2003 CHEVROLET SILVERADO 2500 Complaints

I WAS DRIVING DOWN THE ROAD AND DEPRESSED THE BRAKES TO STOP AND PULL INTO MY DRIVE WAY THE PEDAL WENT TO THE FLOOR AND THE BRAKES DID NOT STOP THE VEHICLE. AS A RESULT THE VEHICLE MADE CONTACT WITH MY GARAGE DOOR AND IT WAS DAMAGED IN THE INCIDENT. THIS INCIDENT IS COMPLETELY UNACCEPTABLE TO ME. THERE WERE NO WARNING LIGHTS PRIOR TO FAILURE. I HAVE TAKEN THE VEHICLE TO A SHOP AND THE LINES ARE RUSTED THROUGH. *TR

TO START OFF, MY BRAKE LINE ARE SEVERELY CORRODED AS THE WAS A NEW ENGLAND TRUCK FOR THE FIRST 8 YEARS OF ITS LIFE. AFTER SITTING OVERNIGHT, I WENT TO DRIVE MY TRUCK YESTERDAY. UPON STARTING IT, I RECEIVED THE MESSAGE "SERVICE BRAKE SYSTEM" ON THE DRIVER INFORMATION SCREEN. I ALSO NOTICED THE BRAKE LIGHT WAS ON AND THAT THE PEDAL WENT TO THE FLOOR. I WENT UNDER THE HOOD AND NOTICED THE BRAKE MASTER CYLINDER WAS EMPTY AND SEVERAL OF THE BRAKE LINES WERE WET WITH BRAKE FLUID. I HAD JUST CHECKED MY BRAKE FLUID (WITH ALL OF MY OTHER FLUIDS THIS WEEK AS I WAS ON A CAMPING TRIP WHEN THIS HAPPENED. I LOOKED THIS UP ON THE INTERNET WHEN I GOT HOME AND FOUND NHTSA ACTION NUMBER DP10003 THAT DISCUSSED THIS EXACT SAME ISSUE. PLEASE ADVISE ON THE STATUS OF THIS INVESTIGATION. THANK YOU. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD EQUIPPED WITH BF GOODRICH COMMERCIAL TIRES, SIZE: TA 245/75/R16. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE TREAD ON THE REAR DRIVER'S SIDE TIRE SEPARATED AND CAUSED THE TIRE TO EXPLODE. THE CONTACT WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE WITHOUT INCIDENT. THE CONTACT STATED THAT THE STRUT SUPPORT RODS AND THE DRIVER SIDE TAIL LIGHT BECAME DAMAGED FROM THE TIRE FAILURE. THE CONTACT SHIPPED THE TIRE TO THE MANUFACTURER FOR INSPECTION. THE MANUFACTURER STATED THAT THEY INSPECTED THE TIRE AND NOTICED THAT AN OBJECT HAD STRUCK THE TIRE AND CAUSED THE TREAD SEPARATION FAILURE. THE FAILURE MILEAGE OF THE TIRE WAS 23,000. THE VEHICLE FAILURE MILEAGE WAS 122,900. UPDATED 12/31/12 *BF THE CONSUMER STATED EBERHARDT TIRE WAS CONTACTED AND WAS ADVISED THAT THE MANUFACTURER HAD PROBLEMS WITH THAT TIRE AND WAS GIVEN THE INFORMATION TO REACH MICHELIN NORTH AMERICA. A MICHELIN REPRESENTATIVE STATED THAT THE TIRES ON THE VEHICLE WERE NOT APART OF THEIR VOLUNTARY RECALL. THE CONSUMER WAS GIVEN A CLAIM NUMBER AND CLAIM PACKET ANYWAY. EBERHARDT AND THE CONSUMER NOTICED THAT THE RIGHT FRONT TIRE HAD A LARGE PROTRUSION ON THE OUTER EDGE. THIS TIRE WAS IN THE COURSE SEPARATING.. THIS INFORMATION WAS DOCUMENTED ON THE REPLACEMENT RECEIPT FROM EBERHARDT'S TIRE. MICHELIN DENIED THE PROPERTY DAMAGE CLAIM CAUSED BY THE LEFT REAR TIRE. MICHELIN STATED THEIR INSPECTION REVEALED THAT A RADIAL BREAK THROUGH THE CASING IN THE CROWN AREA CAUSED BY AN IMPACT BY OBJECT OR OBSTRUCTION. UPDATED 1/7/2013*JS

