2005 CHEVROLET SILVERADO 2500 Complaints

2005 SILVERADO 2500 HD SPEEDOMETER MALFUNCTION. SPEEDOMETER REGISTERS VERY HIGH SPEEDS (I.E. 80 MPH), OR NO SPEED AT ALL (I.E. 0 MPH) REGARDLESS OF WHAT SPEED IS ACTUALLY BEING DRIVEN. *TR

MY 2005 DURAMAX DIESEL HAS REPEATEDLY HAD THE RIGHT REAR BRAKE/TAIL LIGHT GO OUT. I HAVE HAD THE BULB REPLACED ONCE BY DEALER, AND PAID FOR IT. AND THE REST OF THE 4 TIMES MY HUSBAND AND I HAVE REPLACED THE BULB AS THE DEALERSHIP COST TO REPLACE A BULB IS 5 X'S THE COST OF THE BULB. MY DURAMAX CURRENTLY HAS THE RIGHT REAR BRAKE/LIGHT BULB OUT. 2005 CHEVROLET, CURRENTLY HAS 40, 000 MILES. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH THE BRAKES WERE ENGAGED AND A SUDDEN LOSS OF POWER STEERING OCCURRED CAUSING THE VEHICLE TO SWERVE OFF OF THE ROAD. EXTREME PRESSURE WAS APPLIED TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN REFUSED TO INSPECT THE VEHICLE AND STATED THAT THEY WERE NOT RESPONSIBLE FOR ANY UNDER CARRIAGE CORROSION REGARDLESS OF THE SEVERITY. THE MANAGER AGREED TO REPLACE THE CORRODED POWER STEERING TANK AND REPAIR THE BRAKES. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY DO NOT COVER ANY CORROSION UNDER THE SERVICE WARRANTY DUE TO THE ENVIRONMENT. THE MANUFACTURER ALSO STATED THAT THE WARRANTY WOULD NOT APPLY TO CORROSION FAILURES WHERE THE RESIDENCE WAS CLOSE TO A BEACH WITH EXPOSURE OF SALT IN THE AIR. THE FAILURE MILEAGE WAS 23,000. THE CURRENT MILEAGE WAS 28,000. UPDATED 05/28/10. *LJ UPDATED 10/12/10

IN FEBRUARY, 2005 I PURCHASED A 2005 CHEVY SILVERADO 2500 HD FWD PICKUP. FROM DAY 1 I HAD BRAKE FADING WITH THE VEHICLE. I COMPLAINED TO THE DEALER WHEN EVER I BROUGHT IT IN FOR SERVICE TO NO AVAIL. IN JULY 2008, WITH 18,359 MILES ON IT I WAS TOLD "THE REAR ROTORS WERE RUSTED TO THE POINT IT WAS AFFECTING BRAKING POWER" AND HAD TO BE REPLACED. THE FRONT ROTORS WERE ALSO RUSTED AND HAD TO BE REPLACED IN JUNE 2009, WITH 25,001 MILES ON IT, I AGAIN HAD BRAKE PROBLEMS AND 3 BLEEDERS WERE RUSTED AND RUINED AND HAD TO BE REPLACED ALONG WITH ONE CALIPER. AT THE SAME TIME THE REAR BRAKE PADS HAD TO BE REPLACED AND THE ROTORS RESURFACED. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE AIR BAG LIGHT ILLUMINATED AND STAYED ON. THE VEHICLE HAD NOT BEEN TAKEN TO AN AUTHORIZED DEALERSHIP FOR DIAGNOSIS AT THE TIME OF THE COMPLAINT. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM THAT THERE WERE NO RELATED RECALLS AND THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS 34,455. THE CURRENT MILEAGE WAS 34,469.

2005 CHEVY 2500HD DIESEL - THE NUMBER 2 AND NUMBER 7 INJECTOR WIRE HARNESS IS NOT MOUNTED PROPERLY. IT RUBS THROUGH AND PUTS THE TRUCK INTO WHAT THEY CALL "LIMP MODE". IT ONLY ALLOWS THE MOTOR TO GOT UP TO 2000 RPM. THIS HAPPENED TO ME TWICE WITH MY CURRENT TRUCK. THE SECOND TIME I WAS RUNNING DOWN INTERSTATE I-80 @ 70MPH ON CRUISE CONTROL. IT AUTOMATICALLY BEGAN DOWNSHIFTING AND SLOWING DOWN. I WAS LUCKY A SEMI WASN'T BEARING DOWN ON ME. GO TO DIESEL PLACE OR ANY OTHER BLOG ON CHEVY DURMAX DIESELS AND DO A SEARCH FOR NO. 2 & 7 WIRE HARNESS FOR THE SECOND GENERATION DIESEL (2004.5-2005) - THEY MUST HAVE FIXED IT AFTER THAT. *TR

ON TWO DIFFERENT OCCASIONS WITH MY 2005 CHEVROLET SILVERADO 2500 I EXPERIENCED POWER STEERING AND BRAKE LOSS AFTER STARTING THE ENGINE AND BEGINNING TO DRIVE.. STEERING WAS VERY HARD AND I HAD TO "STAND" ON THE BRAKE PEDAL TO STOP THE VEHICLE. AFTER A FEW MINUTES IT ALL BEGAN TO WORK AGAIN BUT I WAS WITHOUT POWER STEERING AND BRAKES FOR SEVERAL MINUTES. I TOOK IT TO MY DEALER AND THEY REPLACED THE BRAKE UNIT AND REPLACED A HOSE ON THE POWER STEERING PUMP. PARTS ARE PROBABLY NOT AVAILABLE AS I LEFT THEM AT THE DEALER. NOW I AM GETTING A SLIGHT SURGE WHEN BRAKES ARE APPLIED AND THIS IS ONE OF THE EVENTS THAT HAPPENED BEFORE THE FAILURE CAUSING ME TO FEAR THAT FAILURE MIGHT HAPPEN AGAIN. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET K2500 PICKUP TRUCK. WHILE DRIVING 5 MPH THE VEHICLE SHIFTED INTO NEUTRAL GEAR WHILE IT WAS IN DRIVE. HE THEN TRIED TO SHIFT GEARS AND WAS UNABLE TO DO SO. THE ENGINE WAS REVVING AFTER HE TRIED TO CHANGE GEARS AND WITHIN A FEW MINUTES, HE WAS ABLE TO CONTINUE DRIVING NORMALLY. THE DEALER WAS CONTACTED AND STATED THAT THE WARRANTY EXPIRED AND MADE NO REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED BY ANOTHER MECHANIC AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 52,000 AND THE CURRENT MILEAGE WAS 54,000. UPDATED 04/01/10. *LJ

I TOOK MY 2005 CHEVROLET SILVERADO PICK UP IN FOR A EXHAUST LEAK. THE MANIFOLD BOLTS ROTTED AWAY. 3 BOLTS HOLDING RIGHT AND LEFT EXHAUST MANIFOLDS IN PLACE. VARY VERY UNSAFE, ONE GOOD BUMP IN THE ROAD AND IT WOULD DROP. VEHICLES WITH LESS THAN 30,000 MILES HAVE THE SAME PROBLEM. GM KNOWS ABOUT THE PROBLEM AND SHOULD HAVE CONTACTED IT'S CUSTOMERS. VARY DANGEROUS. FIRE, ACCIDENT OR EXHAUST FUMES. NOT GOOD AT ALL!! *TR

SPEEDOMETER FAILURE--SPEEDOMETER WOULD READ INCORRECTLY AND NOW HAS COMPLETELY FAILED. NOTHING TO DATE HAS BEEN DONE TO CORRECT THE PROBLEM. *TR