2005 CHEVROLET SILVERADO 2500 Complaints

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE BRAKE LINES WERE RUSTED OUT. THE DEALER STATED THAT NEW BRAKE LINES NEEDED TO BE INSTALLED ON THE VEHICLE. THE VEHICLE WAS REPAIRED IN JULY OF 2014. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 125,000.

WHILE DRIVING AT APPROX 50 MPH, ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I APPLIED MY BRAKES, BUT HIT THE OTHER VEHICLE. THE AIRBAGS DID NOT DEPLOY AS THEY SHOULD HAVE. THE SEAT BELT STOPPED MY FORWARD PROGRESSION, BUT I DO NOT KNOW WHY THE AIR BAGS DID NOT DEPLOY.

PITMAN ARM TO CENTER LINK BROKE DURING SLIGHT LEFT TURN A LOW SPEED LEAVING RESIDENTIAL DRIVEWAY. VEHICLE HAD NO STEERING AFTER EVENT. ALL ORIGINAL OEM EQUIPMENT WITH NO MODIFICATIONS. STEERING GEAR BOX HAD PREVIOUSLY BEEN REPLACED YEARS EARLIER ALL OTHER COMPONENTS ORIGINAL.

HAD TO MAKE A SUDDEN STOP WHEN A PEDESTRIAN WALKED OUT IN FRONT OF THE CAR IN FRONT OF ME. MY BRAKE PEDAL WENT TO THE FLOOR AND I REAR ENDED THE CAR IN FRONT OF ME. UPON ON INVESTIGATION IT WAS FOUND THAT ONE OF THE FRONT BRAKE LINES RUPTURED DUE TO THE HIGH PRESSURE FROM THE EMERGENCY STOP AND THE RUSTED BRAKE LINE. I HAVE OWNED THIS TRUCK SINCE NEW AND THERE HAVE BEEN NO RECALLS OR COMMUNICATIONS THAT THE BRAKE LINES WILL PREMATURELY CORRODE AND FAIL. BRAKE LINES ARE NOT A NORMAL SERVICEABLE PART. APPARENTLY, THIS IS TYPICAL OF THIS YEAR VEHICLE FROM GM. PLEASE RECALL OR NOTIFY THE PUBLIC BECAUSE THIS IS A TIME BOMB WAITING TO KILL PEOPLE. BRAKES ARE MORE IMPORTANT THAN YOUR EMPHASIS ON AIR BAGS. THE BRAKE LINES DIDN'T LAST AS LONG AS THE ENGINE, TRANSMISSION, BALL JOINTS, SHOCKS, ETC WHICH ARE ALL SERVICEABLE ITEMS AND EXPECTED TO BE REPLACED. PLEASE STEP UP TO YOUR RESPONSIBILITIES AND GET THE VEHICLE OWNERS NOTIFIED AND GET THE VEHICLES OFF THE ROAD UNTIL THE BRAKE LINES ARE REPLACED. MY 1941 CHEVROLET PICKUP HAS ORIGINAL BRAKE LINES IN BETTER CONDITION THAN MY 2005 CHEVROLET PICKUP. PLEASE RECALL THESE VEHICLES.

TODAY AT APPROXIMATELY 25MPH I CAME TO RESIDENTIAL STOP SIGN AND THE BRAKES WENT TO THE FLOOR WITHOUT AND WARNING. THE VEHICLE WENT INTO THE CROSS ROAD WITHOUT STOPPING. I WAS FORCED TO USE EMERGENCY BRAKE TO GET VEHICLE TO FULLY STOP. UPON INSPECTION THERE WAS ALOT OF BRAKES FLUID IN TWO SPOTS. FROM DRIVERS SIDE FRAME RAIL AND ABOVE FUEL TANK. WHEN YOU LOOK UNDER THE FRAME, THE PARTS ALL LOOK VERY CLEAN AND NEW LOOKING. THE ONLY EXCEPTION WAS THAT ALL THE BRAKE LINES LOOK HEAVILY RUSTED. I WAS LUCKY IT WAS NOT AT HIGH SPEEDS, BUT FROM WHAT MECHANICS TELL ME, THIS IS GETTING EXTREMELY COMMON. I BELIEVE AT LEAST OWNERS SHOULD BE NOTIFIED TO HAVE THEM INSPECTED. THE DEALER TELLS ME ALL THE LINES NEED REPLACED AT APPROXIMATELY $1300

