2005 CHEVROLET MALIBU Complaints

A/C CONTROL HEAD FAILED RIGHT AFTER WARRANTY EXPIRED. I PAID TO HAVE IT REPLACED, AND HAVE HAD IT REPLACE 3 OTHER TIMES NOW. THERE IS DEFINITELY A DESIGN FLAW WITH THIS PART. *TR

DRIVERS SIDE ELECTRIC SEAT ADJUSTMENT HAS A WELD BROKEN. THIS MAKES ADJUSTING THE SEAT IMPOSSIBLE. THE SEAT FAILS TO ADJUST ON THE RIGHT SIDE. IT IS LOP-SIDED AND NO LONGER TO COMFORTABLE. I BOUGHT MY MALIBU BRAND NEW IN MARCH OF 05. *TR

HAVE HAD NUMEROUS WARRANTY WORK DONE. PURCHASED CAR 4 MONTHS AGO WITH 24,000 MILES NOW HAS 28,000. 6 WARRANTY REPLACEMENTS. AROUND 25,000 STARTED CAR AND STEERING WHEEL WAS TURNING VIOLENTLY. SHUT CAR OFF AND IT WAS FINE. LATER NOTICED STEERING WAS LOOSER AND THUMPING NOISE. CHEVY REPLACED STEERING GEAR. NOW AT CURRENT MILEAGE DID THE SAME THING HAS HAPPENED AND REPLACING ANOTHER COMPONENT IN STEERING. THIS IS VERY DANGEROUS. WHEN DRIVING AROUND TURNS IT FELT LIKE I HAD NO CONTROL OVER CAR. NOW THAT MY WARRANTY IS OUT MY WHEN I PUT MY CAR INTO D HALF THE TIME IT WILL JUMP INTO GEAR AND SOMETIMES IT GETS STUCK OR WANTS TO STOP AT R. A CAR WITH 28,000 MILES SHOULD NOT BE HAVING THIS KIND OF TROUBLE. I CAN ONLY IMAGINE WHAT IT WILL BE LIKE WITH 75,000 MILES ON IT. *TR

NOTICED BOTH FRONT TURN SIGNALS/DAYTIME RUNNING LAMPS YELLOW COVERS WERE MELTED. IT HAD DISCOLORED LIGHT LENS DUE TO APPARENT EXTREME HEAT. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING COLUMN MAKES RANDOM KNOCKING NOISES. HE DISCOVERED TSB NUMBER 1973984, WHICH IS IDENTICAL TO THE FAILURE HE IS EXPERIENCING. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS AND THE RECOMMENDED SOLUTIONS IN THE TSB WERE HEEDED; HOWEVER, THE FAILURE PERSISTS. THE CONTACT IS CONCERNED THAT HIS STEERING COLUMN WILL EVENTUALLY FAIL COMPLETELY. THE FAILURE MILEAGE WAS 18,000 AND CURRENT MILEAGE WAS 48,000.

WE HAVE A 2005 CHEVY MALIBU WITH 39,000 MILES. MY WIFE DRIVES THE CAR NORMALLY BUT I DROVE THE CAR FOR A FEW WEEKS AND NOTICED A CLUNKING IN THE STEERING AT LOW SPEEDS WHEN TURNING. TAKING THE CAR INTO OUR MECHANIC IT WAS DIAGNOSED AS A ISSUE WITH THE INTERMEDIATE STEERING SHAFT WHICH HAD TO BE REPLACED. I DON'T THINK THIS PART SHOULD EVER GO OUT LET ALONE AT 39,000 MILES. IT IS A SAFETY ISSUE WITH THE CAR. THE MECHANIC TOLD US THAT CHEVY HAS HAD THIS ISSUE WITH MAY CARS AND TRUCKS AND HAS KNOWN ABOUT THE ISSUE. *TR

ACCORDING TO THE DEALER THIS VEHICLE HAS A DEFECTIVE RACK AND PINION THAT IS BASED UPON ENGINEERING AND COULD CAUSE A LOSS OF CONTROL STEERING WHILE DRIVING THE VEHICLE. A LOUD POPPING NOISE IS HEARD WHILE TURNING LEFT OR RIGHT AND A SNAPPING IS HEARD WHEN SLOWING DOWN AND BREAKING. A LOOSE RATTLE ALSO OCCURS IN FRONT END WHILE DRIVING ON PRIMARY OR SECONDARY ROADS. CAR JUMPS AND STEERING JERKS WHEN HITTING A BUMP ON PAVED ROADWAYS. CAR HAS BEEN TAKEN IN FOR REPAIRS THREE TIMES. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHEN TURNING THE STEERING WHEEL, THE CONTACT HEARD A POPPING SOUND. THE FAILURE BEGAN SIX MONTHS AGO AND NOW IT IS CAUSING THE POWER STEERING TO FAIL. THE FAILURE WAS VERY SUBTLE AT FIRST, BUT NOW THE POWER STEERING FAILS FOR DAYS AT A TIME. THE AIR CONDITIONING WOULD ACTIVATE ON AND OFF, BUT NOW IT DOES NOT WORK AT ALL. THE DEALER STATED THAT THE POWER STEERING MODULE AND AIR CONDITIONING RESISTOR NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE CONTROL PANEL IS WARM TO THE TOUCH AFTER DRIVING FOR SOME TIME. THE VEHICLE IS CURRENTLY WITH THE DEALER AND THE REPAIR WILL COST OVER $900. THE CURRENT MILEAGE WAS 70,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 09/10/08. *LJ THE CONSUMER STATED THE SHOCKS WENT BAD, THE TIE ROD ENDS HAD TO BE REPLACED, THE CD BECAME STUCK IN THE CD PLAYER. THE REAR CALIPERS HAD TO BE REPLACED AND THE STARTER WORKED INTERMITTENTLY. UPDATED 09/12/08. *JB

I OWN A 2005 CHEVY MALIBU LS V6, THE BRAKE PEDAL GRINDS WHEN YOU PRESS IT, THEN IT IS HARD TO GET THE CAR INTO GEAR, THE BRAKE LIGHTS WILL STAY ON OR NOT COME ON AT ALL. I WAS TOLD BY THE DEALERSHIP WHEN UNDER WARRANTY THAT THEY HAD TO PLACE THE ENTIRE COMPUTER SYSTEM BACK IN OCT 2006, BUT IT IS CONTINUING TO HAVE THE SAME PROBLEMS THAT IT DID IN 2006. *TR

A FRIEND OF MINE HAS A 05 CHEVY MALIBU . I SEE AN INVESTIGATION WAS DONE ON THE 04'S #PEO4031 ELECTRIC POWER ASSIST SYSTEM . I HAVE PERSONALLY HAD IT GO OUT ON ME TWICE . AND I COULD BARELY STEER THE CAR AND ALMOST GOT INTO A WRECK...... I WEIGH 190 LBS. MY GIRL FRIEND WEIGHS 130 LBS.... PEOPLE ARE GOING TO GET IN WRECKS AND DIE BECAUSE OF THE EPS SYSTEM. AND YOU ARE AWARE OF IT....... DOES THE S IN NHTSA STAND FOR SAFETY ??? THANK YOU FOR YOUR TIME . *TR