2005 CHRYSLER 300C Complaints

DRIVERS SIDE HEADLIGHT DOES NOT WORK. WE HAVE CHANGED THE BULB , EVEN TRIED ONE THAT DID WORK FROM THE LEFT SIDE . ON BLOGS PEOPLE ARE COMPLAINING OF THE SAME ISSUE ON THE DRIVERS SIDE , THEREFORE I WONDER IF OTHERS HAVE REPORTED IT LIKE MYSELF . THE AIR BAG LIGHT IS STAYING ON AS WELL .

WHEN REFUELING MY CHRYSLER 300C BACK TO FULL CAPACITY IT WILL IMMEDIATELY STALL OUT AND SHUT OFF COMPLETELY. THE CAR WILL START RIGHT UP AGAIN NO PROBLEM, AND CONTINUE TO STALL OUT WHILE DRIVING IN TRAFFIC MULTIPLE TIMES FOLLOWING UNTIL IT BURNS OFF ENOUGH FUEL TO STOP. I ALSO HAVE BEEN SMELLING RAW GASOLINE INSIDE AND OUTSIDE THE VEHICLE AND THE PROBLEM VARIES. THE ODOR IS HIGHLY POTENT COMING FROM THE PASSENGER SIDE REAR. NEVER WITNESSED ANY FLUID LEAKING UNDERNEATH THE CAR OR NOTICEABLY IN FUEL TANK GAUGE UNTIL THIS MORNING, IT WAS LEAKING OUT FROM THE TRIM PANEL UNDERNEATH THE REAR PASSENGER SIDE .

AFTER I REFUEL MY CAR, IT ALWAYS SMELLS LIKE GAS INSIDE THE CAB. I RECENTLY LOOKED TO SEE WHERE IT IS COMING FROM, AND FOUND IT ON THE PASSENGER SIDE BACK SEAT. THE TRANSFER PUMP HAS A PUDDLE OF GASOLINE ON THE BACK SIDE OF IT. I DID SOME RESEARCH AND FOUND THAT OTHER PEOPLE WHO HAVE THIS MAKE AND MODEL CAR ARE ALSO EXPERIENCING THE SAME ISSUE.

THE MAIN GROUNDING WIRE PASSENGER-SIDE ENGINE BLOCK CONTACT POINT HAD CORROSION(RUST) LIMITING ELECTRICAL CURRENT FLOW TO THE WIRING HARNESS. THIS CAUSED TOO MUCH CURRENT TO FLOW TO 2 SMALLER 16 GAUGE GROUNDING WIRES ATTACHED TO THE REAR OF EACH HEMI CYLINDER HEAD TO FRY. THIS DIRECTLY AFFECTS THE CCN BUS COMMUNICATIONS TO THE CPU. ANY DEVICE, MODULE, OR SENSOR ATTACHED TO THE CCN BUS CAN HAVE INTERMITTENT BEHAVIOR. EXAMPLES OF VERY BAD BEHAVIOR IN MY CAR: 1. THE ALARM RANDOMLY GOING OFF WHILE PARKED OR WHEN DRIVING THE CAR. 2. WHILE PARKED AND THE ALARM SET THE SUNROOF DECIDED TO OPEN UP DURING A RAINSTORM FILLING MY CAR WITH 3 INCHES OF RAIN. 3. THE 300C DOESN'T USE A THROTTLE CABLE. IT UTILIZES A THROTTLE POSITION SENSOR THAT COMMUNICATES WITH THE CPU OVER THE CCN BUS. JUST TOUCHING THE GAS PEDAL WAS THE SAME AS PRESSING THE GAS PEDAL TO THE FLOOR. IT'S A GOOD THING THAT WHEN THIS HAPPENED TO ME THERE WAS NO TRAFFIC ON THE ROAD AND I WAS CLOSE TO HOME. SINCE THIS IS CCN 2-WIRE TWISTED PAIR BUS COMMUNICATION ISSUE ANYTHING THAT COMMUNICATES WITH THE CPU CAN HAVE A RANDOM INTERMITTENT PROBLEM. SINCE THESE CARS ARE GETTING OLDER I HAVE TO THINK THAT THERE ARE OTHER CARS THAT ARE OR WILL HAVE SIMILAR ISSUES. PRAY TO GOD THAT YOUR THROTTLE DOESN'T STICK WIDE OPEN LIKE MINE DID. I HAD TO KEEP MY FOOT BURIED ON THE BRAKE WHILE I WAS SCREAMING DOWN THE ROAD UNTIL I WAS ABLE TO TURN OFF THE IGNITION. HAVE FUN COMING TO A STOP OR DRIVING HOME AFTER THAT HAPPENS. FORMALLY I WAS AN I2C BUS COMMUNICATIONS(2 WIRE BUS) EXPERT AT BOTH INTEL CORP AND CISCO SYSTEMS. I KNOW WHAT I AM TALKING ABOUT. TODAY I TALKED WITH A BREMERTON CHRYSLER/DODGE/JEEP TECHNICAL SERVICE REPRESENTATIVE ABOUT THIS ISSUE. BOTTOM-LINE OVER $3000 TO FIX. THERE MAY HAVE BEEN SOMEBODY SOMEWHERE THAT IS DEAD BECAUSE OF THIS FACTORY DEFECT AND NO ONE IS THE WISER. WHY NOT A FACTORY RECALL ISSUE?

