2009 AUDI A4 Complaints

TWO FAULTY MIS FIRES CAUSED CAR TO MISFIRE AND RUN ROUGH AND JOLT. CAR WAS TOWED TO THE CLOSEST AUDI DEALERSHIP FOR REPAIRS. SUBSEQUENTLY, WITHIN THE NEXT 9 MONTHS, THE CARE AGAIN EXHIBITED CLOSE TO THE SAME SYMPTOMS AND THE CAR WAS AGAIN TOWED TO THE CLOSEST AUDI DEALERSHIP. THIS TIME, THE INTAKE MANIFOLD WAS CRACKED AND WAS REPLACED. WITH A SERVICE BULLETIN OUT ON THIS VEHICLE ON THESE EXACT ISSUES, I WAS STILL CHARGED A $250 DEDUCTIBLE PER INCIDENT ($500 TOTAL) ON MY EXTENDED WARRANTY TO REPLACE BOTH THE INJECTORS AND THE INTAKE MANIFOLD. ACCORDING TO THE SERVICE BULLETIN, I SHOULD NOT HAVE BEEN CHARGED.

2009 AUDI A4 WAS RECALLED FOR OIL CONSUMPTION ISSUES. REBUILT IN MARCH OF 2014. JULY 2015 TIMING CHAIN TENSIONER FAILED CAUSING TIMING CHAIN TO JUMP AND DROP A VALVE. CAR IS NOW SITTING AT AUDI DEALERSHIP WITH AN UNFIXABLE ENGINE. THERE ARE HUNDREDS OF EXAMPLES OF THIS PART FAILING AFTER OIL CONSUMPTION REBUILD. THIS AS A DEFECT AND VERY DANGEROUS BECAUSE CAR JUST STOPS RUNNING. AUDI WILL NOT TAKE ANY RESPONSIBILITY DESPITE THE MOUNTING FACTS AGAINST THE PART.

PURCHASED AROUND JAN 2013 WITH APX. 30,000 MI. NOTICED RIGHT AWAY THE ADD OIL INDICATOR COMING ON. AFTER ADDING A QUART OF OIL A COUPLE OF TIMES BETWEEN OIL CHANGES AND EVEN TAKING INTO THE DEALERSHIP FOR THEM TO ADD OIL, I QUESTIONED THE OIL CONSUMPTION OF THE CAR KNOWING THAT NO CAR USES THAT MUCH OIL BETWEEN OIL CHANGES. THE DEALERSHIP ASSURED ME THERE WERE NO ISSUES AT FIRST. AFTER HAVING THE DEALERSHIP DO MY OIL CHANGES AND THE ADD OIL INDICATOR CONTINUING TO COME ON, I FINALLY STATED TO DEALERSHIP THERE IS A PROBLEM AND IT NEEDED TO BE LOOKED INTO. AFTER THE DEALERSHIP TESTING THE OIL CONSUMPTION OF THE CAR TWO TIMES, THEY FOUND THERE WAS A PROBLEM AND REPAIRED IT. HAVE HAD NO PROBLEMS SINCE. RECORDS OF REPAIR ON FILE.

TL* THE CONTACT OWNS A 2009 AUDI A4. THE CONTACT STATED THAT THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT ADDED OIL TO THE ENGINE AND THE OIL WARNING LIGHT SHUT OFF. THE FAILURE RECURRED AFTER APPROXIMATELY 250 MILES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE VEHICLE WAS BURNING AN EXCESSIVE AMOUNT OF OIL AND THE RINGS AND VALVES OF THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

THE TIMING CHAIN TENSIONER FAILED CAUSING THE AUDI INTERFERENCE ENGINE TO BECOME OUT OF SYNC RESULTING IN THE ENGINE BECOMING TOTALED. THIS HAS BECOME A COMMON OCCURRENCE AND IS WIDELY REPORTED ON 2009 AND NEWER MODELS. BELOW IS AN ARTICLE WITH THEIR ASSESSMENT OF THE SITUATION. THE CAR HAD BEEN TAKEN IN 2X FOR MISFIRES AND WAS DIAGNOSED AS AN ISSUE WITH THE SPARK PLUGS, IT IS NOW CLEAR THAT THIS WAS THE TIMING CHAIN BEING OUT OF ALIGNMENT AND MISSED. UPON THE ENGINE LIGHT COMING ON THE CAR WAS LEFT PARKED UNTIL THE DAY BEFORE THE SERVICE APPOINTMENT WHEN IT WAS TO BE DROPPED OFF AT THE SERVICE LOCATION, AT THAT TIME, UPON STARTING THE VEHICLE THE TIMING CHAIN TENSIONER FAILED AND CAUSED THE ENGINE TO FIRE OUT OF ALIGNMENT DAMAGING THE ENGINE. WHEN SPEAKING TO A MEMBER OF THE AUDI DEALERSHIP IT WAS SHARED THAT ANOTHER VEHICLE IS IN FOR THE SAME ISSUE AND THAT THEY ARE SEEING THIS OCCUR MORE AND MORE IN THEIR VEHICLES. THIS FAILURE IS ALSO REMINISCENT OF THE 2007 CLASS ACTION LAW SUIT WHICH PROMPTED AUDI TO MOVE FROM A TIMING BELT TO THE FOR THE SAME OUTCOME OCCURRING. HTTP://REDLINESPEEDWORX.COM/2-0T-TSI-TIMING-CHAIN-FAILURE/ IF AUDI HAD PLACED OUT UPDATED PARTS, I WOULD LIKE TO KNOW WHY THERE WAS NO RECALL TO REPLACE THE PART OR ANYTHING MENTIONED BY THE MANUFACTURE INDICATING THE RELEASE OF UPDATED HARDWARE TO ADDRESS A "POTENTIAL ISSUE"

