2005 CHRYSLER 300C Complaints

I FILLED THE TANK AND THE VEHCILE STALLED SEVERAL TIMES THE NEXT FEW MILES. ESPECIALLY AFTER RIGHT TURNS, LIKE WHEN MERGING ONTO FREEWAYS. THIS HAPPENS NOW EVERY TIME WHEN I FILL THE TANK. VERY DANGEROUS. FROM WEB FORUMS I UNDERSTAND GAS IS GETTING SUCKED INTO THE EVAP SYSTEM BECAUSE A CHECK VALVE AT THE GAS-FILLER NECK DOESN'T WORK. WHAT A PAIN! I REPLACED THE EVAP SOLENOID, THAT DIDN'T HELP...THE PROBLEM AT THE GAS TANK FILLER-NECK CHECK VALVE. *TR

ON 3 SEPARATE OCCASIONS IMMEDIATELY FOLLOWING FILLING WITH GAS, THE ENGINE DIED WITHIN 2 BLOCKS OF THE GAS STATION. NO CHECK ENGINE LIGHT WAS DISPLAYED ON ANY OF THE 3 OCCASIONS AND THE CAR WAS EXTREMELY DIFFICULT TO RESTART, REQUIRING AT LEAST 30 SECONDS. ALSO, AFTER RESTART ON ALL 3 OCCASIONS, THE ENGINE RAN VERY ROUGH FOR 1-2 MILES AND THEN RAN SMOOTHLY. ON 1 OF THE OCCASIONS, THE CAR DIED THE NEXT DAY AFTER ONLY DRIVING A FEW BLOCKS FROM HOME. AFTER THE FIRST OCCURRENCE, THE SPARK PLUGS WERE CHANGED, THE THROTTLE BODY WAS CLEANED, THE VAPOR CANISTER WAS REPLACED, AND THE EVAPORATION SYSTEM SOLENOID WAS REPLACED. ON 1 OF THE OCCASIONS, THE GAS TANK WAS TOPPED OFF BEYOND THE INITIAL SHUT-OFF BY SEVERAL TENTHS OF A GALLON. AFTER THE 3RD OCCURRENCE (70,796 MILES), THE CAR WAS TAKEN TO THE OLATHE CHRYSLER DEALERSHIP AND DIAGNOSED AS NEEDING TO REPLACE THE GAS TANK (2/20/2013). THE COST WAS $1583.58. SINCE THEN, THE VEHICLE NOW HAS 72,062 MILES ... APPROXIMATELY 1200 MILES SINCE REPLACING THE GAS TANK ... AND HAS NOT DIED FOLLOWING FILLING WITH GAS (6 TIMES). *TR

VEHICLE STALLS ONE OR MORE TIMES AFTER REFUELING, PARTICULARLY WHILE DECELERATING. VEHICLE MAY THEN LURCH SEVERAL TIMES BEFORE RESUMING NORMAL OPERATION, WHICH USUALLY OCCURS AFTER 5-10 MINUTES OF DRIVING. PROBLEM IS INTERMITTENT BUT ONGOING. MECHANIC HAS NOT BEEN ABLE TO RESOLVE PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 CHRYSLER 300C. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE ACCELERATOR PEDAL FRACTURED. THE CONTACT HAD TO MANUALLY DEPRESS THE ACCELERATOR WITH HIS LEFT HAND AND MANEUVER THE VEHICLE TO SAFETY SIMULTANEOUSLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 76,000.

WAS IN MY FATHER'S '05 CHRYSLER 300C, STOPPED AT A RED LIGHT. ENGINE SHUT ITSELF OFF, STEERING COLUMN LOCKED, AND THE OIL PRESSURE LIGHT CAME ON. I TURNED THE VEHICLE OFF AND TURNED IT BACK ON AGAIN, AND IT CONTINUED TO WORK FINE. UPON SEARCHING THE INTERNET FOR CAUSES TO THIS PROBLEM, I QUICKLY FOUND THAT THIS IS A VERY COMMON PROBLEM. LOTS OF PEOPLE HAVE HAD THEIR 300 STALL ON THEM, AND APPARENTLY THE COMPUTER IN THE CAR DOES NOT HAVE A RECORD OF THE SYSTEM FAIL, OR THE WARNING LIGHTS ON THE DASHBOARD COMING ON. THE REPAIRS APPEAR TO BE IN THE $1200 - $2000 RANGE. SEEMS LIKE SOMETHING CHRYSLER SHOULD MAKE THEIR DEALERS FIX FOR FREE, SEEING AS IT IS VERY CLEARLY A MANUFACTURER'S ERROR. HAVING LEARNED OF THE TREATMENT CHRYSLER'S CUSTOMERS RECEIVE, I WILL BE SURE NOT TO BRING MY MONEY TO THEM WHEN I NEED A CAR OF MY OWN. *TR

