2002 CHEVROLET AVALANCHE Complaints

ON INSPECTION I WAS TOLD THAT I HAD A LOT OF CORROSION (VERY RUSTY)ON REAR ROTORS AND SAID I WOULD NEED TO HAVE THEM RESURFACED AND SERVICE THE CALIPERS AND REPLACE PADS @16,934 ACTUAL MILES. VERY POOR BRAKING ABILITY AND NOT WANTING TO STOP AS SHOULD. ALSO I KEPT HAVING PROBLEMS STOPPING AS SHOULD IN ANY DISTANCE AND CAME VERY NEAR IN GETTING INTO AN ACCIDENT. HAD I BEEN GOING MUCH OVER THE 35 MILES I WAS I WOULD HAVE HIT THE CAR THAT PULLED OUT IN FRONT OF ME FOR VERY POOR BRAKING. I THEN TOOK VEHICLE INTO ANOTHER DEALERSHIP CLOSER TO ME AND WAS ROAD TESTED THEY COME UP WITH REPLACEMENT AND THAT I WOULD NEED NEW ROTORS AND PADS FRONT BECAUSE OF A LOT OF CORROSION AND RUST AND NEW REAR @ 17,778 ACTUAL MILES DONE JULY 22,2005 FOR PROBLEMS SPONGY BRAKES AS THEY WERE, PLUS THE ANTI-LOCK DID NOT SEEM TO WORK RIGHT FOR SOMETIME. VERY SCARED TO DRIVE MY TRUCK AFTER COUPLE OF NEAR ACCIDENTS.. RESURFACING $110.00 PLUS PAD KIT $59.95 WITHOUT TAXES, LABOR 183.95 AND $492.64 NO LABOR CHARGED WITH ARRANGEMENTS WITH OTHER DEALERSHIP.

I AM ENTERING THIS IN REGARDS TO YOUR INVESTIGATION PE05020. THIS IS ON AN INCORRECT ACTIVATION OF THE ANTI-LOCK BRAKE SYSTEM IN CHEVY TRUCKS 99-2002. I BELIEVE MY VEHICLE HAS THIS DEFECT AND IT MAY HAVE CONTRIBUTED TO TWO ACCIDENTS. THE DEFECT IS IN THE ANTI LOCK BRAKE SPEED SENSOR AND OCCURS DUE TO CORROSION. MY FAMILY HAS A SNOW REMOVAL BUSINESS SO I FREQUENTLY USE THE TRUCK IN BAD WEATHER..ALSO I LIVED ACROSS THE STREET FROM THE OCEAN FOR A YEAR SO THE TRUCK WAS FREQUENTLY EXPOSED TO SALT SPRAY. I WOULD BE HAPPY TO LET YOU EXAMINE THE TRUCK IF YOU WOULD LIKE. I HAVE NOT GONE TO CHEVY TO REQUEST REPAIR YET..AWAITING ADVICE FROM MY INSURANCE COMPANY. *JB

BRAKING DISTANCE IS VERY LONG. REAR BRAKE PADS WEAR OUT MUCH FASTER THAN FRONT PADS. AS AN ENGINEER, I SUSPECT THAT THE ANTILOCK BRAKING SYSTEM IS PREVENTING HYDRAULIC PRESSURE FROM REACHING FRONT CALIPERS, AND THEREBY REDUCING BRAKING EFFECTIVENESS. *NM

POWER WINDOWS QUIT WORKING FIRST RIGHT FRONT THEN LEFT FRONT ABOUT A YEAR LATER. *NM

DT: CONTACT STATED POWER WINDOWS WERE MESSED UP. ABOUT ONE YEAR AGO THE PASSENGER'S SIDE POWER WINDOW STOPPED WORKING. HE TOOK VEHICLET TO THE DEALER ,AND THEY CHANGED SOMETHING ON IT AND FIXED THE PROBLEM. ON 8-17-05 THE DRIVER'S SIDE WINDOW STOPPED WORKING. ALSO TAILGATE JUST DROPPED OPEN. HE SAID SOMEONE WORKED ON IT LAST YEAR AND IT WORKED FOR A WHILE. BUT CURRENTLY IT WAS MESSED UP AGAIN. IT HAS GOTTEN PROGRESSIVELY WORSE OVER THE PAST YEAR. *AK

