2004 CHEVROLET SUBURBAN Complaints

THE TRUCK FAILS TO RESTART AFTER DRIVING IT AN AT FIRST IT WOULD RESTART AFTER 15 - 20 MINUTES AFTER IT SITS AN NOW IT DOES NOT START AT ALL SO FAR I KNOW IT IS HAPPENING TO MORE THAN 20 VEHICLES INCLUDING THE STATE PATROL 2016 SUBURBANS AND SEVERAL OF THE PICKUPS

CRACKED DASH, NEVER REMOVED, GARAGE KEPT. CRACKED RUNS THROUGH DASH FROM FRONT WINDOW TOWARDS RADIO CLUSTER. DASH HAS SHARP PIECES THAT IN ACCIDENT CAN EASILY BE BROKEN OFF.

THE EXHAUST MANIFOLD BOLTS HAVE SNAPPED OFF, 4 OF THEM TO BE EXACT. EXHAUST FUMES CAN NOW LEAK INTO TO THE CAB AND POISON OCCUPANTS.

INSTRUMENT CLUSTER SHORTS OUT AND GEAR INDICATOR GOES BLANK. NO MESSAGE CENTER INFORMATION WARNINGS ARE DISPLAYED. PART IS DEFECTIVE AND CAR MAKERS SHOULD REPLACE IT. NOT KNOWING WHAT GEAR VEHICLE IS IN CAN LEAD TO DEATH IF VEHICLE LEFT IN NEUTRAL AND ROLLS AWAY. GM NEEDS TO FIX THIS EXPENSIVE PROBLEM. ALSO 4L60E TRANSMISSION ON THESE VEHICLES FAILS AND STARTS SLIPPING BECAUSE OF DEFECTIVE SUN SHELL AND REAL PISTON SEAL. GM SHOULD RECALL ALL THESE BAD TRANSMISSIONS. WARRANTY SHOULD HAVE BEEN FOR LIFE. WHY SHOULD SUCH AN EXPENSIVE PART TO REPAIR FAIL UNDER NORMAL USE? RECALL ! BOTH THESE PARTS FAIL WHEN DRIVING. ALL WARNING OF VEHICLE CONDITIONS ARE SENT TO FAILED CLUSTER. VEHICLE WAS MADE IN MEXICO FOR RE-IMPORTATION AND SALE IN USA AND MAYBE PARTS SUPPLIERS IN MEXICO PROVIDED DEFECTIVE PARTS. MANY PEOPLE HAVE SUFFERED FINANCIAL LOSS TRYING TO FIX THESE PROBLEMS, LASTLY, THE EMISSION SOLENOID NEAR THE TANK ALSO FAILS. VEHICLE MAY NOT PASS EMISSION. *TR

WHILE AVOIDING ANOTHER VEHICLE I APPLIED MY BRAKES SUDDENLY. THE BAKE LIKE CONNECTING THE ABS UNIT AND THE REAR BRAKES FAILED DUE TO CORROSION/RUST THAT WAS NOT OBSERVABLE DUE TO THE LINE BEING RAN BETWEEN THE VEHICLES FRAME AND BODY AND GAS TANK. ALTHOUGH THIS LOCATION MIGHT HAVE MADE FOR EASY MANUFACTURING IT HAS LED TO THE LINE BEING IN A LOCATION THAT CANNOT BE VISUALLY INSPECTED TO PREVENT DANGEROUS CONDITIONS FROM BUILDING UP FROM LACK OF AWARENESS. .

TOTAL BRAKE FAILURE (VEHICLE HAS 95,387) MILES) AT 40 MPH IN MOTION. STABIL-TRAC LIGHT INDICATED AT THE TIME OF FAILURE, SERVICE BRAKE INDICATOR ON DISPLAY INFORMATION CONSOLE. . DEPLOYED 4WD LOW, DROPPED TO LOWER GEAR AND HIT EMERGENCY BRAKE TO STOP THE VEHICLE ON SHOULDER OF ROAD. GOT OUT OF VEHICLE SAW BRAKE FLUID ALL OVER THE SKIDS AND FRAME. CAUSE: TOWED TO LOCAL SHOP INDICATED THAT BRAKE LINES ON DRIVER SIDE AND LINES GOING TO FRONT WHEEL WERE COMPLETELY RUSTY AND "LIKE PAPER". THIS WAS UNSETTLING I DON'T LIVE NEAR SALTWATER BUT DRIVE THE VEHICLE A LOT IN WINTER. HAD I BEEN IN A DENSELY POPULATED AREA, THERE CERTAINLY WOULD HAVE BEEN LOSS OF LIFE. THIS VEHICLE WEIGHS OVER 6000 LBS AND NO BRAKES IS LIKE TO TRYING TO STOP A TRAIN. PLEASE INVESTIGATE SIMILAR FAILURES AS THIS FAILURE IN SIMILAR VEHICLES/ANY VEHICLE COULD CAUSE LOSS OF LIFE.

2004 CHEVY SUBURBAN - SUDDEN & COMPLETE LOSS OF BRAKE PRESSURE AT HIGHWAY SPEED. VEHICLE BRAKES WERE INSPECTED IN JULY THROUGH THE VA STATE INSPECTION PROGRAM - NO ISSUES FOUND - TODAY ON 8/30/16 WHILE EXITING A FREEWAY RAMP AT 60MPH TRAFFIC CAME TO SUDDEN STOP. WHEN THE SERVICE BRAKE WAS APPLIED IN WHAT WOULD BE CONSIDERED A STAB/EMERGENCY BRAKING MANEUVER THERE WAS A COMPLETE AND SUDDEN LOSS OF BRAKE PRESSURE - PEDAL WENT TO FLOOR WITHOUT WARNING, BRAKE WOULD NOT PUMP UP ADEQUATE ENOUGH TO SLOW VEHICLE. I HAD TO USE A COMBINATION OF PARKING BRAKE APPLICATION AND UTILIZING THE SOFT SHOULDER AND DITCH TO STOP THE VEHICLE. THE BRAKE WARNING INDICATOR (RED) AND SERVICE INDICATOR DID NOT ILLUMINATE UNTIL AFTER THE THIRD OR FOURTH APPLICATION OF THE BRAKE PEDAL. SUBURBAN WAS TOWED. CAUSATIVE FACTORS = RUPTURED BRAKE LINE.

BRAKE LINE (HARD LINE) CATASTROPHIC FAILURE. UNABLE TO STOP ON COMING TO HIGHWAY INTERSECTION USING HYDRAULIC BRAKES. HAD TO RESORT TO APPLYING PARKING BRAKE TO STOP VEHICLE. ON INSPECTION MAIN BRAKE HYDRAULIC LINE RUPTURED- FLUID SPEWED ON ROADWAY AND APPROXIMATELY 1/2 OF FLUID FROM MASTER CYLINDER. LIMITED RESIDUAL PRESSURE FROM SECONDARY WAS UNABLE TO STOP VEHICLE WITHOUT MECHANICAL ASSIST FROM PARKING BRAKE.

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE THE VEHICLE WAS IN THE PARK POSITION, THE GEAR SHIFTED INTO THE NEUTRAL POSITION UNEXPECTEDLY WITHOUT WARNING. THE FAILURE OCCURRED ONCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 148,000.

DRIVING AS NORMAL ATTEMPT TO STOP AND PEDAL WENT TO THE FLOOR. NO BRAKES. COASTED TO STOP LUCKILY NOT TRAVELING AT HIGH SPEED. INSPECTION REVEALED RUSTED THROUGH BRAKE LINES. AND ALL FLUID GONE FROM MASTER CYLINDER.