2003 CHEVROLET SILVERADO 2500 Complaints

BRAKING WHILE PULLING A TRAVEL TRAILER AND TWO SEPARATE STEEL BRAKE LINES RUPTURED. IN PROCESS OF REPLACING ALL STEEL LINES DO TO HIGH LEVEL OF CORROSION. *TR

5/12/2011 2003 CHEVROLET 2500 HD 85,000 MILES WHILE APPROACHING STOPPED TRAFFIC BEGAN TO BRAKE WHEN BRAKE PEDAL WENT ALL THE WAY TO FLOOR AND HAD NO BRAKING ABILITY. STRUCK THE AUTOMOBILE IN FRONT OF ME AT APPROX. 20 MPH WHICH STRUCK THE AUTOMOBILE IN FRONT OF THEM. LUCKILY NO INJURIES REPORTED AT TIME OF INCIDENT. $1,500 REPAIRS TO FRONT END OF MY TRUCK AND UNKNOWN AMOUNT OF DAMAGES TO REPAIR OTHER AUTOMOBILES. BOTH WERE DRIVABLE ALTHOUGH APPROX. SAME AMOUNT OF DAMAGE AS MINE. TRUCK WAS TOWED FROM SCENE. DEALERSHIP FOUND BRAKE LINE HAD RUPTURED DUE TO CORROSION. ALL BRAKE LINES HAD TO BE REPLACED, $1,600. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 70 MPH, HE APPLIED PRESSURE TO THE BRAKE PEDAL AND THE PEDAL DEPRESSED TO THE FLOOR. THE VEHICLE WAS COASTING TO A STOP WHEN SMOKE BEGAN TO RISE FROM THE ENGINE. THE CONTACT ENGAGED THE PARKING BRAKE TO STOP THE VEHICLE. THE CONTACT EXAMINED THE VEHICLE AND NOTICED THE BRAKE LINES FRACTURED UNDER THE ENGINE COMPARTMENT, CAUSING A SMALL FIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS TOLD THE BRAKE LINES WERE VERY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 160,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE BRAKES WERE APPLIED BUT THE VEHICLE WOULD NOT STOP. THE VEHICLE ROLLED TO A STOP WITH THE ASSISTANCE OF THE BRAKES ON A TRAILER IT WAS HAULING. THE CONTACT EXITED THE VEHICLE AND NOTICED BRAKE FLUID LEAKING FROM UNDER THE FRONT DRIVERS SIDE DOOR. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: DP10003 (SERVICE BRAKES, HYDRAULIC). THE FAILURE AND CURRENT MILEAGES WERE 55,000.

I'VE HAD IT LESS THAN 1 YEAR, AND HAS UNDER 90,000 MILES. I LEFT MY HOUSE AND GOT 1/4 MILE DOWN THE STREET AND THE ENTIRE CAB OF THE TRUCK FILLED WITH SMOKE. HAD TO CALL 911 AND HAVE THE FIRE DEPARTMENT COME TO THE SCENE. AN ELECTRICAL FIRE ABOVE THE HEAD LINER KILLED THE ELECTRONICS IN THE ENTIRE VEHICLE. NO LIGHTS, POWER SEATS, RADIO, DASH CLUSTER, EXTERNAL LIGHTS AND SIGNALS, HORN, WINDOWS,NOTHING WORKS, ENGINE WONT START. THE FIRE APPEARS TO HAVE STARTED NEXT TO THE ON STAR SPEAKER IN THE HEADLINER. *TR

CORRODED BRAKE LINES ON 2003 CHEVROLET SILVERADO 2500 HD ALMOST CAUSED AN ACCIDENT. *TR

INSTRUMENT CLUSTER FUEL GAUGE FAILURE. THIS HAPPENS FREQUENTLY, SOMETIMES EVERY DAY. NOTHING HAS BEEN FOUND TO CORRECT THE FAILURE. THE FUEL GAUGE OFTEN SHOWS INACCURATE FUEL LEVEL READINGS. IT HAPPENS MORE OFTEN WHEN THE CAR IS WARM THAN WHEN IT IS COLD. IT HAPPENS A LOT WHEN THE CAR IS HOT (E.G. HEATER IS ON VERY HIGH OR IN THE SUMMER). I'M AFRAID THAT THE FUEL GAUGE WILL TELL ME THAT I HAVE MORE FUEL THAN I REALLY DO AND, AS A RESULT, CAUSE THE ENGINE TO STALL FROM FUEL EXHAUSTION ON A BUSY HIGHWAY RESULTING IN AN ACCIDENT. THIS STILL HAPPENS TO THE VEHICLE OFTEN. REPAIRS HAVE NOT BEEN DONE. I HAVE HEARD THAT MANY MANY OTHERS WITH THIS MAKE OF VEHICLE HAVE THE SAME PROBLEM. THE SAME ISSUE HAPPENS NOT ONLY TO THE FUEL GAUGE, BUT ALSO THESE OTHER GAUGES: THE SPEEDOMETER (WHICH COULD CAUSE ME TO DRIVE TOO FAST FOR CONDITIONS OR BREAK THE SPEED LIMIT), OIL PRESSURE, ENGINE TEMP, VOLTMETER, TRANSMISSION TEMP AND TACHOMETER. *TR

I OWN A 2003 CHEVY SILVERADO 2500HD PICK UP W/ A LITTLE OVER 50,000 MILES. THIS WINTER WHILE DRIVING THE BREAK PEDAL WENT STRAIGHT TO FLOOR AND COULD NOT STOP. A SNOW EMBANKMENT STOPPED ME LUCKILY WITH NO INJURY AND NO DAMAGE TO THE VEHICLE. THE VEHICLE WAS BROUGHT TO A NEARBY CHEVROLET DEALER WHERE IT WAS DETERMINED THAT THE BRAKE LINES HAD CORRODED RIGHT THROUGH THE CALIPERS WERE CORRODED AT THE BLEEDER VALVE AND ROTORS WERE DELAMINATING . THE DEALERSHIP SAID THAT IT IS COMMON WITH THESE VEHICLES. I CANNOT SEE A 7 YEAR OLD VEHICLE W/ LOW MILES HAVING SUCH A MAIN MAJOR SYSTEM FAILURE AS THIS. THE COST FOR REPAIR WOULD BE $3,200 I CANNOT AFFORD THIS SO THE VEHICLE (WHICH IS MINT CONDITION) IS NOW SITTING IN THE DRIVE WAY. *TR

2003 CHEVROLET SILVERADO 2500HD W/ 8.1L ENGINE. WITH 59,000 MILES. I NOTICED A TICKING NOISE COMING FROM THE ENGINE COMPARTMENT. I TOOK INTO A DEALERSHIP FOR SOME OTHER SERVICE AND HAD THEM CHECK THIS NOISE ALSO. IT TURNED OUT TO BE A WARPED RIGHT SIDE EXHAUST MANIFOLD. I ALSO KNOW PEOPLE THAT HAVE THIS SAME ENGINE IN THERE MOTORHOMES THAT HAVE HAD THE SAME PROBLEM. *TR

BRAKE LINES CORRODE EASILY WHICH LEADS TO LEAKING AND LOSS OF BRAKES UNDER NORMAL DRIVING SITUATIONS. THIS IS THE SECOND TIME I'VE HAD TO REPLACE A SECTION OF BRAKE LINE. *TR