REMOVED MID-GATE GLASS ON 2002 AVALANCHE TO CLEAN AND NOTICED THAT PLASTIC AROUND MID-GATE WAS SEPARATED FROM ITSELF. WINDOW HAD NEVER BEEN OUT BEFORE. *NM

DT: CALLER HAD FAULTY BRAKES FOR THE LAST THREE WEEKS. WHILE COMING TO A STOP THE BRAKE WILL NOT HOLD AND THE VEHICLE KEPT ROLLING. DEALER SAID THEY WILL CHECK IT. MANUFACTURER HAS NOT BEEN CONTACTED YET. VEHICLE WAS OWNED BY NESTER BROTHERS CONTRACTORS.*AK

# 1-JULY 05---E BRAKE AND FOOT BRAKE WENT TO THE FLOOR BOARDS..REAR ROTORS REPLACED BECAUSE THEY WERE ROTTED,000 MILES 3 AND 1/2 YEARS..INFERIOR METAL WAS USED.........#2 WAS TOLD BY CHEVY I MUST ANTICIPATE ALL STOPS AND TURNS..STEP ON BRAKES SOONER BURN THEM OUT QUICKER..7/30/05 3 PEOPLE IN TRUCK & THE AC ON,DRIVING IN JERSEY, ALMOST HAD THREE HITS. TRUCK WOULDN'T STOP UNDER QUICK STOPS OR LAST MINUTE TURNS BY PEOPLE IN FRONT OF ME. FOUND OUT THE 2003 ON UP HAVE HYDRAULIC IN STEAD OF VACUUM. WHY DID I NOT GET A RECALL OR A RETRO FIT NOTICE TO HAVE THE BRAKE SYSTEM WORK OFF HYDRAULIC AND HAVE THE ROTORS REPLACED BECAUSE OF INFERIOR METAL..CHEVY CHARGED ME $ 100-PLUS FOR A DIAGNOSTIC THAT MADE NO MENTION ABOUT ROTTED ROTORS , BUT FOR $500 PLUS THEY DID SAY THEY WOULD CUT THE REAR ROTORS NEW PADS AND SHOES-- BECAUSE THE SYSTEM IS CALLED BRAKE IN A HAT!!!!!!!*JB

DT: CALLER HIT A SPEED BUMP OR A SPOT ON THE ROAD THAT RAISED THE SPEED. UP 60 OR 70 MPH AND VEHICLE WENT COMPLETELY DEAD. PULLED OVER ON THE HIGHWAY AND TURNED IT OFF. THEN, IT STARTED AGAIN. HE\\CALLER STATED IT DID NOT HAPPEN IN THE CITY, ONLY ON THE HIGHWAY. HE TOOK VEHICLE TO TWO DIFFERENT DEALERS. ONE DEALER SAID THEY COULD NOT DUPLICATE THE PROBLEM. ANOTHER DEALER SAID THE PROBLEM WAS A NEGATIVE CABLE. MANUFACTURER HAS NOT BEEN CONTACTED YET. CALLER SAID THAT THE PROBLEM STARTED AFTER HE HAD THE INTAKE VALVE COVER REPLACED. CALLER STATED THIS HAPPENED 7 TIMES. CALLER BELIEVED THE PROBLEM WAS IN THE ELECTRICAL SYSTEM.*AK

DT: CONTACT STATES HE IS HAVING A PROBLEM WITH HIS ABS. THE BRAKES PULSATE AND THEY DON'T STOP THE VEHICLE. THE CONSUMER NOTICED THE PULSATION WHILE DRIVING AT LOWER SPEEDS BUT NOT AS MUCH AS WHEN HE IS TRAVELING AT HIGHER SPEEDS. THIS OCCURS DURING NORMAL BRAKING. THIS HAS BEEN GOING ON AT SOME DEGREE SINCE HE BOUGHT THE CAR. IT HAS GOTTEN PROGRESSIVELY WORSE. IT IS HAPPENING ALL OF THE TIME NOW. THE BRAKE LIGHT DOES NOT COME ON. THERE IS ALSO A GRINDING NOISE BEFORE THIS HAPPENS. THE CONSUMER IS GOING TO TAKE THE CAR INTO THE DEALER TOMORROW. HE HAS NOT YET TALKED TO THE MANUFACTURER. THE CAR HAS 22,000 MILES ON IT. THERE HAS NOT BEEN ANY KIND OF REPAIR WORK DONE FOR THE BRAKES. *NM