2002 CHRYSLER PT CRUISER Complaints

DT*: AT 45,000 MILES THE FRONT LOWER CONTROL ARM BUSHINGS AND LINK FAILED AND HAD TO BE REPLACED. UPDATED 03/17/06. *JB

AT 24,000 MILES TRANSMISSION WENT OUR COMPLETELY. NOW AT 65,000 MILES TRANSMISSION IS LEAKING AND NEEDS A TRANSMISSION SOLENOID PACK REPLACED. ENGINE COMPARTMENT SMOKES AND SMELLS HOT. FOUND TSB#0801505 AND NHTSA #10013731 ON FILE BUT DEALER CAN NOT TELL ME ANYTHING. FOUND SEVERAL WEB SITE LISTING THIS SAME COMPLAINT SOME WITH CATASTROPHIC FAILURES ON THE ROAD. *JB

MY 2002 PT CRUISER HAS BEEN MAINTAINED PROPERLY, INCLUDING OIL CHANGES, FOR THE ENTIRE TIME THAT I HAVE OWNED IT. IN SPITE OF THIS, IT HAS DEVELOPED ENGINE PROBLEMS THAT APPEAR TO BE RELATED TO THE FORMING OF SLUDGE IN THE ENGINE. THE OIL CONSUMPTION ON THE CAR HAS BEEN APPROXIMATELY A QUART PER 1000 MILES EVER SINCE THE 36000 MILE SERVICE. I FEEL THAT THERE IS SOME INHERENT DESIGN PROBLEM THAT HAS LED TO THE PREMATURE WEARING OUT OF THE ENGINE AND THE LOSS OF POWER IN THIS AUTOMOBILE. I THINK THAT THIS IS UNACCEPTABLE, REGARDLESS OF THE MILEAGE, IN THE SPACE OF 4 YEARS TIME. *NM

DT: THE CONTACT STATED THE DRIVER'S SIDE AND PASSENGER'S SIDE AIR BAGS DEPLOYED WHILE DRIVING DOWN THE HIGHWAY. THERE WAS NO PRIOR WARNING. ALSO , THE RIGHT FRONT BRAKE HAD A LOUD POPPING AND SQUEALING NOISE, THIS CAUSED THE STEERING WHEEL TO VIBRATE. THE RIGHT FRONT BRAKE OVERHEATED, IT TURNED THE RIM RED HOT. HE COULD SMELL THE BRAKE DUST FROM THE RIGHT FRONT BRAKE. HE CONTACTED THE DEALER, THEY HAVE REPEATEDLY REPLACED THE BRAKES, BRAKE PADS, DISC CALIPER, AND ROTORS. HE WAS STILL HAVING THE SAME PROBLEM WITH THE VEHICLE. *AK UPDATED 12/7/2005. THE BATTERY HAD TO BE REPLACED AT 14972 MILES. *NM

DT: THE CONTACT STATES THERE IS A NHTSA CAMPAIGN ID NUMBER 04V268000 CONCERNING THE STEERING POWER ASSIST HOSE PIPING AND CONNECTIONS. THE CONSUMER IS EXPERIENCING THE SAME SYMPTOMS AS INDICATED IN THE RECALL BUT THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. NO REPAIRS HAVE BEEN MADE AT THIS TIME DUE TO THE EXPENSE. *JB

DT: THE CONTACT STATED THE DRIVER'S SIDE AND PASSENGER'S SIDE AIR BAGS DEPLOYED WHILE DRIVING DOWN THE HIGHWAY. THERE WAS NO PRIOR WARNING. ALSO , THE RIGHT FRONT BRAKE HAD A LOUD POPPING AND SQUEALING NOISE, THIS CAUSED THE STEERING WHEEL TO VIBRATE. THE RIGHT FRONT BRAKE OVERHEATED, IT TURNED THE RIM RED HOT. HE COULD SMELL THE BRAKE DUST FROM THE RIGHT FRONT BRAKE. HE CONTACTED THE DEALER, THEY HAVE REPEATEDLY REPLACED THE BRAKES, BRAKE PADS, DISC CALIPER, AND ROTORS. HE WAS STILL HAVING THE SAME PROBLEM WITH THE VEHICLE. *AK

WAS LOSING MASSIVE AMOUNTS OF AIR FROM LEFT REAR TIRE. TOOK IT TO SEARS, FOR TIRE REPAIR, AND WAS TOLD THAT THE TIRE WAS FINE, BUT THAT THE CHROME PLATED WHEEL WAS SEVERELY CORRODED AT THE BEAD. THEN TOOK CAR TO DEALER, WHERE THE MECHANIC SAID THAT THE WHEEL WAS BEYOND REPAIR, AND ORDERED A NEW ONE. REPLACED A WEEK LATER. OK SINCE, HOWEVER I NOW HAVE TWO MORE WHEELS DOING THE SAME THING. WARRANTY HAS EXPIRED, NOT SURE WHAT TO DO. I AM AFRAID THAT THE WHEELS MAY FAIL. *JB