I WAS DRIVING DOWN THE ROAD AT HIGHWAY SPEED (65MPH) AND THE FRONT RIGHT STEEL BRAKE LINE BURST AND I LOST MOST OF MY BRAKE FLUID. UPON LOOKING UNDER THE TRUCK FOR THE CAUSE OF THE PROBLEM, I NOTICED THAT ALL OF THE BRAKE LINES AND TWO OF THE FUEL LINES WERE BADLY CORRODED. I TOW TRAILERS OFTEN AND I'M THANKFUL I WASN'T TOWING OUR 11,000LB 5TH WHEEN CAMPER WHEN THIS HAPPENED OR THERE WOULD HAVE BEEN A HORRIFIC CRASH! I HAVE DONE QUITE A BIT OF RESEARCH AND NOTICED THAT THERE ARE QUITE A FEW COMPLIANTS ABOUT THE SAME PROBLEM FOR THIS MODEL YEAR PICKUP. IS THERE A RECALL AND HOW DO I GO ABOUT GETTING THIS FIXED? I AM OUT OF WORK ON MEDICAL LEAVE AND CANNOT AFFORD TO TAKE THE TRUCK TO THE SHOP AND "WAIT" FOR GM TO THINK ABOUT RE-EMBURSING ME. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500HD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH IN A PARKING LOT, THE BRAKE PEDAL WAS DEPRESSED AND WHEN ALL THE WAY TO THE FLOORBOARD. THE BRAKES FAILED TO STOP THE VEHICLE WHICH CONTINUED TO ACCELERATE. THE CONTACT MENTIONED THAT IN ORDER TO COME TO A STOP THE GEAR WAS SHIFTED INTO PARK. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE BRAKE LINES WERE COMPLETELY CORRODED. THE VEHICLE WAS NOT TOWED AND REMAINED AT THE LOCATION WHERE THE BRAKE MALFUNCTION OCCURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 70,101. UPDATED 12/3/2012 *JS

BRAKE LINE FAILURE DUE TO CORROSION. 2004 CHEVY SILVERADO 2500HD WITH 70,100 MILES MY 15 YEAR OLD WAS DRIVING THE VEHICLE PULLING INTO A PARKING SPOT AT A SHOPPING CENTER WITH HIS DAD IN THE PASSENGER SEAT. HE ATTEMPTED TO STOP AND VEHICLE BRAKES FAILED WITHOUT WARNING. NO DASHBOARD LIGHTS AND NO KNOWN CAUSE AT THE TIME. SUBSEQUENT FAILURE LOCATED AT LEFT FRONT WHEEL WELL AS CORRODED BRAKE LINES COMING ALONG CHASIS FROM BRAKE VALVE BODY MASTER CYLINDER. NO WARNING LIGHTS OF ANY KIND ON DASHBOARD. VEHICLE HAS NOT BEEN REPAIRED AS OF DATE OF INCIDENT (YESTERDAY). *TR UPDATED 11/13/12 *CN UPDATED 12/3/2012 *JS

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED THAT WHILE DRIVING 45 MPH AND ATTEMPTING TO BRAKE, THE VEHICLE WOULD NOT RESPOND. THE CONTACT NOTICED WHITE SMOKE COMING FROM UNDER THE HOOD AS VEHICLE STALLED WITHOUT WARNING. THE BRAKE LINES WERE FRACTURED AND CAUSED BRAKE FLUID TO LEAK. THE VEHICLE IGNITED IN FLAMES AND BURNED PARTS OF THE EXHAUST SYSTEM, THE INSULATION FIREWALL, THE WIRING HARNESS AND THE WHEEL WELL. THE FIRE DEPARTMENT WAS CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIR SHOP FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 207,000.

WHILE BACKING-UP TO UNLOAD A 24 FT BOAT, THE BRAKE PEDAL WENT TO THE FLOOR. STOPPED VEHICLE BY APPLYING EMERGENCY BRAKE. HAD VEHICLE TOWED TO CHEVROLET DEALER. COST $1836.15 TO REPLACE ALL BRAKE LINES, PLUS $85 FOR TOW. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET 2500 HD. THE CONTACT STATED THAT THE DRIVER CRASHED INTO ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THERE WERE NO INJURIES BUT THE VEHICLE WAS DESTROYED. THERE WAS A POLICE REPORT FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE CAUSE OF THE AIR BAGS WAS UNKNOWN. THE FAILURE MILEAGE WAS 139,000. THE VIN WAS UNAVAILABLE.

I WAS DRIVING HOME THURS. AUG 23, 2012 IN HEAVY TRAFFIC WHEN I HAD TO STOP SUDDENLY TO AVOID AN ACCIDENT. I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR WITH NO RESISTANCE. I DROVE THE TRUCK HOME WITH VERY LITTLE BRAKING POWER. WHILE AT HOME I INSPECTED THE TRUCK, AND FOUND A PUDDLE OF BRAKE FLUID ON THE GROUND UNDER THE DRIVERS DOOR. WHILE INSPECTING THE UNDERSIDE OF THE TRUCK I FOUND THAT THE BRAKE LINES JUST IN FRONT OF THE ABS MODULE HAD RUSTED COMPLETELY THROUGH. *TR