2003 CHEVROLET SILVERADO 2500 Complaints

THE BRAKE LINES RUSTED THREW WHILE DRIVING MAKING THE TRUCK UNSAFE FOR DRIVING.THE FUEL LINES ARE GOING TO GO NEXT AFTER INSPECTION ALL THE BRAKE AND FUEL LINES ARE BAD. *TR

AT FREEWAY SPEEDS I NOTICED THE OIL PRESSURE HAD DROPPED TO ALMOST 2 OUT OF 10 ON THE PRESSURE GAUGE. I STOPPED AS SOON AS POSSIBLE AND LET THE ENGINE COOL FOR 20 MINUTES. I CHECKED THE OIL LEVEL AND COLOR. IT WAS OK IN BOTH RESPECTS. AFTER ANOTHER 30 MINUTES I RESTARTED THE ENGINE AND CONTINUED HOME. I WATCHED THE PRESSURE GAGE FOR ANOTHER HOUR AND SAW THE PRESSURE READING CONTINUE TO FALL TO A DANGEROUS LEVEL BUT THERE WAS NOTHING I COULD DO. THE NEXT DAY I TOOK THE TRUCK TO THE CHEVY DEALER IN EL CENTRO, CA 92243 FOR THEIR ANALYSIS. THEY SAID IT WAS ONLY POOR OIL AND NEEDED CHANGING. I LET THEM SERVICE THE TRUCK AS THEY WISHED. THEY ALSO SCANNED (SWEPT) THE GAUGES AND CHANGED THE OIL AND SENT ME ON MY WAY. THE NEXT DAY IT DID THE SAME THING. I DID NOT RETURN TO THE DEALER AS I WAS NOT PREPARED FOR AN ARGUMENT. *TR

HAD TOTAL BRAKE FAILURE, NO WARNING TILL SLOWING DOWN AT INTERSECTION OF BUSY ROAD. APX. 100 YARDS BEFORE STOP LIGHT I APPLIED BRAKES, PEDAL WAS SOFT,PUMPED BRAKES AND PEDAL WENT ALL THE WAY TO FLOOR! I QUICKLY PUMPED BRAKES AND CAME TO STOP IN THE INTERSECTION NOT 2 SECONDS AFTER MOTORCYCLE WITH PASSENGER PASSED IN FRONT OF ME! NO BRAKE WARNING LIGHT EVER ALERTED, FOUND STEEL BRAKE LINE HAD RUSTED AND RUPTURED. THIS TRUCK HAS ONLY 65000 MILES ON IT, FOUND ANOTHER LINE IS VERY RUSTED IN SAME PLACE AS IT CROSSES OVER FRAME. AFTER RESEARCH ON REPAIRS, FOUND THAT THIS IS COMMON PROBLEM WITH THESE TRUCKS FROM 1999 TO 2003. THIS ONE COULD HAVE BEEN FATAL,AS MOTORCYCLE WAS TRAVELING AT LEAST 45 MPH. THESE TRUCKS ARE ALL COMING TO THE AGE OF FAILURE. THANK GOD, I WAS NOT PULLING MY BOAT THAT WEIGHS 6700 LBS AS THIS TRUCK CAN NO LONGER BE TRUSTED. I WILL BE CHECKING INTO REPAIRS,AND IT WILL BE SOLD ! *TR

TRUCK WAS PARKED AT HOME ON A HILL. I PUT IT IN REVERSE AND STARTED TO BACKUP WHEN THE BRAKES COMPLETELY FAILED CAUSING ME TO GO INTO A TREE. THIS CAUSED DAMAGE TO THE REAR DRIVERS SIDE QUARTER PANEL. BRAKE FLUID IS LEAKING FROM THE BRAKE LINE IN THE REAR OF THE VEHICLE. VEHICLE WOULD NOT SHIFT BACK INTO PARK. I HAD TO SHUT THE VEHICLE OFF AND NOW CALLING A TOW TRUCK. *TR

