2008 CHEVROLET CORVETTE Complaints

This car has suffered a known defect that causes fuel to leak out of the tank when the tank is more than 1/2 full. Unfortunately, the leak in my vehicle occurred outside the window that GM arbitrarily set up. (10 years after vehicle put in service or 120,000 miles whichever comes first. My vehicle is a 2008 with 94,000 miles and the problem occurred recently and after GM's window. Therefore, GM will not fix this leaking fuel tank and correct a potentially life-threatening issue. The problem is that this is a serious safety issue with strong fumes inside the cars cabin and strong fumes outside the vehicle with leaking fuel on the tank. The fumes and the leaking fuel are both extreme fire issues. This is a known issue and a known condition that could cause fire and loss of life. NHTSA needs to issue an immediate safety recall to have GM fix all of these leaking fuel tanks.

Gas smells when tank is over half full it’s the plastic fuel system on to of tank is starting to crack and I was reading they have been recalled before but has gone off and this is danger and might cause a fire with the saddle bags across the back and only 30,700 miles on car

I just bought a 2008 Chevy Corvette convertible and parked in the garage. The next morning the garage has distinct smell of gas throughout the garage. If my heater to the house would have kicked on the house would have blown up. This is a safety issue which should be addressed by Chevy. After researching the issue, it seems to be a common issue, which should be a recall. Even after moving it outside, when I get in the car it smells of gas.

After refilling my car with gas and parking it in my garage, I noticed that fuel was actively LEAKING from the bottom of my car!@#! Within a few minutes, fuel was pooling under my car on the garage floor. I immediately moved it outside and ran the car for an hour to use up enough fuel so that it was no longer actively leaking. Unfortunately, there still remains an extremely strong fuel smell, even inside the car when driving. With this fuel smell there are strong vapors in my garage. I have to park the car outside all the time, otherwise my garage will be filled with gas vapors immediately (kind of like an air-fuel bomb). The dealer tells me that it will cost $3000-4000 to fix it. This is a HUGE safety issue and should be covered under a factory recall!!!!

SERVICE ACTIVE HNDLG message on the DIC. Not able to put in drive due to this message. Read a lot of forums. There are recalls on up to 2007 but the 2008 Corvettes are having the same issues.

Hello NHTSA, Fuel leaks from drivers side fuel tank. I see fuel tracks down side of tank, so conclude fuel is leaking from top of tank or from fuel pump. Fuel components are plastic, and now 17 years old, so they are probably cracked from age. I have strong smell of fuel in my garage, and puddle of fuel under drivers side tank. This is a safety fire hazard gas can leak down to the exhaust system. ' Searching Corvette forums - this is a known issue many years. Searching nhtsa - there are a number of complaints logged by other C6 Corvette owners with the identical issue. GM must fix or at least share to fix this issue. The defect is caused by GM making the conscious decision to swap more durable metal parts for less durable plastic parts in the fuel pump/tank assembly. Please put pressure on GM to reach out to current Corvette owners and their dealership network to get this issue corrected and at a minimum share the cost with Corvette Owners. Let's not allow this issue be one that causes injury or even death. Thank you

Just bought 2008 corvette with 46,000 miles. Very strong smell of fuel in car and in garage after fill up. This issue is definitely a safety issue

Developed fuel leak above left side tank coming from known faulty fuel pump connector elbow at top of tank. Extreme gas fumes prevent parking in garage for fear of vapors igniting causing an explosion. Can not rule out possibility of drips or spray hitting hot exhaust. Will be seeking repair asap as this is not safe to drive or park in enclosed environment.

After refilling my car with gas, there was a strong fuel smell. As the fuel level dropped, the smell of gas went away. With this fuel smell there were strong vapors in my garage. I had to open the garage doors and let the garage air out before starting any of my vehicles I have in the garage. It got to the point I had to part the Corvette outside. I finally took it to a mechanic (Christain Brothers Automotive Huntsville Alabama), they found the fuel boost pump (driver's side) was cracked on top. I did not have the tools or capability to change the boost pump.

The other day from my garage i smelled a overtaking smell of gas coming from my 2008 Corvette with only 22,300 miles on it. I thought it was coming from my gas cap , so i replace the cap. Replacing the gas cap didn't help there was still a overwhelming gas smell coming from the left side of the car. I also notice when the gas tank drops below a 1/2 tank the smell seams to go away. I found out there are hundreds of complaints about this issue and that there was a special coverage adjustment issued covering this problem with the Primary Tank Module Flange Fuel and Vapor Leaks for a limited time and miles. I believe such a serious safety issue there should have been a recall to fix this problem by GM regardless of time and mileage. I have taken the car to Chevrolet dealer which has confirmed the problem.