2007 CHEVROLET HHR Complaints

The fuel line rusted causing it to leak. We discovered it when we had some exhaust work done on the car. No one other then myself and the people that have done the exhaust work. There was no warning of the issue.

Car has developed a fuel leak once again in the rear of the vehicle. this is the second time a fuel leak has been noted. the first time the mechanic replaced a portion of the line that had corroded and was leaking fuel near the driver rear tire. now the leak is in another section of the original pipe near the fuel tank. this is poor quality and engineering.

Power steering went out while I was driving and it put me in danger and other drivers because it was hard to control the vehicle, the steering wheel was really tough to turn. The vehicle wasn't inspected by a professional because the problem just occurred.

Power steering lights up and I am unable to turn the steering wheel. When I shut the motor down and start back up, the steering starts working again. This has been doing this for about 4 years now. I took it to White Allen Chevrolet when it first started happening and they told me that they drove it around and that it did not happen while they test drove the car. It happens intermittingly. I never know when it is going to happen. When it first started, it only happened about once every six months or so. Now it is happening every time I am in the car. Sometimes when I pull out onto a street and into traffic the power steering light comes on and I have to find a spot to get off the street so that I can turn the motor off and restart the engine. Today 09/18/2025, it cut off 3 times. I am checking to see if there is a recall on this model for the power steering. I have found out that it does not use power steering fluid but that it has a motor under the steering wheel that controls the power steering.

My power steering keeps going out. It randomly makes it hard to turn which could cause a crash. It's common in other hhr models, mine has not been inspected personally yet. It has a chime and then the console says "power steering". There were no signs before it started. It goes away when you restart the car but will come back randomly. I was advised by an auto repair place to replace the battery, but it didn't help.

Power steering motor went out. Went to the dealer to get special coverage 14119 ( I was aware of the issue ). Dealership refused to do work for free as stated in service bulletin. Called GM Corporate and they also said work would would not be done for free. 14119 specifically stated that power steering motor would be changed and I quote " at no cost to the customer " unquote. They want $175 just to look at my vehicle. When does the " at no cost to the customer " come in, apparently we seem to have forgotten that. I would like some legal clarification to this from the nhtsa.

The fuel line on the left back side of the car (back drivers side) was leaking fuel when it was in parking or sitting and idling. Noted fuel smell when car started up and was idling, car was taken to independent mechanic, fuel line was broke in 2 places. It was broke close by the wheel are and the other spot was back by the exhaust

Fuel line leaking next to exhaust. This is very dangerous and could kill someone. Bad design on Chevy's part.

Fuel leak coming from the Left (Drivers Side) of the vehicle in the area of the rear wheel. There was a strong odor of fuel, Fuel was observed dripping to the ground under the vehicle in front of the Left rear wheel. This condition was observed only when the vehicle was running and in park. The condition does not seem to happen when the vehicle is off and not running. No repair has been made yet , vehicle can be inspected in its current condition. This is a severe safety concern of ignition/explosion due to a fuel leak; risk of property damage or even death. This problem has not been addressed yet to a dealer or local mechanic as of yet . Failed component has not yet been inspected by GM, Police or insurance. No warning lamps or messages were illuminated on dashboard, prior to failure, vehicle did have some difficulty starting, possibly due to this problem, but it did start.

Fuel line leak. My fuel line has cracked in multiple places and needs to be replaced entirely. The leak was consistent, with a constant stream leaking out when in operation and for several minutes after stopping the engine. The odor of gasoline was strong from inside of the vehicle when in operation and large puddles of gas were visible on the ground afterwards when I first noticed the issue. My repair quote is about $500 to get the line replaced entirely.