2002 CHRYSLER TOWN AND COUNTRY Complaints

THE VAN WAS PURCHASED IN MARCH AND AROUND JULY THE MIDDLE SECTION OF THE FRONT WHERE THE AC UNIT, RADIO, CONTROLS, ETC ARE LOCATED BEGAN TO STOP WORKING PROPERLY. THE AC WILL NOT CUT OFF, INSTEAD THE AIR PRESSURE INCREASES AND DOESN'T STOP. THIS HAS AFFECTED MY BACK UNIT AND THE HEAT WILL NOT WORK, WHICH MAKES IT HARD TO BEAR WITH SMALL CHILDREN. RECENTLY, THE CD CHANGER HAS BEEN MESSING UP AND NOT EJECTING CD'S OR CHANGING. NOTHING HAS BEEN REPAIRED, BECAUSE IT WILL COST A LOT, ACCORDING TO THE DEALER, TO LOCATE THE PROBLEM. *TR

TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED. THE VEHICLE MADE A CLACKING NOISE AND SMOKE BEGAN TO RISE FROM THE ENGINE. THE CHECK ENGINE LIGHT DID NOT ILLUMINATE UNTIL THE VEHICLE BEGAN SMOKING. THE CONTACT PULLED TO THE SIDE OF THE ROAD. THE ENGINE SHUT OFF AND THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN. HE ADDED WATER TO THE RADIATOR AND DROVE TO HIS RESIDENCE. THE VEHICLE WAS THEN TOWED TO THE DEALER AND THEY STATED THAT THE COMPUTERS FAILED AND NEEDED TO BE REPLACED. THE CONTACT DISAGREED AND STATED THAT THE VEHICLE OVERHEATED BECAUSE THE FAN AND COOLING SYSTEM WERE INADEQUATE IN SIZE. THE DEALER DID NOT REPAIR THE VEHICLE. THE CURRENT MILEAGE WAS 71,421 AND FAILURE MILEAGE WAS 50,000.

AIRBAG LIGHT AND ALARM TONE COMES ON INTERMITTENTLY WHILE DRIVING, SOMETIME REMAINS ON FOR MORE THAN 10 SECONDS THEN GOES OUT AND COMES BACK ON AGAIN AFTER A FEW SECONDS. RECENTLY AT DEALER FOR ANOTHER UNRELATED REPAIR AND ASKED THEM TO TROUBLESHOOT THIS, TECHNICIAN SAID IT WAS AN INTERMITTENT OPEN IN THE CLOCK SPRING (CS) AND THAT THERE WASN'T A RECALL. I HAD REPORTED PREVIOUS CLOCK SPRING PROBLEM ON MY 1997 DODGE WHICH WAS SUBSEQUENTLY RECALLED AND KNOW WHAT IT LOOKS LIKE, BUT THIS TIME THE CRUISE, AND HORN STILL WORKED. I PURCHASED A NEW CS P/N 5082050AC AND PULLED THE STEERING WHEEL MYSELF TO REPLACE IT. IT APPEARS TO HAVE FIXED THE PROBLEM. HOWEVER, I NOTICED THAT THE REPLACEMENT CS WAS DIFFERENT THAN THE ORIGINAL CS (WHICH I KEPT). THE DEFECTIVE ORIGINAL CS HAS THE FOLLOWING NUMBERS ON IT P/N 04685712AC AND SMALLER *1 324101379R*. IT ALSO HAS A SOCKET WITH COPPER CLIPS WHERE A CONNECTOR SPLIT 4 WIRE HARNESS CONNECTS TO THE CS WITH THE TWO CABLES GOING TO THE AIRBAG MODULE. THE REPLACEMENT CS HAD NO SOCKET AND HAD ELIMINATED THE CONNECTOR AND HAD TWO 2 WIRES HARNESSES HARD WIRED TO THE CS. I DISASSEMBLED THE DEFECTIVE CS AND CHECKED IT FOR BREAKS IN THE RIBBON CONDUCTORS THERE WEREN'T ANY VISIBLE ALSO THE CONSTRUCTION APPEARED TO BE MUCH MORE DURABLE POSSIBLY WITH BRAIDED COPPER LAMINATE RUNS. SINCE IT WAS INTERMITTENT I SUSPECT THAT THE PROBLEM IS ACTUALLY WITH THE HARNESS CONNECTOR TO THE CS SOCKET FOR THE AIRBAG CONNECTION, DEVELOPING A LOOSE OR DIRTY CONTACT CONNECTION. PERHAP CHRYSLER ALREADY KNOWS THIS AND THAT IS WHY THE REPLACEMENT HAS ELIMINATED THAT POINT OF FAILURE. PLEASE PURSUE A RECALL ACTION ON THIS FOR THE SOCKET CONNECTOR TYPE CS AS THIS CAN CAUSE AIRBAG FAILURE AND POSSIBLE DEATH OR INJURY. I AM AN ENGINEER BY TRADE AND IF THEY WANT THE OLD PART FOR TESTING THEY CAN CONTACT ME DIRECTLY. *TR

