2005 CHRYSLER 300C Complaints

THIS PROBLEM ONLY AFTER FILL THE GAS TANK. AFTER PULLING AWAY FROM THE PUMP AND PULLING INTO TRAFFIC THE CAR DIED AND WON'T START UNTIL YOU PUT IN PARK. THIS HAPPENS UNTIL SOME OF THE FUEL HAS BEEN USED UP. I WOULD HAVE IT HAPPEN MAKE IT HOME. THEN THE NEXT TIME I DRIVE IT THE CAR WILL DIE UNTIL ITS BEEN DRIVEN ENOUGH TO USE UP SOME FUEL. THIS DANGEROUS BECAUSE IT HAPPEN AS YOU SLOW DOWN OR START UP. I HAVE HAD IT DIE WHILE TURNING AND LOSE ALL CONTROLS BECAUSE IT DIES! THE ONLY WAY TO COMBAT THIS IS TO NOT FILL THE TANK. THAT WORKS IF I DRIVE THE CAR BUT MY FAMILY MEMBERS FORGET THAT AND HAVE LOST CONTROL ALSO! THIS HAS BEEN GOING ON FOR 3 YEARS! DANGEROUS *TR

I READ ABOUT THIS IN THE PAPER ON 5-13-2013. AFTER FILLING UP , I STARTED DRIVING IN 3 LANES OF HEAVY TRAFFIC GOING ABOUT 55. THE CAR SUDDENLY STOPPED. THE ENGINE SHUT DOWN. I WAS LUCKY I DIDN'T GET HIT BY ONE OF THE OTHER CARS. THIS HAPPEND SEVERAL OTHER TIMES AFTER THAT. I WENT TO THE DEALER AND THEY SAID THEY HAD NEVER HEARD OF SUCH A THING. THEY SAID I MUST HAVE TOPPED OFF THE GAS. I SAID NO. THEY SAID THEN DO NOT PUT SO MUCH GAS IN AT ONCE. WELL THEY JUST BLEW ME OFF. I REALLY THINK THIS MATTER NEEDS TO BE ADDRESSED NOW, BEFORE IT IS TOO LATE FOR SOMEONE. *TR

AFTER FILLING UP THE GAS TANK AND DRIVING AWAY FROM GAS STATION, ENGINE WOULD STALL AND DIE. TRIED RESTARTING BUT DIFFICULT TO DO AFTER MANY ATTEMPS. VEHICLE WOULD FINALLY DRIVE NORMAL AFTER STARTING AND RUNNING ENGINE AT HIGHER THAN IDLE SPEED. THIS STALLING WOULD HAPPEN ANYTIME I WOULD FILL TANK. I WOULD NEVER TOP OFF TANK BUT WOULD FILL TILL PUMP WOULD STOP THE FIRST TIME. IF I FUEL VEHICLE WITHOUT FILLING TO TOP, VEHICLE RUNS FINE. *TR

I FILLED THE TANK UP TO FULL LIKE I HAD MANY TIMES BEFORE. I HAVE ALWAYS PREFERRED RELYING ON GALLONS AND NOT THE AUTOMATIC PUMP SHUT OFF TO KNOW WHEN IT WAS FULL TO PREVENT A POSSIBLE OVERFILLING. I HAD GONE MAYBE 10 YARDS AFTER RESTARTING AND SHE STALLED. TRIED TO CRANK HER BACK UP, AND SHE WOULD SPUTTER AND TRY TO START, BUT IT TOOK A FEW TRIES. THEN, AS I AM PULLING INTO THE STREET, IT DIED AGAIN BUT STARTED RIGHT BACK UP. THEN IT DIED 10 YARDS LATER, AGAIN. IT CONTINUED TO STALL EVERY FEW FEET UNTIL I WAS ABLE TO GET THE RPMS UP AND HOLD IT IN 1ST AND 2ND GEAR TO ATTEMPT AND BURN UP AS MUCH FUEL AS QUICKLY AS POSSIBLE. HOWEVER, COMING TO A COMPLETE STOP ANYTIME FOR THE NEXT 15 MILES OR SO WOULD CAUSE A STALL BUT ALWAYS FOLLOWED WITH AN IMMEDIATE START UP. WHEN IT STALLS THAT VERY FIRST TIME IT TAKES A FEW MINUTES FOR IT TO START AND THEN IT IS VERY ROUGH FOR A FEW MILES. SINCE THAT DAY ANYTIME I FILL UP TO WITHIN ABOUT A GALLON OF MAXIMUM CAPACITY IT WILL START THE STALLING PROCESS ALL OVER AGAIN. COMBINE BAD GAS MILEAGE WITH A TANK THAT CAN'T BE FILLED AND IT'S SAFE TO ASSUME I SPEND A LOT OF TIME AT GAS STATIONS. *TR