THE TIMING CHAIN TENSIONER FAILED CAUSING THE AUDI INTERFERENCE ENGINE TO BECOME OUT OF SYNC RESULTING IN THE ENGINE BECOMING TOTALED. THIS HAS BECOME A COMMON OCCURRENCE AND IS WIDELY REPORTED ON 2009 AND NEWER MODELS. BELOW IS AN ARTICLE WITH THEIR ASSESSMENT OF THE SITUATION. THE CAR HAD BEEN TAKEN IN 2X FOR MISFIRES AND WAS DIAGNOSED AS AN ISSUE WITH THE SPARK PLUGS, IT IS NOW CLEAR THAT THIS WAS THE TIMING CHAIN BEING OUT OF ALIGNMENT AND MISSED. UPON THE ENGINE LIGHT COMING ON THE CAR WAS LEFT PARKED UNTIL THE DAY BEFORE THE SERVICE APPT WHEN IT WAS TO BE DROPPED OFF AT THE SERVICE LOCATION, AT THAT TIME, UPON STARTING THE VEHICLE THE TIMING CHAIN TENSIONER FAILED AND CAUSED THE ENGINE TO FIRE OUT OF ALIGNMENT DAMAGING THE ENGINE. WHEN SPEAKING TO A MEMBER OF THE AUDI DEALERSHIP IT WAS SHARED THAT ANOTHER VEHICLE IS IN FOR THE SAME ISSUE AND THAT THEY ARE SEEING THIS OCCUR MORE AND MORE IN THEIR VEHICLES. THIS FAILURE IS ALSO REMINISCENT OF THE 2007 CLASS ACTION LAW SUIT WHICH PROMPTED AUDI TO MOVE FROM A TIMING BELT TO THE FOR THE SAME OUTCOME OCCURRING. HTTP://REDLINESPEEDWORX.COM/2-0T-TSI-TIMING-CHAIN-FAILURE/ IF AUDI HAD PLACED OUT UPDATED PARTS, I WOULD LIKE TO KNOW WHY THERE WAS NO RECALL TO REPLACE THE PART OR ANYTHING MENTIONED BY THE MANUFACTURE INDICATING THE RELEASE OF UPDATED HARDWARE TO ADDRESS A "POTENTIAL ISSUE"

VEHICLE BEGAN TO RUN VERY ROUGH AND STARTED TO SHAKE. PARKED AND STOPPED ENGINE. ON ATTEMPTING TO RESTART IT BRIEFLY FIRED BUT THEN DIED AND STALLED. SUBSEQUENT ATTEMPTS TO START THE VEHICLE RESULTED IN IT TURNING OVER WITH NO APPARENT FIRING. VEHICLE WAS TOWED TO THE AUDI DEALER AND WE WERE INFORMED IT WAS DUE TO TIMING CHAIN SLIP. IT APPEARS FROM INFORMATION ONLINE THAT THE TIMING CHAIN TENSIONER IN THIS 2009 B8 2.0T ENGINE IS DEFECTIVE. THE HEAD AND PISTONS WERE ALL DAMAGED AND THE ENGINE WAS DECLARED UNREPAIRABLE BY THE AUDI DEALER. DEALER CHARGED $1300 FOR INSPECTING THE PISTONS AND WANTS $13,000 FOR A NEW ENGINE. THIS VEHICLE HAD REPLACEMENT PISTON RINGS OUT OF WARRANTY BUT AT NO CHARGE TO US DUE TO THE KNOWN EXCESSIVE OIL CONSUMPTION ISSUE (FOR WHICH THERE WAS A CLASS ACTION LAWSUIT). AUDI INCREASED THE ENGINE WARRANTY FROM 4 TO 8 YEARS AS PART OF SETTLEMENT OF THIS CLASS ACTION, BUT ONLY IN RESPECT OF FAILURES RELATED TO THE EXCESSIVE OIL CONSUMPTION ISSUE. AUDI MAINTAINS THAT THIS ISSUE IS UNRELATED BUT THE DEALER SERVICE MANAGER TOLD ME THAT ANECDOTALLY SHE'S SEEN SEVERAL SUCH FAILURES AFTER PISTON RING REPLACEMENT (I HAVE THIS INTERACTION RECORDED ON VIDEO). SEARCHING ONLINE SHOWS THAT THERE ARE SEVERAL WEBSITES SELLING REPLACEMENT TIMING CHAIN TENSIONERS TO REPLACE THE DEFECTIVE PART THAT AUDI USES ON THIS ENGINE. AUDI REFUSES TO ACKNOWLEDGE ANY FAULT ON THIS ISSUE. RED LINE SPEEDWORX WEBSITE WHICH SELLS UPGRADE KITS TO REPLACE THE DEFECTIVE PART SAYS THAT TYPICALLY THIS FAILURE OCCURS AT 80K MILES PLUS. SINCE THE STANDARD WARRANTY IS 50K MILES THIS MEANS THAT AUDI VIEWS ITSELF AS NOT LIABLE FOR THESE FAILURES. WE ARE FILING A LAWSUIT AGAINST AUDI OVER THIS ISSUE.

