2008 CHRYSLER ASPEN Complaints

ASPEN WAS PARKED WIFE IN PASSENGER SEAT PULLED ON WINDSHIELD PILLAR ASSIST HANDLE HANDLE BROKE LOOSE WIFE FELL TO GROUND AND WAS INJURED. *DSY

I RECENTLY BOUGHT MY CHRYSTLER ASPEN AND AS I WAS DRIVING DOWN THE ROAD I NOTICED A CLUNK ON THE REAR END. I CHECKED TO MAKE SURE THE SPARE TIRE OR MUFFLER WASN'T LOOSE AND EVEN TOOK IT TO A LOCAL SHOP WHERE WE FOUND A BOLT LOCATED RIGHT AT THE REAR DIFFERENTIAL THAT APPEARS TO BE LOOSE CAUSING THAT CLUNKING NOISE. I WENT ONLINE TO SEE IF ANY OTHER CHRYSTLER OWNERS HAD THE SAME ISSUE AND FOUND OUT THAT THERE HAS BEEN CERTAIN DODGE AND CHRYSTLER VEHICLES AFFECTED AND EVEN RECALLED FOR THIS SAME ISSUE. I ALSO READ ONLINE THAT DRIVING WITH THAT BOLT BEING LOOSE COULD DAMAGE THE DIFFERENTIAL AND CAUSE IT TO LOCK UP MAKE THE WHOLE TRUCK TO STOP VERY SUDDENLY CAUSING THE DRIVER TO LOOSE CONTROL OF THE VEHICLE. I CALLED 2 DIFFERENT LOCAL DEALERSHIPS AND EXPLAINED THE ISSUE AND ASKED THEM IF MY VEHICLE HAD A RECALL LIKE MANY OTHER SIMILAR MODELS HAD,BUT THEY TOLD ME THERE WAS NO RECALLS ON MY TRUCK. I'M CONCERNED FOR MY SAFETY AND MY FAMILY'S DUE TO MY TRUCK'S CONDITION AND I WOULD LIKE TO LET CHRYSTLER KNOW THIS POOR WORKMANSHIP COULD CAUSE A SERIOUS IF NOT FATAL ACCIDENT FOR ME AND MY FAMILY IF NOT RESOLVED.

MY 2008 ASPEN WAS BUILT DURING THE SAME TIME AS THE 2009 MODEL YEAR THAT HAD THE FAULTY PINION NUTS/SHAFT. RIGHT AT 170,K OUR PINION BEARING IS BAD. I BELIEVE THEY SAME PARTS WERE USED AND DODGE REFUSES TO WORK WITH ME. THANKFULLY IT HAS NOT BROKE YET BUT THE TRUCK IS NEEDING TO BE IN THE SHOP.

2008 CHRYSLER ASPEN STALLS FOR APPROXIMATELY FIRST 5 MILES AFTER REFUELING. MIL ILLUMINATES (CODES ARE FOR P0455 AND P0456) THEN CLEARS BY ITSELF AFTER A FEW DAYS. AFTER RESEARCHING, I HAVE DISCOVERED THAT THE PROBLEM IS THE ORVR VALVE MALFUNCTION, THIS IS DOCUMENTED NUMEROUS TIMES ON MANY WEBSITES THROUGHOUT THE INTERNET. THIS LEADS TO THE EVAP CANISTER MALFUNCTIONING (HTTP://OPENSIUC.LIB.SIU.EDU/CGI/VIEWCONTENT.CGI?ARTICLE=1006&CONTEXT=AUTO_PRES). THIS IS NOT ONLY A FAILURE OF THE EMISSION CONTROL SYSTEM, BUT ALSO A SAFETY CONCERN SINCE THE VEHICLE STALLS, WHICH IT ALWAYS DOES WHEN SLOWING OR STOPPING AFTER FILL-UP. BECAUSE THE VEHICLE WILL LOSE POWER STEERING AND POWER BRAKE ABILITY, I CAN NO LONGER LET MY WIFE OR CHILDREN OPERATE THIS VEHICLE AS IT HAS BECOME A SAFETY CONCERN. THIS VEHICLE AND OTHER RELATED VEHICLES (DODGE DURANGO, RAM 1500, AND OTHERS) SHOULD BE RECALLED AT ONCE TO HAVE THIS ISSUE ADDRESSED BEFORE INJURIES OCCUR, IF IN FACT THEY ALREADY HAVEN'T. THIS HAS BEEN HAPPENING THE MY VEHICLE SINCE DECEMBER 2016 BUT HAS LAST HAPPENED IN MARCH 2018 (NOW).

