2018 CHRYSLER PACIFICA Complaints

Vehicle engine is stalling, smells like burnt makes a lot of knocking sound and has a lot of white smoke coming out the muffler. My safety of my family and me is put at risk because this is a safety hazard that can cause an accident or a fire.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated while driving at an undisclosed speed, the middle passenger’s side captain seat became inoperable. The contact stated the back rest failed to remain locked in place. The contact stated that seat fell forward, raised up and unlocked before sliding forward and collapsing. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact was informed by the dealer that a fix was not available for the failure. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 81,000.

The engine was unresponsive and made it difficult to pull into the oncoming traffic. We found out the head gasket was blown and it finally just shut down. Then after we fixed that the lifters and heads were gone even after we had the heads milled and got new gaskets and other parts amounting to $11000.00 so far. We have this car for two years and we have put less that 5000 miles on the car.

There was a rough idle and tje the check engine light came on, idle smoothed out and the the following week the check engine light started blinking and the van started to miss and then drove rough. Then I took the van to dealer and they said it seemed that I have a cracked head after I received engine code for misfire on cylinder 3... sounds like this is a growing issue for this van and engine type.. Thank You for any help with this situation.

The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Blown head gasket. Had to get it repaired. Steering is catching as well. Probably need a new steering box. It’s been one expensive repair after another.

I bought my 2018 Chrysler Pacifica limited about two years ago. It’s been the worst decision I’ve ever made. I have just about a 3% rate and with the amount of issues these things have I’m so far upside down it’s not even funny. This car with all of its known issues is depreciating faster than I can pay for it. I currently have about 129,000 miles on it. I couldn’t get rid of this thing if I tried. The Chrysler dealership I service it with said they would give me 4000.00 IF they were willing to buy it back. The engine build company my mechanic uses says they won't even build these engines at all because of how many issues they have. So no option other than to buy the exact same engine is has now through Chrysler and know it will do it again. I’m having stalling/accelerating issues (shop can’t figure it out, kids cry when it stalls in traffic.. I've been in for it about 9 times to two different place) Oil cooler housing unit replaced last year (taken it back in a few times for ongoing leak, now need a head gasket) Head gasket Batteries galore Ongoing start stop issues My AC went out the month I bought it (leak in the lines near the rear) 3000k to fix The shop says it needs lifters, cam shafts and rockers (might as well do the engine if I had the extra money after paying off the rest of the repairs) My heated and cooled seats have stopped working numerous times Dash comes on and off when it wants Back up camera stays on the screen while I drive as much as it doesnt My rear washer fluid sprays INSIDE the car onto my kids Rear power seats stopped working multiple times now Get in to head to work and it just won’t start…. Have to basically play a video game with the controls and key fob to miraculously start it up Starting to rust already We have owned 2 Durango’s, 2 dodge rams, a Chrysler Sebring and now this. Clearly we support Chrysler but after this my husband switched to a ford truck and I will be going back as soon as I can if this isn't resolved.

74,121 miles head warped on engine. $4300 repair to replace head and head gasket.

[XXX] [XXX] [XXX] National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation 1200 New Jersey Avenue SE Washington, DC 20590 Subject: Complaint Regarding Recurrent Mechanical Issues and Potential Safety Concerns with 2018 Chrysler Pacifica Dear NHTSA Office of Defects Investigation, I am writing to formally report repeated mechanical issues with my 2018 Chrysler Pacifica (VIN [XXX] ), which have raised significant concerns regarding the vehicle’s reliability and safety. In 2023, my vehicle initially experienced a persistent ticking noise in the engine, leading to extensive repairs. These included replacing the tappets, rockers, and timing chain tensioner on the right bank of the engine. Following these repairs, the vehicle exhibited low oil pressure, ultimately requiring a complete long block replacement. These issues left the vehicle out of service for nearly two months, significantly disrupting our daily lives. Despite these major repairs, my Pacifica has recently developed overheating issues, necessitating the replacement of the radiator at an estimated cost of over $2,000. The vehicle has less than 60,000 miles, and I find it deeply concerning that such critical mechanical issues are occurring at such low mileage. These repeated failures suggest a potential underlying defect in the design or manufacturing of this vehicle, which could present a safety risk. An overheating engine, for instance, poses a potential hazard both to the occupants and to other road users. As a police officer and parent of three young children, I rely on this vehicle for my family’s safety and transportation. I respectfully request that the NHTSA investigate whether these issues are indicative of a broader defect in 2018 Chrysler Pacifica models. I believe an investigation could help identify potential safety risks to other owners and encourage Chrysler to address these problems proactively INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The hybrid battery coolant heater (part 68443445AC) was confirmed a problem, however the dealership wont review ANY recalls on my vehicle until I pay $1700 to replace that part. However, there are MULTIPLE incidents online showing this is a problem with this vehicle and should be a recall as this is obviously defective within the first 150000 miles. My car has roughly 124K miles, making it just outside the warranty coverage. Shortly before this lamp warning (check engine) came on my steering wheel started "sticking" making it hard to steer in a curve, causing me to veer off the road. Within 7 days of this happening, is when my check engine light appeared, throwing code POE15. The heat now also takes much longer to warm up- like 30 minutes longer. The dealership said none of the issues are connected, however after online research I have determined that is not true.