NOTICED A LARGE AMOUNT OF FLUID UNDER CAR IN THE MORNING. AFTER INVESTIGATION, DETERMINED IT WAS TRANSMISSION FLUID. THE FLUID LEVEL IN CAR WAS VERY LOW. SINCE IT WAS A"SPECIAL" FLUID, I COULD NOT BUY IT AT THE LOCAL PARTS STORE. TOOK A CHANCE AND DROVE IT TO THE DEALER. MECHANIC DETERMINED THAT IT WAS DEFECTIVE "SOLENOID PACK" AND "COOLER LINES". PARTS REPLACED, OK SINCE. IF IT HAD HAPPENED ON THE HIGHWAY, IT WOULD HAVE BEEN A CATASTROPHIC TRANSMISSION FAILURE AND POSSIBLY FIRE. *JB

SUBJECT: 2002 PT CRUISER BRAKES / TRANSMISSION I DO NOT KNOW IF YOU ARE THE PROPER PERSON TO BRING UP SOME SAFETY ISSUES WITH THE CHRYSLER PT CRUISER BUT IT IS MY SINCERE HOPE THAT MAYBE YOU COULD DIRECT THIS TO SOMEONE WHO CAN. ABOUT TWO MONTHS AGO, I HAD MY BRAKES SERVICES AT A LOCAL SHOP THAT I HAVE BEEN DEALING WITH FOR 10 YEARS. WHEN I WAS YOUNGER, I USED TO DO MUCH OF THE WORK TO CARS MYSELF, AND ONCE IN A WHILE I DO AN AUDIT OF THE WORK HE DOES. AS ALWAYS, HE DOES A GREAT JOB. RECENTLY I WAS DRIVING BACK FROM LAKE TAHOE ON I80. THIS IS MOSTLY FULL OF MOUNTAINS WITH VERY STEEP GRADES AND A LOT OF SHEER CLIFFS. I HAD A FULL CAR LOAD OF HUMAN AND PERSONAL PROPERTY SO I WOULD CONCEDER IT TO BE CLOSE TO THE MAX WEIGHT OF THE CAR. I PLACED THE AUTOMATIC TRANSMISSION FROM OVER-DRIVE TO THE NEXT LOWEST GEAR DURING THE STEEP GRADES. WE DID NOT SLOW DOWN AT ALL! I DISCOVERED TO MY HORROR THAT THE NEXT LOWEST TRANSMISSION SPEED WAS THIRD. SO I DROPPED IT DOWN AGAIN TO THE NEXT LOWER GEAR AND IT WAS FIRST GEAR. SINCE OUR SPEED WAS 55 MILES PER HOUR, IT DID NOT ENGAGE AT ALL. THANK GOODNESS IT DID NOT. SO I APPLIED THE ABS FRONT DISCS AND REAR DRUMS. BY THE TIME WE GOT DOWN FROM THIS AREA, I TOTALLY BURNED OUT THE BRAKES. I HAVE DRIVEN OTHER CARS FROM CALIFORNIA TO TEXAS TO FLORIDA WITH SIMILAR LOADS, BUT NEVER WITH A TRANSMISSION WITH NO SECOND GEAR. I HAVE NEVER BURNED NEW BRAKES UP IN A SIMILAR FISSION AND REQUIRED ONE NEW DISC. I DO NOT THINK THAT THEY ??CHRYSLER?? DID ENOUGH ENGINEERING IN STOPPING THIS CAR WITH STEEP HIGHWAY GRADES WITH A FULL LOAD, AND THE POPULATION IS AT RISK FOR RUN-AWAY CARS IN THOSE AREAS. THANK YOU VERY MUCH FOR YOUR VALUABLE TIME. *NM

THE CAR BEGAN REPEATEDLY OVERHEATING REQUIRING AC TO BE TURNED OFF. THE COOLING FAN HAS CEASED WORKING AND AN ENTIRE ASSEMBLE NEEDED TO BE PURCHASED. IN DISCUSSING THIS WITH TWO SEPARATE GARAGES, THEY INDICATED THIS WAS A COMMON PROBLEM THAT THEY SEE FREQUENTLY AND SHOULD HAVE BEEN A SUBJECT OF RECALL. *NM