STEERING PROBLEMS HAD RACK AND PINION REPLACED, INNER TIRE RODS REPLACED, LOST CONTROL OF VEHICLE, OUTER RIGHT TIRE RODS BROKEN, VERY FORTUNATE MY FAMILY AND I NOT HURT (70MPH ON I95), REPLACE OUTER TIRE ROD, PLAY IN STEERING REPLACE STEERING YOKE. ALSO WATER GETS INTO ELECTRICAL SYSTEM SHORTING OUT COMPUTER. DO NOT KNOW HOW WATER GETS IN, CAN NOT SEE FROM INSIDE OF VEHICLE, BUT CAN SOMETIMES HEAR WATER SLOSHING AROUND.

VEHICLE SHUT OFF FOR NO APPARENT REASON WHILE ENTERING ONTO AN EXPRESSWAY. LOSS OF POWER STEERING MADE VEHICLE DIFFICULT TO CONTROL TO SAFELY GET ONTO THE SHOULDER. SUDDEN LOSS OF SPEED MADE THE VEHICLE A FURTHER HAZARD. ONCE ON THE SHOULDER, THE VEHICLE COULD BE PHYSICALLY KEYED OFF, THEN RESTARTED WITHOUT ISSUE. CAUSE OF FAILURE IS UNKNOWN.

WHILE DRIVING, THE VEHICLE INTERMITTENTLY SLIPPED INTO 4-WHEEL DRIVE LOW. VEHICLE IMMEDIATELY BECAME HARD TO STEER/MOVE IN THIS CONDITION, DANGEROUS TO DRIVE AS THE VEHICLE'S HANDLING COULD CHANGE AT ANY MOMENT... AT ANY SPEED.

HAVING A PROBLEM WITH THE VEHICLE STALLING AFTER REFUELING WITH GAS. VEHICLE WILL STUTTER AND STALL WITHIN A COUPLE OF MINUTES. THIS IS DANGEROUS AS THE STALL OCCURS WHILE DRIVING AND YOU LOSE STEERING CONTROL OF THE VEHICLE. NEITHER A DEALER OR PRIVATE MECHANIC CAN GET A CLEAR INDICATION AS TO WHAT IS CAUSING THE ISSUE. FUEL PUMP RELAY(MARCH 2017) AND EGR VALVE(JULY 2017) HAVE BOTH BEEN REPLACED AND PROBLEM IS STILL OCCURS. VEHICLE RUNS FINE AFTER SITTING FOR A WHILE BUT STALLS AFTER REFUELING. OUR VEHICLE HAS BEEN IN THE SHOP SINCE JULY 5. WE GOT IT BACK ON JULY 19 AND WHEN WE PUT GAS IN IT , IT DIED AGAIN AND HAD TO BE TOWED BACK THE SAME NIGHT TO THE SHOP WHO HAD JUST REPLACED THE EGR VALVE.

WHEN I FILL THE GAS TANK UP AND THE GAS PUMP CLICKS, I REMOVE THE GAS HANDLE AND GAS WILL SPILL OUT FROM THE TANK. THIS HAPPENS EVERY TIME I FILL MY GAS TANK UP.

2008 CHRYSLER ASPEN. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE AIRBAG INFLATOR. *LD THE CONSUMER STATED THE LOCAL DEALER HAD NOT RECEIVED THE PARTS NECESSARY TO PERFORM THE RECALL ON THE VEHICLE. UPDATED 05/03/2017*JS