACTURER ADVISED HER TO HAVE ANOTHER ONE. WHILE THE VEHICLE WAS AT THE SHOP, THE MECHANIC STATED THAT THE BALL JOINTS WERE DEFECTIVE DUE TO THE DAMAGE CAUSED BY THE TIRES AND NEEDED TO BE REPLACED. THE BALL JOINTS HAVE NOT BEEN REPLACED AND THE MANUFACTURER IS REFUSING RESPONSIBILITY FOR THE REPAIRS. THE FAILURE MILEAGE WAS 34,200 AND CURRENT MILEAGE WAS 123,402.

4 TIRES PURCHASED FROM ARMY AIR FORCE EXCHANGE SERVICE, (AAFES) ON 20 NOV 2006 FOR A 2003 TOYOTA SIENNA VAN. I HAVE HAD TO TAKE IT BACK TO GET THE VALVE STEMS REPLACED. FIRST INCIDENT WAS 10 OCT 2008, THE SECOND OCCURRENCE JUST HAPPENED AND WILL BE REPLACED ON THE 11TH. *TR

TL*THE CONTACT OWNS A 1998 FORD F-150. THE VEHICLE HAS TOYO OPEN COUNTRY AT TIRES, SIZE P235/70/R16. THE CONTACT NOTICED THAT THE SIDEWALLS OF THE FRONT DRIVER'S SIDE, FRONT PASSENGER SIDE, AND REAR PASSENGER SIDE TIRES WERE CRACKED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND ALL FOUR TIRES WERE REPLACED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 116,000. UPDATED 12-01-08 *BF UPDATED 12/02/08. *JB

AS A PRECAUTIONARY MEASURE, I REPLACED A TOYO TIRE (WITH LESS THAN 35,000 MILES ON IT) ON MY 1999 MAXIMA. AN EXTERIOR BUBBLE BEGAN TO APPEAR IN THE SIDEWALL OF THE PASSENGER-SIDE RIGHT FRONT TIRE. *TR

TL*THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE VEHICLE HAS TOYO TIRES, SIZE 215/70/R15. THE CONTACT CLOSELY INSPECTED THE REAR DRIVER'S SIDE TIRE AND NOTICED A BULGE. THE TIRE PRESSURE WAS NORMAL. HE TOOK THE TIRE TO A TIRE DEALER AND THEY STATED THAT THE TIRES WERE NO LONGER MANUFACTURED. THE CONTACT STILL HAS POSSESSION OF THE TIRE. HE CALLED THE MANUFACTURER AND IS WAITING FOR A RESPONSE. THE DOT NUMBER AND VIN WERE UNKNOWN. THE FAILURE MILEAGE WAS 90,000. UPDATED 11/6/08 *CN UPDATED 11/10/08. *JB

WHILE TRAVELING ON THE HIGHWAY AT 60 MPH THE REAR TIRE ON THE DRIVERS SIDE FELL APART. THE TIRE SEPARATED AT THE SIDE WALL. MY WIFE MANAGED TO MAINTAIN CONTROL OF THE VEHICLE AND CAME TO A STOP ON THE SIDE OF THE ROAD. THE DEALER WAS NO HELP. WE FEEL THAT THESE TIRES ARE UNSAFE AND WANT TO REPLACE THEM. TIRES-TOYO P225 70R16 101S M+S 97H1407 THESE TIRES HAD ONLY 19800 MILES ON THEM. *TR