2008 CHRYSLER ASPEN 4X4 Complaints

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 CHRYSLER ASPEN 4X4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V352000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2008 CHRYSLER ASPEN 4X4. WHILE DRIVING 25 MPH, ALL OF THE EMERGENCY WARNING INDICATORS ILLUMINATED. THE VEHICLE LOST POWER AND STALLED. THE VEHICLE WAS TOWED AND DIAGNOSED THAT THERE WAS CATASTROPHIC ENGINE FAILURE DUE TO A FRACTURED TIMING CHAIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS TOO OLD AND HAD TOO MANY MILES; THEREFORE, THEY COULD NOT ASSIST. THE CONTACT WAS ADVISED TO CALL NHTSA. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

I BEGAN ACCELERATING ONTO A RAMP TO ENTER ONTO A MAJOR HIGHWAY AND MY ASPEN COMPLETELY LOSS ALL POWER SUDDENLY. THE ENGINE JUST SHUT DOWN INCLUDING POWER ALL ELECTRONICS. I HAD TO LET THE CAR GLIDE TO THE SHOULDER, PUT IT IN PARK AND RESTART THE CAR, WHICH IT STARED AS IT ALWAYS HAS. THIS HAS NEVER HAPPENED BEFORE NOR DID IT HAPPEN AGAIN. I HAD THE CAR CHECKED OUT AND THEY COULDN'T FIND ANYTHING WRONG. BEING THAT THIS HAPPENED WHILE ENTERING A BUSY HIGHWAY, A SERIOUS ACCIDENT COULD HAVE BEEN CAUSED.

THIS VEHICLE HAS AWD AND ELECTRONIC SHIFTING OF THE TRANSFER CASE. THE MOTOR FOR THE TRANSFER CASE ENGAGES AND SHIFTS THE TRANSMISSION INTO 4WD LOCK DURING LOW SPEED TURNS AND WHILE PARKED.

VEHICLE SPUTTERS AND DIES AFTER REFUELING. AFTER REFUELING THE FUEL TANK THE VEHICLE DOES NOT WANT TO STAY RUNNING. IT WILL RUN LONG ENOUGH TO PULL OUT, OR ATTEMPT TO PULL OUT INTO TRAFFIC AND THEN WILL DIE. THIS IS VERY UNSAFE. MY MECHANIC HAS DETERMINED IT TO BE A CHECK VALVE IN BETWEEN THE FUEL TANK AND VAPOR CANISTER THAT FAILS AND ALLOWS RAW FUEL TO ENTER THE EMISSION SYSTEM. THIS IN TURN CAUSES THE VEHICLE TO DIE. ONE WOULD THINK THAT THIS IS A SIMPLE FIX, BUT THE CHECK VALVE IS ONLY AVAILABLE WITH THE $807 FUEL TANK. THIS ISSUE IS SERIOUS AND COULD CAUSE A WRECK WHICH COULD LEAVE TO INJURIES AND OR DEATH.

WE PURCHASED THE VEHICLE SECOND HAND. ONE PREVIOUS OWNER PRIOR. JUST RECENTLY IT STARTED SPITTING GAS BACK DURING FILL UP (CAR IS PARKED, NOT RUNNING). ANYTIME WE FILL UP WITH GAS, THE PUMP SHUTS OFF AND IMMEDIATELY GAS SPITS BACK OUT OF THE TANK. VARYING AMOUNTS OF GAS THAT SPITS BACK AT THE PUMP. EVERY TIME, WITH FORCE, HAVING TO ALERT THE GAS STATION ATTENDANTS TO FUEL SPILLED ON THE GROUND DUE TO THE SPIT BACK. I DON'T KNOW FOR SURE WHAT WOULD CAUSE THE SPIT BACK.

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 CHRYSLER ASPEN 4X4. THE CONTACT RECEIVED NOTIFICATION OF A RECALL FOR THE AIR BAGS AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

THE VEHICLE STALLS WHILE IN MOTION REGARDLESS OF ROAD STREET OR HIGHWAY AFTER REFUELING, WE TOOK THE VEHICLE TO THE DEALERSHIP AND WAS TOLD THAT THE FUEL TANK & THE ON-BOARD REFUELING VAPOR RECOVERY SYSTEM IS FAULTY AND THAT RAW LIQUID FUEL WAS GOING INTO THE ENGINE CAUSING FAILING. WE HAVE LITTLE CHOICE BUT TO FIX THE PROBLEM, AS THIS COULD POTENTIALLY CAUSE A FIRE IN THE ENGINE AND\OR CAUSE A POTENTIAL ACCIDENT AS THE ENGINE STOPS WHILE IN MOTION.

THE FUEL SPRAYS BACK OUT OF THE TANK DURING A REFUELING. IT DOESN'T MATTER THE TIME OF YEAR ALTHOUGH DURING THE WARMER TEMPERATURES IT IS MORE INTENSE. THIS IS A SAFETY ISSUE WHICH NEEDS TO BE CORRECTED BY THE MANUFACTURER.

WHEN FUELING MY 2008 CHRYSLER ASPEN, FUEL SPLASHES BACK OUT OF THE FUEL TANK INLET PIPE ONTO THE PERSON PUTTING FUEL INTO THE TANK. THIS HAPPENS EVEN THOUGH YOU MAY NOT BE TOPPING OFF THE TANK. FUEL SPLASHES ONTO PERSON, CLOTHES, HANDS, SHOES, VEHICLE QUARTER PANEL AND PUDDLES ON CONCRETE PAD . I HAVE RECEIVED SKIN IRRITATION FROM THE CONTACT OF THE FUEL ON MY HANDS AND HAVE TO GO IN THE STORE TO WASH MY HANDS OR WASH THEM IN THE DIRTY WATER IN THE WINDSHIELD SCRAPER HOLDER. I HAVE A COUPLE OF FRIENDS THAT OWN ASPENS AND THEY HAVE THE SAME PROBLEM. IN DOING RESEARCH ON THIS ISSUE, I SEE WHERE CHRYSLER HAD A RECALL ON CERTAIN DURANGOS AND ASPENS, BUT ACCORDING TO MY DEALER, MY VEHICLE AND MANY MORE WERE EXCLUDED. THIS IS A DANGEROUS ISSUE AND NEEDS TO BE ADDRESSED IMMEDIATELY BY CHRYSLER. IT IS A MANUFACTURERS DEFECT AND THEY ARE RESPONSIBLE. HOW MANY PEOPLE HAVE TO BE INJURED OR KILLED BEFORE NHTSA MAKES CHRYSLER DO A RECALL ON ALL AFFECTED VEHICLES. QUESTION BELOW ASKS, "WHEN DID THIS HAPPEN"? IT HAPPENS EVERY TIME I PUT FUEL IN MY ASPEN. IT CAN HAVE 1/4 TANK AND I CAN PUT IN 5 GALLONS OF FUEL REAL SLOW AND WHEN I WITHDRAW THE NOZZLE, FUEL WILL SPLASH OUT. LAST TIME IT HAPPENED WAS TODAY...