BRAKE LINES RUSTED OUT PREMATURELY AND BURST, CAUSING LOSS OF BRAKING ABILITY. HAD TO REPLACE EVERY BRAKE LINE ON THE ENTIRE TRUCK, FOR THEY WERE ALL EXTREMELY RUSTY. 2 MONTHS LATER MY FUEL LINE ALSO SPRUNG A LEAK DUE TO EXCESSIVE RUST, CAUSING FUEL TO SPILL, CHECK ENGINE LIGHTS, AND HARD STARTING. BOTH OF THESE ISSUES PRESENT MAJOR SAFETY CONCERNS, AND UNFORTUNATELY ARE EXTREMELY COMMON WITH THESE TRUCKS.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHEN THE VEHICLE WAS STARTED, THE SERVICE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT DROVE THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT END SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,347.

MY TRUCK HAS BEEN BABIED, ONLY HAVING LESS THAN 45,000 MILES. HAS NEVER BEEN OFF BLACKTOP, AND KEEP IN GARAGE. WHILE TOWING MY BOAT MY BREAKS WENT OUT, COME TO FIND OUT MY BREAK LINE WAS RUSTED INTO AND MY MASTER CYLINDER WAS ALSO RUSTED WHERE THE BREAK LINES CONNECT. I WAS TOLD BY CHEV DEALER THAT ALL FOUR BREAK LINES AND MASTER CYLINDER WOULD HAVE TO BE REPLACED. $1,400.00, THIS SEEMS IMPOSSIBLE FOR A TRUCK WITH LESS THAN 45,000 MILES THAT WAS NOT DRIVEN IN THE RAIN FOR THE FIRST TWO YEARS AND NEVER BEEN DRIVEN ON SALT TREATED ROAD. I HAVE ANOTHER 4 WHEEL DRIVE TRUCK THAT I DRIVE IN BAD WEATHER. THIS IS THE ONLY NEW VEHICLE I HAVE EVER PURCHASED. VERY DISAPPOINTED IN BREAK SERVICE AND CHEVY WELLNESS TO ADMIT THERE I IS A DEFECT WITH THE BREAK SYSTEM.

I HAVE A 2005 CHEVROLET 2500 HD WITH 57000 MILES AND THE BRAKE LINES ARE RUSTED INTO. I WAS GETTING READY TO HOOK MY TRAILER UP AND WAS BACKING AND HIT THE BRAKES AND THEY WENT TO THE FLOOR. IT WAS POURING FLUID OUT UNDER THE DOOR WHERE THE BRAKE LINE WAS RUSTED INTO. THIS TRUCK HAS NOT SEEN THAT MUCH SALT TO HAVE THIS HAPPEN. I HEAR THAT GM DOES NOT WHAT TO RECALL BECAUSE THEY SAY IT IS A MAINTENANCE ISSUE I BEG TO DIFFER. I HAVE A 1971 CHEVY PICKUP THAT HAS SEEN YEARS OF SALT AND WATER AND NONE HAVE EVER RUSTED LIKE THIS 2005 HAS. I GUESS THEY ARE WAITING TO SEE HOW MANY WILL DIE BEFORE THERE IS A PROBEM.

THE STEEL FUEL LINES AND STEEL BRAKE LINES ARE CORRODING AND LEAKING. ON OCTOBER 8TH 2015 MY TRUCK BEGAIN TO LEAK DIESEL FUEL FROM THE RUSTED FUEL LINES. WHILE FIXING THE FUEL LEAK THE TECHNICIAN ALSO NOTICES THAT THE BRAKE LINES WERE ALSO STARTING TO RUST AND WILL NEED TO BE REPLACES SOON BEFORE THEY FAIL.