2005 CHEVROLET SILVERADO Complaints

AIR BLOWS COLD ON DRIVER SIDE AND EXTREMELY HOT ON DRIVERS SIDE WITH DUAL CONTROLS BOTH SET TO COOL. SEEMS TO BE A VERY COMMON PROBLEM ACCORDING TO MANY PEOPLE ON THE FOLLOWING WEBSITE AND UNABLE TO BE FIXED BY DEALERS. HTTP://AUTOFORUM.CLASSIFIEDS1000.COM/CHEVROLET-SILVERADO_1500_PICKUP/DUAL_AC_BLOWS_COLD_AIR_ON_PASSENGER_BUT_HOT_ON_DRIVER. *TR

I HAVE A 2005 CHEVROLET SILVERADO. I KEPT SMELLING AN ODOR OF SOMETHING BURNING BUT COULD NOT FIND WHERE IT WAS COMING FROM UNTIL RECENTLY WHEN MY FAN MOTOR STOPPED WORKING. I HAD BEEN HAVING PROBLEMS WITH THE SWITCH NOT WORKING IN ALL POSITIONS. I CALLED THE DEALERSHIP TO INQUIRE ABOUT THE PRICE AND AVAILABILITY OF THE SWITCH. THE PARTS DEPT. INFORMED ME THAT IT WAS MOST LIKELY THE FAN RESISTOR OR THE PLUG BECAUSE THEY HAVE HAD SEVERAL THAT NEEDED REPLACED. WHEN I LOOKED UNDER THE DASH I FOUND WHAT HAD BEEN CAUSING THE SMELL. THE RESISTOR SHOWED SIGNS OF BEING OVERHEATED AND THE WIRE HARNESS WAS BURNT FOR APPROXIMATELY 6 INCHES. THIS IS A FIRE HAZARD AND IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS EITHER INJURED OR KILLED DUE TO THIS DEFECTIVE RESISTOR/PLUG. *TR

LETTER FROM SENATOR ON BEHALF OF CONSTITUENT RE PROBLEMS WITH 2005 CHEVY SILVERADO. DOT/I#2010-1208. *KB THE CONSUMER STATED HIS VEHICLE HAS SEVERE CORROSION ON THE FRAME. WITHIN TWO YEAS, THE ENTIRE UNDERCARRIAGE HAD CORRODED, WHICH CAUSED THE BRAKES AND POWER STEERING TO FAIL CATASTROPHICALLY. THE CONSUMER SUED ALLEGING BREACH OF WARRANTY. THE CASE WAS HEARD, HOWEVER GM EXPERTS TESTIFIED THAT THE CORROSION WAS CAUSED BY SEA AIR AND THEY WERE NOT UNDER ANY OBLIGATION TO COVER CORROSION CAUSED BY THE ENVIRONMENT. THEY ALSO TESTIFIED THAT THE CORROSION WAS PRIMARILY COSMETIC AND THAT THE VEHICLE WAS IN GOOD DRIVING CONDITION. THE CONSUMER STATED TWO DAYS LATER, AS HE ATTEMPTED TO DRIVE THE VEHICLE TO A REPAIR SHOP, THE BRAKE LINES RUPTURED AND THE DRIVE SHAFT SHEARED IN HALF, NEARLY CAUSING A MAJOR ACCIDENT. *JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE AIR CONDITIONER ON, THE DRIVERS SIDE VENT WAS RELEASING HOT AIR WHILE THE PASSENGER SIDE VENT CONTINUED TO RELEASE COLD AIR. THE CONTACT SHUT THE VEHICLE OFF AND AFTER RESTARTING IT THE AIR CONDITIONER BEGAN TO FUNCTION PROPERLY. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE CONTACT STATED THAT OVER TIME THE FAILURE BECAME PROGRESSIVELY WORSE. THE FAILURE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER. THE CONTACT WAS INFORMED THAT THERE WAS A TECHNICAL SERVICE BULLETIN RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 71,000. THE VIN WAS UNAVAILABLE.

SPEEDOMETER INOPERATIVE. EVERYTIME THE VEHICLE IS DRIVEN I HAVE NO WAY OF TELLING HOW FAST I AM TRAVELING. *TR

AT AROUND 37,000 MILES THE SPEEDOMETER STARTED STICKING AND AROUND 45,000 MILES IT COMPLETELY WENT OUT AND HAS BEEN STUCK AT 120 MPH EVER SINCE. I TOOK IT TO THE CHEVY DEALERSHIP AND THEY TOLD ME IT WOULD COST AROUND 800.00 DOLLARS TO FIX. I CALLED AND COMPLAINED TO GM CUSTOMER SERVICE, AT WHICH TIME THEY DID NOTHING BUT TOLD ME TO TAKE IT IN AND GET IT REPAIR AT MY EXPENSE. I HAVEN'T HAD THE MONEY TO HAVE IT REPAIRED SO FAR SO I HAVE BEEN DRIVING WITHOUT IT. I THINK CHEVY SHOULD RECALL THE INSTRUMENT CLUSTERS AND FIX THE PROBLEM AT THEIR OWN EXPENSE. *TR

SPEEDOMETER FAILS TO REGISTER ACTUAL SPEED OF DRIVING -- WILL SHOW 120 WHEN DRIVING 70, 90 MPH WHEN DRIVING 30MPH, 15 MPH WHEN STOPPED AT A LIGHT. MAKES HIGHWAY DRIVING HAZARDOUS BECAUSE I AM PRONE TO DRIVING SLOWER THAN TRAFFIC. ALSO CONCERNS ABOUT ACCURACY OF THE ODOMETER BECAUSE OF THIS PROBLEM. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHEN DRIVING THE VEHICLE THE CONTACT NOTICED THAT THE SPEEDOMETER WOULD DISPLAY A SPEED OF 120 MPH WHEN THE CONTACT WAS ACTUALLY TRAVELING AT A SPEED OF 45 MPH. THE DEALERSHIP WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE VEHICLE WAS NOT REPAIRED AT THE TIME OF COMPLAINT. THE FAILURE AND CURRENT MILEAGES WERE 90000. UPDATED 07/19/10 *BF UPDATED 07/21/10.*JB

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO DIESEL ENGINE . WHILE DRIVING AT SPEEDS AS LOW AS 50 MPH, THE VEHICLE SPEEDOMOTER WOULD INDICATE THE VEHICLE WAS TRAVELING AT SPEEDS OF 120 MPH AND WOULD STICK AT THIS MILEAGE. THE VEHICLE WAS TAKEN TO THE DEALER, HOWEVER NO REPAIRS WERE MADE TO THE VEHICLE. THE CONTACT WAS NOT PRESENT AT THE TIME THE VEHICLE WAS TAKEN TO THE DEALER AND WAS UNSURE AS TO WHAT WAS ADVISED IN REFERENCE TO THE VEHICLE. THE FAILURE PERSISTED. THE FAILURE AND CURRENT MILEAGES WERE 96,000. UPDATED 06/02/10. *LJ THE CONSUMER WAS INFORMED THE PROBLEM WAS CAUSED BY A WIRING CLUSTER IN THE DASH. UPDATED 06/28/10*JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHEN THE CONTACT DROVE THE VEHICLE AT VARIOUS SPEEDS, SHE NOTICED THAT THE DASHBOARD PANEL FAILED TO OPERATE PROPERLY. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 115000.