WHEN DRIVING CAR IT BECOMES REALLY DIFFICULT AT TIMES TO TURN THE STEERING WHEEL. OFF AND ON. I MYSELF ALMOST HIT SOMEONE WHEN MAKING A TURN AT AROUND 20 MPH, I HAD TO BRAKE AND TURN WITH BOTH HANDS USING ALOT OF FORCE. HAS HAPPENED MULTIPLE TIMES WITH MY DAUGHTER AS WELL. STARTED HAPPENING THE END OF LAST YEAR. CALLED DEALERS AND THEY SAID THERE ARE NO RECALLS ON VEHICLE

VEHICLE BEGAN TO RUN VERY ROUGH / STARTED TO SHAKE. VEHICLE WAS THEN PARKED / TURNED OFF AND COULDN'T RESTART. THE VEHICLE WAS TOWED TO THE AUDI DEALERSHIP WHERE THEY DIAGNOSED THE PROBLEM AS A FAULTY CHAIN TENSIONER. MAY I ADD HERE THAT I'M BEING TOLD BY THE SERVICE PEOPLE THAT UPDATED CHAIN TENSIONERS ARE BEING RECOMMENDED ON NEWER VEHICLES. JUST PRIOR TO THE WARRANTY EXPIRATION THE CARE WAS SERVICED FOR THE OIL CONSUMPTION ISSUE.

THE STEERING WHEEL WAS DIFFICULT TO ROTATE BECAUSE OF A STRONG RESISTANCE TO ROTATION. THIS BEHAVIOR WAS DANGEROUS BECAUSE I COULD NOT TURN THE WHEEL IN NORMAL TRAFFIC WITHOUT EXTREME FORCE. THE AUDI DEALERSHIP TESTED THE CAR AND REPLACED THE "INTERMEDIATE STEERING SHAFT" BUT WOULD NOT PAY FOR THE REPLACEMENT. A CARS STEERING SHOULD WORK FOR THE LIFE OF THE CAR. I QUOTE THE SERVICE TECHNICIAN'S REPORT: 'CONFIRMED CUSTOMER COMPLAINT AND FOUND THE STEERING WAS JERKY AND WOULD NOT RETURN TO CENTER. INSPECTED STEERING COMPONENTS AND FOUND THAT INTERMEDIATE STEERING SHAFT WAS BINDING CAUSING THE STEERING TO JERK. REMOVED AND REPLACED SHAFT AND TESTED AND FOUND CAR TO BE OPERATING AS DESIGNED." I REQUESTED THE REPLACED PART WHICH I HAVE. (PART NUMBER 8K1 419 753 F). THE PART INCLUDES TWO UNIVERSAL JOINTS , ONE ON EACH END. EACH UNIVERSAL JOINT INCLUDES TWO FLEXIBLE BEARINGS WHICH ALLOW THE SHAFT TO BE FREE TO ROTATE FOR CHANGE IN ANGULAR POSITION. ONE OF THE ROTATING PINS WAS FROZEN AND WOULD NOT ROTATE. THIS IS VERY DANGEROUS AND MAY BE OCCURRING ON MANY OF THIS TYPE OF SHAFT. THE NUMBER OF REPLACEMENTS BY AUDI SHOULD BE IDENTIFIED TO DETERMINE IF A RECALL INSPECTION IS NEEDED. I TOLD AUDI US HEADQUARTERS THAT I WOULD BE FILLING A CLAIM IN SMALL CLAIMS COURT. AS A RESULT THEY OFFERED TO PAY 50% OF THE $714.70 BILL WHICH I ACCEPTED INSTEAD OF WAITING FIVE MONTHS FOR A HEARING IN MASSACHUSETTS SMALL CLAIMS COURT. *TR