2005 CHEVROLET SILVERADO Complaints

WHILE DOING AN OIL CHANGE ON MY 2005 PU SILVERADO I NOTICED LARGE RUST BUILD UP ON THE BRAKE LINES' THIS IS NOT THROUGH NEGLECT ON MY PART, BUT IS SUFFICIENT ENOUGH TO CAUSE SERIOUS CONCERN. MY SON IN LAW WITH CHEVY 2002 HAD A SIMILAR PROBLEM WHEN HIS BRAKES FAILED ON A HILL WHICH CAUSED ME TO CHECK MINE.THIS IS EXTREMELY DANGEROUS AND GM SHOULD BEAR THE RECALL EXPENSE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVING DOWN HIGHWAY ROAD WHEN SEVERAL DEER RAN IN FRONT OF VEHICLE. SLAMMED ON BRAKES AND THE PEDAL, AFTER A FEW SECONDS, WENT TO THE FLOOR. NOTICED BIG PUDDLE OF FLUID THE NEXT DAY UNDER CAB OF TRUCK. STARTED TRUCK AND HAD NO BRAKES AT ALL. HAD THE TRUCK INSPECTED BY LOCAL REPAIR SHOP AND WAS INFORMED THAT ALL OF THE BRAKE LINES WERE RUSTY BEYOND THE POINT OF REPAIR. HAD TO HAVE A WHOLE NEW BRAKE LINE KIT INSTALLED. *TR

THE TRUCK HAS 110K MILES ON THE DURAMAX / ALLISON DRIVE TRAIN. THE DIESEL FUEL INJECTION PUMP FAILED UNEXPECTEDLY AND WITHOUT WARNING. THIS POWERTRAIN COMBINATION SHOULD BE CAPABLE OF 500K MILES WITHOUT PROBLEMS LIKE THIS. THIS PUMP SHOULD NOT FAIL AFTER NORMAL USE IN ONLY 110K MILES. NOTHING BUT EXCUSES AND OTHER NOT POSSIBLE REASONS FOR THE POOR ENGINEERING AND MANUFACTURING EXHIBITED IN THEIR PRODUCT. THEY SAID THE METHANOL WATER INJECTION SYSTEM CAUSED THE FUEL INJECTION PUMP TO FAIL. METHANOL (NON CAUSTIC FLUID) IS INJECTED AIR SIDE OF THE ENGINE AND DOES NOT MIX WITH THE INJECTED FUEL UNTIL THE ENGINE CYLINDER. THE FUEL INJECTION PUMP SUPPLIES FUEL TO THE INDIVIDUAL INJECTORS THAT THEN IN TURN SUPPLIES THE HIGH PRESSURE FUEL TO THE CYLINDERS. IF THIS CONDITION WAS TO HAPPEN ON THE ROAD PULLING A TRAILER / HEAVY LOAD IN HILLS OR OTHER CONFINED ROADWAYS PEOPLE COULD BE INJURED OR KILLED BY THE SUDDEN LOSS OF POWER AND CONTROL. GM BUSINESS PRACTICES ARE GOING TO CONTINUE TO KILL AND HURT PEOPLE. *TR

BRAKE PEDAL PUSH TO THE FLOOR, OIL COMING OUT ONTO THE GROUND, BRAKE LINES RUSTED OUT IN MANY PLACES UNDER THE HOOD. *JS

HAD TO ADD COOLANT OVER A TIME.....NO EVIDENCE OF A LEAK ON MY DRIVEWAY OR ANY OTHER PLACE. STARTED TRUCK ONE MORNING AND HEARD CLICKING NOISE COMING FROM ENGINE. I OBSERVED WATER COMING FROM THE MUFFLER. TOOK VEHICLE TO DEALER ON APRIL 22, 2014. ( MILEAGE 84241) DEALER FOUND BLOWN HEAD GASKET AND SEALS, ONE CRACKED HEAD AND WATER IN OIL. REPAIRS DONE: COMPLETE VALVE JOB (REPLACE HEAD GASKET, SEALS & OTHER ASSOCIATED PARTS), REPLACE BROKEN BOLTS, REPLACE COOLANT HOSES, RADIATOR & HEATER HOSES AND THERMOSTAT ETC.. WAS NOT ADVISED BY SERVICE CONSULTANT OF ANY RECALLS OR BULLETINS FOR 2005 SILVERADO. THIS IS LOW MILEAGE FOR THIS KIND OF ENGINE PROBLEM. REPAIR COST: $3683.92 MARTIN CHEVROLET *** TORRANCE, CALIF. *TR

