2007 CHEVROLET HHR Complaints

POWER STEERING FAILS RANDOMLY WHILE DRIVING, STEERING BECOMES VERY DIFFICULT AND COULD BE VERY DANGEROUS.. PULLING OVER AND TURNING THE CAR OFF RESTARTS THE STEERING, BUT IT FAILS AGAIN RANDOMLY VERY VERY DANGEROUS. WHY NO RECALL?

THE CAR BEGAN HAVING DIFFICULTY STARTING AND WOULD REQUIRE MULTIPLE ATTEMPTS. UPON PARKING THE CAR AND GETTING OUT, I NOTICED A STRONG SMELL OF GAS THAT FADED VERY QUICKLY. THE FOLLOWING DAY THE TROUBLE STARTING CONTINUED AND THE GAS SMELL JUST GOT STRONGER AND STRONGER EVEN WHILE DRIVING. I PARKED THE CAR AND RETURNED AN HOUR LATER TO DISCOVER A WIDE PUDDLE OF FUEL DRIPPING FROM JUST IN FRONT OF THE REAR DRIVER'S SIDE TIRE. RESEARCH HAS SHOWN THAT THIS SEEMS TO BE HAPPENING TO A LOT OF HHR CUSTOMERS REGARDLESS OF LOCATION OR EXPOSURE TO ICE MELT CHEMICALS.

TAKATA RECALL MY HORN DON'T WORK THE SERVICE AIRBAGS STAYS ON. THE STRUTS BACK HATCH DON'T OPEN CRUISE CONTROL DON'T WORK CHECKED ALL MY FUSES AND THEY ARE ALL GOOD

LIKE MANY PTHERS, POWER STEERING INDICATOR ON DASH AND NO POWER STEERING. WORKS FOR FEW SECONDS WHEN CAR US RESTARTED THEN OUT AGAIN. HAVE REPLACED PUMP TWICE ALREADY .

WHILE DRIVING THE POWER STEERING FAILED AND THE INDICATOR CAME ON THE DASH INDICATING FAILURE. IF THE CAR IS TURNED OFF AND THEN RESTARTED THE POWER STEERING WILL WORK FINE FOR AWHILE BUT WILL EVENTUALLY FAIL AGAIN, USUALLY WITHIN 15-20 MIN. THIS STARTED AT 78,000MILES.

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING 30 MPH ON VARIOUS OCCASIONS, THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000.

STARTED DRIVING DOWN THE ROAD POWER STEERING LIGHT AND BELLS CAME ON AND LOST STEERING. ALMOST CRASHED INTO THE DITCH . LUCKILY NOBODY WAS COMING TOWARDS US OR BEHIND US . DO NOT DARE TO DRIVE MY CAR NOW I HAVE A YOUNG CHILD.

RUSTED FUEL LINES ON DRIVER'S SIDE NEAR THE REAR. THIS IS A MAJOR DESIGN FLAW WITH CHEVY HHRS. I NOTICED A BAD FUEL ODOR COMING FROM THE VEHICLE WHEN IT WAS PARKED. UPON FURTHER INVESTIGATION THERE IS A SOLID "DRIP" FROM WHERE THE LINE HAS RUSTED OUT. IT NEEDS TO BE FIXED BEFORE THERE IS A FIRE OR EXPLOSION AND SOMEBODY IS SERIOUSLY HURT OR KILLED.

THIS COMPLAINT CONCERNS A 2007 CHEVROLET HHR LT WHICH WAS PURCHASED AS A NEW VEHICLE. IT IS 'ALWAYS GARAGED'. IT HAS 36,1XX ORIGINAL MILES. ABOUT 2 WEEKS AGO WE BEGAN TO NOTICE 'CHUNKS' OF RUST GATHERING UNDER THE REAR OF THE VEHICLE. AN INSPECTION MADE BY SELF REVEALED EXTENSIVE RUST-OUT TO THE "REAR REINFORCEMENT BAR" (PART #10 IN THE ENCLOSED DIAGRAM). I CONTACTED "GM" VIA THEIR 'SOCIAL MEDIA CUSTOMER CARE CENTER', THOROUGHLY EXPLAINED THE ISSUE, AND WAS DIRECTED TO A LOCAL BUICK/GMC DEALERSHIP FOR AN EVALUATION, WITHIN HOURS I HEARD A NEGATIVE RESPONSE TO MY REQUEST FOR ASSISTANCE. SUBSEQUENT ATTEMPTS BY SELF HAVE NOT GIVEN ME A SATISFACTORY EXPLANATION AS TO THE "WHY" OF THIS RUSTED PART. THIS VEHICLE HAS ALWAYS BEEN MAINTAINED TO A HIGH DEGREE. THE EXAMINER TOLD ME HE DID NOT OBSERVE ANY OTHER RUST ISSUES ON OR UNDER THIS VEHICLE. KEEP IN MIND THAT I AM NOT AN 'AUTOMOTIVE' ENGINEER; BUT- TO MY 'UNTRAINED EYE' PART OF THE PROBLEM IS THAT THE PART IS DEEPLY HIDDEN WITHIN THE REAR BUMPER COVER; AND THE DESIGN OF THE REAR BUMPER COVER IS SUCH THAT IT FOSTERS THE COLLECTION OF DEBRIS FROM THE ROAD ON IT'S HORIZONTAL SURFACES. THIS DEBRIS THEN IS IN SITU WITH THE METAL PARTS OF THE ACTUAL 'REAR BUMPER'. GIVEN TIME THE DEBRIS RETAINS MOISTURE WHICH 'APPARENTLY' THEN COVERS THE METAL PARTS. ...AND ONE GETS THE RESULTS SHOWN IN THE PHOTOS. NONE OF THIS WOULD BE VISIBLE UNLESS A PERIODIC, CAREFUL EXAMINATION OF THE HIDDEN PARTS WERE TO BE MADE BY THE OWNER/OPERATOR OF THE VEHICLE. A "POSSIBLE" MEASURE TO BE TAKEN WOULD BE FOR GENERAL MOTORS TO EDUCATE/INFORM OWNER/OPERATORS AS TO THE POTENTIAL FOR A PROBLEM. ANOTHER "POSSIBLE" SOLUTION, WERE THIS A VEHICLE STILL IN PRODUCTION (AND NOT YET ANOTHER GM 'ORPHAN' CAR) WOULD BE, OF COURSE, TO CORRECT THE APPARENT, ORIGINAL 'DESIGN DEFICIENCY'.

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE AT A FUEL STATION, A SMELL OF FUEL WAS DETECTED FROM THE VEHICLE. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED A LEAK IN THE FUEL LINE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NEITHER DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.