MY RIGHT SIDE AIRBAG INTERNALLY OPENED (2002 CHRYSLER TOWN & COUNTRY 3.3 V-6) STATED BY METRO JEEP AND CHRYSLER. I DON'T UNDERSTAND WHY. I HAVE NO IDEA WHY THIS HAPPENED. I HAVEN'T BEEN IN ANY KIND OF COLLISION. AT METRO JEEP & CHRYSLER. I WAS TOLD THAT IF A NEW MODULE IS NOT PUT IN, THE RIGHT SIDE AIRBAG WON'T DEPLOY. I BELIEVE THAT THIS IS A MANUFACTURER"S (CHRYSLER) ERROR. *JB

I HAVE HAD A MAJOR PROBLEM WITH MY 2002 TOWN & COUNTRY MINI VAN SINCE WE PURCHASED IT FROM CU FLEET. THE VAN HAS BEEN IN THE SHOP FOR A NUMBER OF REPAIRS. FROM THE ENGINE TO THE SENSORS. *JB

THE TRANSMISSION WENT OUT ON MY 2002 CHRYSLER TOWN & COUNTRY MINI VAN AS WE WERE DRIVING ON THE FREEWAY. THE VAN HAD ONLY 51,700 MILES ON IT! I HAD IT TOWED TO THE NEAREST DEALERSHIP, AND THEY WANTED $4,000 TO FIX IT. I CALLED CHRYSLER TO ASK IF THEY WOULD COVER THE COST OF THE REPAIR SINCE THE MILEAGE WAS SO LOW, BUT THEY REFUSED TO HELP ME BECAUSE THE WARRANTY WAS UP. I HAD IT FIXED AT A TRANSMISSION SHOP WHERE THEY REBUILT THE TRANSMISSION. I DON'T HAVE THE OLD PARTS AVAILABLE. THERE MUST BE A DEFECT IN THE TRANSMISSION, OR SOME KIND OF "WEAK" PARTS FOR IT TO GO OUT AT SUCH LOW MILEAGE. I DO REGULAR MAINTENANCE ON THE VAN, I CHANGE THE OIL EVERY 3,000 MILES, AND EVEN DID THE 30,000 MILES SERVICE THAT WAS HIGHLY RECOMMENDED BY THE DEALERSHIP! *JB

MY AIRBAG LIGHT IS ON, IT IS A KNOW PROBLEM IN THE CHRYSLER TOWN & COUNTRY HOWEVER THIS YEAR (2002) DOESN'T HAVE A RECALL. I ALSO HAVE A 2005 TOWN & COUNTRY THAT IS COVERED UNDER THE RECALL. I WANT MY AIRBAG PROBLEM COVERED UNDER THE RECALL, THIS IS OBVIOUSLY A BIG PROBLEM AND I NO LONGER FEEL SAFE IN MY VEHICLE. THE AIRBAG COULD DEPLOY OR MAY NOT DEPLOY BECAUSE OF THIS ISSUE. PLEASE CONTACT ME AND TELL ME HOW I CAN HAVE THIS SAFETY ISSUE RESOLVED. *TR

WHILE THE VEHICLE IS IN MOTION, THE REAR HATCH OPENS. THE CAR IS EQUIPPED WITH A POWER LIFTGATE. THIS OCCURRED TWICE DURING ONE TRIP TODAY. ONCE WITH THE DOOR CLOSED VIA THE POWER MECHANISM, AND AGAIN AFTER CLOSING THE DOOR MANUALLY. IT HAD PREVIOUSLY OCCURRED ONCE BEFORE, ABOUT 2 YEARS PREVIOUS. *JB

OVER A PERIOD OF A FEW WEEKS I WAS EXPERIENCING INTERMITTENT ELECTRICAL PROBLEMS WHERE THE AIR CONDITIONER (A/C) FAN, RADIO, WINDSHIELD WIPERS, AND POWER WINDOWS WOULD STOP WORKING FOR SEVERAL MINUTES AND THEN START WORKING AGAIN. THE PROBLEM GOT WORSE OVER THESE WEEKS. AFTER 3 TRIPS TO THE DEALER THEY TOLD ME THAT BATTERY ACID HAD LEAKED ON THE WIRING HARNESS AND I NEEDED A NEW ONE. I HAD NO PROBLEM WITH THE BATTERY, AND CHRYSLER DEALERS HAD PERFORMED MOST ON THE MAINTENANCE ON THE CAR AND NO ONE HAD TOLD ME THAT BATTERY ACID WAS LEAKING ON THE WIRING HARNESS. THE NEW WIRING HARNESS COST ME $2,600. IT SEEMS TO ME TO BE A DEFECT IN DESIGN TO RUN THE WIRING HARNESS UNDER THE BATTERY. ALSO, WHY CAN'T THE WIRING HARNESS BE MODULAR WHERE ONE SECTION COULD BE REPLACED AT A MUCH LOWER COST.*AK

AIRBAG LIGHT CAME ON AND DOESN'T GO OFF. I TOOK IT TO A REGULAR REPAIR SHOP AND THEIR COMPUTERS CAN'T ANALYZE THE PROBLEM, IT HAS TO BE RETURNED TO A CHRYSLER DEALERSHIP. IS THIS A SAFETY HAZARD AND IS THERE A RECALL FOR THIS PROBLEM? *TR