I WAS DRIVING HOME FROM WORK WHICH IS 1.5 MILES, WHEN I HEARD A THUMPING SOUND, AND IT SEEMED AS IF MY REAR WHEELS WERE NOT TURNING. I HAD A FRIEND TOW IT TO THE DEALER COX CHEVROLET IN BRADENTON, FL, AND THEY TOLD ME, THAT THE REAR END (SPIDER GEARS, AND BEARINGS) WERE NEEDING REPLACING BUT ARE NOT PART OF THE POWER TRAIN SO IT WAS NOT COVERED UNDER WARRANTY, AND IT WOULD COST ME $2600. I HAD HIM TOW IT AGAIN TO A LOCAL TRANSMISSION SHOP AND THEY TOLD ME IT WAS COMMON IN THAT YEAR OF CHEVY TRUCKS. I ALSO NEEDED BOTH CLUTCHES REPLACED IN EACH REAR WHEEL, COST WAS WELL UNDER THE DEALERS CHARGE. THE OWNER OF THE TRANSMISSION SHOP INFORMED ME THAT HE HAS REPLACED A COUPLE 100 OF THESE AND THERE SHOULD BE A RECALL ON THEM. I COULD HAVE BEEN IN AN ACCIDENT WHEN THE WHEELS LOCKED. *TR

WAS DRIVING DOWN ROAD LOOKED DOWN AT MY SPEEDOMETER AND IT WAS PEGGED OUT OVER 120 MPH I WAS ONLY GOING ABOUT 15MPH SO I STOPPED AND TURNED OFF TRUCK AND SPEEDOMETER WENT DOWN TO 60 NOT 0 AS IT SHOULD I TURNED IT BACK ON AND TOOK OFF IT DID SAME THING ALL WAY OVER 120 MPH SO WHEN I GOT WHERE I WAS HEADING AND TURNED TRUCK OFF AGAIN SAME THING JUST DROPPED TO 60 SO I KEPT TURNING KEY ON AND OFF AND IT WOULD DROP ABOUT 5MPH EACH TIME UNTIL IT GOT TO 0 WENT TO DEALER HE SAID LOT OF PROBLEMS WITH THIS MODEL TRUCK I WOULD NEED A NEW DASH AND IT WOULD COST ME $1200 I THINK GM SHOULD FIX THESE TRUCK IT THE LAW TO HAVE A WORKING SPEEDOMETER ON YOUR TRUCK THANK YOU. *TR

REAR BRAKE LINE APPEARED RUSTY AND SCALY, THEN WHEN HIT MY BRAKES, THE PEDAL WENT TO THE FLOOR. I USED EMERGENCY BRAKE. I REPLACED REAR BRAKE LINE. ALL OTHER LINES APPEARED RUSTY AND SCALY. NOW, MY FRONT LEFT BRAKE LINE IS BEGINNING TO WEEP; IT'S MOIST AND IT GLISTENS WITH OIL. I WILL HAVE TO REPLACE IT SOON. ALL THE OTHER LINES IN THE TRUCK APPEAR TO BE THE SAME, RUSTY AND SCALY. I WILL NO DOUBT HAVE TO CONTINUE TO REPLACE EACH LINE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE ROTORS NEEDED TO BE REPLACED ON A REGULAR BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS NOT ABLE TO DIAGNOSE THE MULTIPLE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1000.

WAS ON HIGHWAY WHEN HEARD A NOISE AND PULLED OVER TO SEE A DOUGHNUT FOR A TIRE AND RUBBER PIECES TIED AROUND TAILPIPE,_E-BRAKE AND OTHER PARTS UNDERNEATH. DAMAGED REAR PANEL THE MILEAGE AT THE TIME WAS 30100MILES COULD'VE CAUSED A BAD ACCIDENT. ALSO BROKE A CLUSTER LOST ALL METERS ON DASH. *TR