VEHICLE STALLS AFTER REFILLING THE FUEL TANK - USUALLY ONCE WITHIN TWO BLOCKS OF THE SERVICE STATION. SOMETIMES THIS HAS HAPPENED TWICE. ONCE IT HAS BEEN DRIVEN A FEW MILES, THEN THE STALLING PROBLEM GOES AWAY. I CONTACTED THE DEALER BUT THEY HAVE NO IDEA WHY THIS IS HAPPENING NOR HOW TO REMEDY THE SITUATION. *TR

TL* THE CONTACT OWNS A 2005 CHRYSLER 300C. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED SEVERAL TIMES AND IMMEDIATELY AFTER REFUELING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 86,000. *TR

ENGINE STALLED SHORTLY AFTER REFUELING AND CONTINUED TO STALL UNTIL OR HESITATE UNTIL 2 - 3 GALLONS OF GASOLINE WAS BURNED OFF. THE CONDITION HAPPENS ALMOST 100% OF THE TIME IF THE TANK IS FILLED TO THE FIRST CLICK DURING REFUELING - IT THE TANK IS ONLY FILLED TO 85% THE CONDITION WILL NOT OCCUR. THE STALLING CONDITION IS VERY DANGEROUS BECAUSE THE ENGINE IS HARD TO RESTART AND REQUIRES EXCESSIVE CRANKING. IT APPEARS THE ENGINE STALLS WHEN THE EVAPORATIVE SYSTEM SENDS RAW FUEL TO THE THROTTLE BODY INSTEAD OF FUMES - THE ENGINE THEN STALLS AND IS DIFFICULT TO RESTART UNTIL AN IGNITABLE AIR/FUEL RATIO IS RE-ESTABLISHED. I WAS DRIVING THE SUBJECT VEHICLE AT 35 MPH AND HAD TO MAKE A RIGHT TURN WHEN THE ENGINE DIED AND THEN LOST POWER STEERING. TRYING TO COMPLETE THE TURN WITHOUT POWER STEERING WHILE TRYING TO RESTART A FLOODED ENGINE WAS DIFFICULT AND COULD HAVE EASILY RESULTED IN A SERIOUS ACCIDENT. I'M AWARE THAT THE NHTSA IS LOOKING INTO 2006 MODEL YEAR CHRYSLER 300S EQUIPPED WITH THE HEMI ENGINE FOR THE EXACT SAME CONDITION. PLEASE BROADEN YOUR INVESTIGATION TO INCLUDE THE 2005 MODEL YEAR VEHICLES TOO. THE BUILD DATE OF THE SUBJECT VEHICLE WAS 03/04 SO IT WAS AN EARLY PRODUCTION VEHICLE. AS BEFORE, THE SUBJECT VEHICLE EXHIBITS THE STALLING CONDITION ALMOST 100% OF THE TIME IF THE GAS TANK IS FILLED TO THE FIRST CLICK. I'LL BE HAPPY TO MAKE THE VEHICLE AVAILABLE TO NHTSA ENGINEERS IF THEY NEED A VEHICLE TO EXAMINE AS PART OF THEIR INVESTIGATION. *TR

AFTER FILLING GAS TANK, ENGINE WOULD REPEATELY STALL (AT IDLE OR AT 40 MPH) UP TO 6 TIMES WITHIN 2+ MILES.. INCIDENT DID NOT SEEM TO OCCUR IF THE TANK WAS NOT FULL. *TR

WHEN FILLING UP THE CAR, WHEN I COME TO AN IDLE...THE CAR DIES. HAPPENS EVERY TIME WE FILL UP THE CAR AND HAPPENS MULTIPLE TIMES AFTER IT'S FILLED. WHEN WE DON'T FILL UP THE CAR, IT NEVER HAPPENS. WE CALLED OUR CHRYSLER DEALERSHIP AND THE SERVICE DEPARTMENT SAID THAT CHRYSLER IS HAVING TROUBLE WITH IT AND THEY HAVE SEVERAL COMPLAINTS HOWEVER THERE IS NO RECALL ON THE COMPLAINT. *TR

THE CAR STALLED AFTER FUELING. ONCE THE PROBLEM STARTED IT CONTINUED EVERY TIME I FILLED THE TANK. I RECENTLY HAD TO HAVE A NEW GAS TANK INSTALLED WHICH COST OVER $1200.00. *TR