WHENEVER I DO A QUICK ACCELERATION, MY CHECK ENGINE LIGHT COMES ON AND THE CAR TEMPORARILY LOSE POWER. WHEN THE CAR LOSE POWER, I CANNOT CONTROL IT, WHICH IS VERY DANGEROUS. WHEN THE CHECK ENGINE LIGHT COMES ON NO CODES ARE STORED. ALSO, I HAVE EXPERIENCE THIS PROBLEM WHILE SITTING AT A RED LIGHT. FOR THE MOST PART, THIS PROBLEM MOSTLY OCCUR DURING ACCELERATION. I HAVE HAD THE SPARK PLUGS REPLACED AND THROTTLE BODY CLEANED BUT THE PROBLEM PRESIST. FROM MY RESEARCH, THIS PROBLEM APPEARS TO BE REGULAR THROUGHOUT THE CHRYSLER/DODGE FAMILY. THIS PROBLEM NEEDS TO BE RECTIFIED BEFORE SOMEONE LOSE THEIR LIFE IN AN UNNECESSARY ACCIDENT.

EVERY TIME THE VEHICLE IS FILLED WITH GAS, THE ENGINE STALLS OUT NO MATTER WHERE IT IS BEING DRIVEN. HYW OR STREET/CITY ROAD.

THE TRANSMISSION HAS BEEN REBUILT 3 TIMES IN THE PAST 8MONTHS .. IT JUST OUT OF NO WERE WITH NO WARNINGS WILL STOP GOING IN TO FIRST GEAR. MOSTLY ON A STOP. THEN STEP ON GAS IT WON'T GO IN TO FIRST GEAR ANY MORE. IT DID DO IT ONE WHILE ON THE FREE WAY. EVERY SINGLE TIME IT HAS DONE THAT IT HAS TO GO TO THE SHOP BECAUSE IT WON'T WORK ANY MORE. *TR

GASOLINE SMELL INSIDE CABIN TRACED TO THE GAS PUMP/SENDING UNIT LOCATED BELOW THE FLOOR MAT DIRECTLY BENEATH THE REAR PASSENGER-SIDE SEAT. A 1/2" DEEP PUDDLE OF GAS FORMS AT THE REAR OF THE UNIT WHICH REAPPEARS AFTER BEING SOAKED UP.

I WAS GOING TO CHECK THE OIL LEVEL WHEN THE TOP OF THE DIPSTICK CAME OFF IN MY HAND. IT IS MADE OF PLASTIC.; I WAS OPENING THE DRIVERS DOOR, THE HANDLE CAME HALFWAY OFF, SUBSEQUENTLY ALL HANDLES HAVE DONE THE SAME THING. THE WASHER FLUID DOES NOT SPRAY. THESE PROBLEMS ALL HAPPENED IN THE PAST 3 OR 4 YEARS. THE VEHICLE WAS STATIONARY FOR THESE PROBLEMS. WHILE TURNING, THE STEERING WHEEL WOULD NOT CONTINUE TOO TURN, HEARD A " THUNK", FINALLY TURNED BUT THE TURN SIGNAL MECHANISM DOES NOT WORK NOW.

TL* THE CONTACT OWNS A 2005 CHRYSLER 300C. WHILE DRIVING 45 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO TWO INDEPENDENT MECHANICS, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. FAILURE CODES APPEARED AFTER THE VEHICLE WAS RETRIEVED. LITHIA CHRYSLER DODGE JEEP RAM FIAT OF SANTA FE (4470 CERRILLOS RD, SANTA FE, NM 87507, (505) 629-0746) STATED THAT THERE APPEARED TO BE AN ELECTRICAL FAILURE AND WERE CHECKING ALL THE WIRING ON THE HARNESS WITH MULTIPLE CODES APPEARING. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 81,000. THE VIN WAS UNKNOWN.