WAS BACKING OUT OF PARKING SPOT TO LEAVE WORK AND STEPPED ON THE BRAKE TO SHIFT INTO REVERSE. BRAKE PEDAL WENT TO THE FLOOR. BEING A CHEVY TRUCK AND KNOWING THAT THEY ARE NOTORIOUS FOR BRAKE LINES RUSTING OUT, I GOT OUT OF THE TRUCK TO LOOK UNDERNEATH AND SAW BRAKE FLUID LEAKING FROM THE REAR OF THE TRUCK, ALONG THE DRIVER SIDE FRAME RAIL ABOVE THE FUEL TANK. HAD RUSTED OUT BRAKE LINES REPLACED BY LOCAL SERVICE CENTER FOR $605.60. I ONLY DROVE THE TRUCK THIS DAY TO PICK UP ITEMS FROM A HOME IMPROVEMENT STORE. NORMALLY THIS TRUCK IS ONLY USED BY MY WIFE TO PULL A HORSE TRAILER. OTHER THAN THAT IT SITS IN OUR GARAGE OUT OF THE WEATHER. I AM SO GLAD THIS HAPPENED TO ME WHILE AT A STOP AS OPPOSED TO HER WHILE DRIVING ON THE WINDING NORTHERN KENTUCKY ROADS PULLING A TRAILER LOADED WITH HORSES! *JS

IN APRIL OF '14, A FRONT BRAKE LINE FAILED AND THAT LINE WAS REPLACED. ON 6/3/14, I HAD ANOTHER BRAKE LINE FAILURE DIRECTLY UNDER THE DRIVERS SEAT. THIS AFFECTED BOTH REAR BREAKS. ON INSPECTION OF THE VEHICLE, IT WAS OBSERVED THAT ALL OF THE STEEL TUBING OF THE BREAK LINES WERE BADLY RUSTED AND NEEDED TO BE REPLACED. FURTHER INSPECTING THE VEHICLE, I ALSO FOUND THAT THE TRANSMISSION LINES WERE ALSO RUSTING BADLY AND NEEDED TO BE REPLACED. *JS

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED ABRUPTLY TO THE FLOOR WHEN DEPRESSED. THE VEHICLE FAILED TO SLOW DOWN UNTIL THE GEAR WAS SHIFTED INTO PARK AND THE EMERGENCY BRAKE WAS ENGAGED. THE VEHICLE WAS THEN DRIVEN TO THE RESIDENCE WITH CAUTION. THE CONTACT WAS A CERTIFIED MECHANIC, WHO REPLACED THE FOUR BRAKE LINES, WHICH RUPTURED DUE TO RUST CORROSION. THE FAILURE RECURRED SHORTLY AFTER THE REPAIRS. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000.

MY 2003 CHEVY 2500 HD HAS AN EXHAUST MANIFOLD LEAK AND THIS IS AN ONGOING AND CHRONIC PROBLEM WITH THESE VEHICLES. I CAN SEE EVIDENCE OF HOT EXHAUST GASES LEAKING INTO THE ENGINE COMPARTMENT. *TR

BLEW A HOLE IN BRAKE LINE AT BOAT LANDING. LUCKILY I GOT IT STOPPED BEFORE IT WENT INTO THE LAKE. ALL BRAKE LINES ARE RUSTED AND NEED TO BE REPLACED. THIS COULD HAVE CAUSED SEVERE INJURY OR DEATH IF IT HAPPENED AT A DIFFERENT TIME. I THINK A RECALL IS NECESSARY AS THIS IS A MAJOR SAFETY ISSUE. I ALSO HAVE A FRIEND THAT HAD THE SAME THING HAPPEN ON HIS 2004 SIERRA. *TR

2003 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO FUEL INJECTORS PROBLEM . *SMD THE CONSUMER STATED HIS VEHICLE WAS ALWAYS MIS-DIAGNOSED. THE DEALER NEVER CHECKED TO SEE IF THERE WAS A PROBLEM WITH THE FUEL INJECTORS, IN WHICH WHITE SOME WAS EMITTING FROM THE VEHICLE. THE DEALER ONLY REPLACED THE GLOW PLUGS, WHICH WAS NOT THE PROBLEM.