THIS SITUATION HAS OCCURRED COUNTLESS TIMES OVER THE LAST YEAR AND A HALF. AFTER FUELING, VEHICLE WILL RANDOMLY STALL OUT, EITHER AT IDLE OR UNDER WAY. THIS HAS OCCURRED UNDER VARIOUS DRIVING CONDITIONS; AT SPEED, AT TRAFFIC SIGNALS, OR MUCH WORSE ON TURNS (WITH OBVIOUS SUDDEN LOSS OF POWER STEERING.) I UNDERSTAND FROM MY OWN RESEARCH THAT THERE IS A CHECK VALVE IN THE FUEL TANK THAT FAILS, ALLOWING RAW GASOLINE TO ENTER THE VAPOR RECOVERY SYSTEM, WHICH CAUSES THE STALL. THE ONLY WAY TO REPLACE THIS VALVE IS TO REPLACE THE FUEL TANK, AS THE VALVE IS MOLDED INTO AND IS INTEGRAL TO THE TANKS CONSTRUCTION. I'VE HAD QUOTES AROUND $1,200 TO REPLACE THE TANK, AND IT IS NOT CLEAR THAT THE NEW TANKS WILL HAVE A REDESIGNED VALVE, SO THE PROBLEM MAY NOT IN FACT BE RECTIFIED AFTER ALL. THIS IS AN EXTREMELY DANGEROUS CONDITION, AS I'VE BEEN IN SITUATIONS WHERE THE UNEXPECTED LOSS OF POWER STEERING COMPROMISED THE VEHICLE'S PERFORMANCE ON TURNS. STALLING COMING OFF A TRAFFIC SIGNAL ACTUALLY CAUSED FOLLOWING VEHICLES TO REQUIRE DANGEROUS EVASIVE MANEUVERS. IT IS INEVITABLE THAT SOMEONE IS GOING TO GET SEVERELY HURT OR KILLED AS A RESULT OF THESE SUDDEN STALLING CONDITIONS. *TR

RECENTLY PURCHASED 2005 CHRYSLER 300C THOUGHT I WAS GETTING GREAT DEAL ONLY HAD 47700 MILES ON IT. FIRST FILL UP IT STALLED IMMEDIATELY AFTER AND DID SO SEVERAL TIMES. I TRIED REVVING UP THE ENGINE WHILE IN NEUTRAL BUT AS SOON AS I DROVE OFF IT STALLED AGAIN. I WAS SO AFRAID SOMEONE WAS GOING TO HIT ME FROM BEHIND UNTIL I COULD GET INTO TO TURNING LANE. IT SEEMED TO WORK, WELL DIDN'T STALL OUT, WHEN I WOULD ACCELERATE WHEN IT SEEMED AS IF IT WAS GOING TO GO DEAD. I TOOK IT BACK THE DEALERSHIP THEY SAID WAS A VENT IN FUEL TANK THAT WAS CLOGGED, ONLY FIX TO REPLACE WHICH THEY ARE NOT WANTING TO DO AND I HAVE ONLY HAVE THE CAR 1 WEEK. *TR

TL* THE CONTACT OWNS A 2005 CHRYSLER 300C. THE CONTACT STATED THAT WHILE DOWN SHIFTING, THE VEHICLE WOULD COME OUT OF GEAR AND INDEPENDENTLY SHIFT INTO NEUTRAL. THE CONTACT WOULD HAVE TO COAST TO THE SIDE OF THE ROAD AND WAIT SEVERAL MINUTES BEFORE THE VEHICLE COULD BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT AIR CONDITIONER DRAIN TUBE LEAKED WATER INTO THE TRANSMISSION, CAUSING THE FAILURE. THE MECHANIC ADVISED HIM THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. THE CURRENT MILEAGE WAS APPROXIMATELY 105,000. *TR

AFTER FILLING CAR WITH GASOLINE, CAR BEGINS TO STALL AND SHUT OFF. THE CAR WILL START UP AGAIN, BUT SHUTS OFF FREQUENTLY UNTIL THE GASOLINE BURNS. THEN IT RIDE NORMALLY. THIS HAS HAPPENED SEVERAL TIMES. I JUST DO NOT FILL THE CAR ANYMORE. THIS IS DANGEROUS BECAUSE IT'S SO UNEXPECTED. IT HAPPENS IN THE MIDDLE OF TRAFFIC WITHOUT WARNING. *TR

2005 CHRYSLER 300C DIED IN TRAFFIC SHORTLY AFTER FILLING FUEL TANK FULL OF GASOLINE. THE VEHICLE WAS RESTARTED AND DIED THREE MORE TIMES IN TRAFFIC BEFORE RUNNING FINE. MY CONCERN IS THAT THIS IS AN ACCIDENT WAITING TO HAPPEN. ONLINE RESEARCH SHOWED THIS IS A COMMON OCCURRENCE IN THIS VEHICLE AFTER FILLING FUEL TANK TO FULL. APPARENTLY RAW GASOLINE (RATHER THAN VAPORS) GETS INTO THE EVAPORATIVE SYSTEM AND ENTERS THE ENGINE, CREATING A RICH FUEL SITUATION AND THE STALLING. THIS IS A VERY SERIOUS SITUATION AND SHOULD BE INVESTIGATED FURTHER. THANK YOU. *TR