2002 CHRYSLER TOWN AND COUNTRY Complaints

DEFECT # 1951- ENGINE FAMILIES-2CRXT0382D0. EMISSION PROBLEM- DUE TO AN OVER- TEMPERATURE WELD CONDITION THE CONTROL SYSTEM MAY SEPARATE FROM THE TANK ASSEMBLY. THIS COULD RESULT IN A POSSIBLE FUEL LEAK. CURRENTLY, ENGINE LIGHT IS ON.

OVER THE LAST FOUR YEARS I HAVE EXPERIENCED SEVERAL INSTANCES OF PARTIAL FRONT BRAKE APPLICATION WHEN NO DRIVER INPUT IS INITIATED. THIS RESULTS IN THE FEELING OF THE CAR DRAGGING. IT IS SUBTLE BUT IF THE CAR IS PUT INTO NEUTRAL THE CAR COMES TO A STOP EVEN WITH NO DRIVER BRAKE INPUT. IN SEVERAL INSTANCES THE FRONT BRAKES GET EXTREMELY HOT AND BEGIN TO SMOKE. THIS IS A SERIOUS FIRE HAZARD. AFTER ALLOWING THE BRAKES TO COOL FOR ABOUT AN HOUR THE BRAKES RETURN TO NORMAL AND DRIVING CAN RESUME. I HAVE TAKEN THE CAR SEVERAL TIMES TO THE CHRYSLER DEALER AND OTHER MECHANICS. THEY CAN FIND NOTHING WRONG. THERE DOES NOT SEEM TO BE ANY RECALLS OR ALERTS CONCERNING THIS PROBLEM. I WOULD ESTIMATE THAT THIS PROBLEM HAS OCCURRED ABOUT SEVEN OR EIGHT TIMES, THE MOST RECENT ONE ON JULY 8, 2017. WEATHER DOES NOT SEEM TO BE A FACTOR NOR DOES HIGHWAY OR LOCAL DRIVING.

SEVERE GASOLINE ODOR FROM UNDER THE WHOLE CAR. NOTICED THE GASOLINE LEAK FROM THE SIDE OF THE GASOLINE TANK WHERE THE WHITE PLASTIC CONNECTOR WAS WELDED TO A BLACK PLASTIC GAS TANK.. WE NOTICED THE GASOLINE ODOR WHILE WE ARE IN A HOUSE. GASOLINE WAS LEAKING FROM THE GASKET BETWEEN THE GAS TANK AND WHITE PLASTIC ATTACHMENT ASSEMBLY.

LOSS OF BRAK POWER, PEDAL TRAVELS TO FLOOR. ; AFTER REPLACING MASTER CYLINDER, CALIPER ON THE LEFT FRONT.. MUST RE-BLEED LEFT FRONT** ONLY . MUST PERFORME THIS PROCEDURE EVERY 2 WEEKS...AND THIS IS A FREQUENT OCCURENCE ON LEFT FRONT WHEEL.THE ONLY OPTION IS TO REPLACE THE ORIGINAL ABS HYDRAULIC UNIT? WHY WAS THIS NOT A RECALL, IT SEEMS LOT OF OWNERS OF 2002 HAVE HAD THIS PROBLEM..,IT'S ONLY THE LEFT FRONT WHEEL THAT HAS THIS PROBLEM, AFTER BLEEDING, THE BRAKES LAST ONLY FEW WEEKS AND SAME THING, BRAKE PEDAL IS SPONGY AND TRAVELS TO THE FLOOR. AND MUST RE-BLEED LEFT FRONT WHEEL. IT SEEMS THAT THERE IS A LOT OF VERY MINUTE BOUBLES. ## VIN PASSED ## CHRYSLER TRUCK 2002, TOWN & CONTRY,2002 3.3 L ##

STRONG SMELL OF GAS FILLING UP VEHICLE WHILE DRIVING. STRONG SMELL OF GAS ALSO OCCURS OUTSIDE OF VEHICLE FILLING UP PARKED ENCLOSURE WHEN VEHICLE WAS RUNNING. INSPECTION DETERMINED FUEL RAIL LEAK. REPAIRS INCLUDED REPLACEMENT RAIL AND FUEL INJECTOR O-RINGS. SIMILAR COMPLAINTS ON FILE.

REAR FUEL TANK RETENTION STRAP BROKE AND NOTICED FRONT STRAP HAS IMMINENT FAILURE DUE TO RUSTING. IF THE FRONT STRAP BROKE THE PLASTIC TANK WOULD DRAG ON THE GROUND CAUSING A HOLE IN THE FUEL TANK AND IGNITION OF FUEL TANK AND VEHICLE AND LOSS OF LIFE. ALL VEHICLES LIKE THIS NEED INSPECTION AND REPAIR AS SOON AS POSSIBLE.

TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING AT 35 MPH, THE LEFT TURN SIGNAL WAS ACTIVATED AND ALL THE LIGHTS, METERS, AND GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION. IN ADDITION, THE CONTACT STATED THAT THE DOORS FAILED TO AUTOMATICALLY LOCK. THE VEHICLE WAS TAKEN TO A DEALER. THE CONTACT WAS UNSURE ABOUT WHAT PART NEEDED TO BE REPLACED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

THE TOWN AND COUNTRY VAN THAT WE OWN CONTINUES TO HAVE MULTIPLE ISSUES WITH INTERMITTENT STALLING AND VARIOUS SPEEDS. THE VAN USUALLY HAS PROBLEMS MOST AFTER REFILLING WITH GASOLINE. THIS PROBLEM HAS BEEN HAPPENING FOR A FEW MONTHS AND CONTINUES DESPITE EFFORTS TO REMEDY THE PROBLEM. I FEEL THIS IS A SAFETY ISSUE THAT NEEDS TO BE ADDRESSED BY CHRYSLER AND THE NHTSA TO AVOID A MAJOR CASUALTY INCIDENT SINCE THESE VANS ARE HAVING DOCUMENTED PROBLEMS AT ALL SPEEDS INCLUDING HIGHWAY DRIVING AT 70 PLUS MPH. WE ARE NOT SURE IF THE PROBLEM EXISTS DUE TO ELECTRICAL ISSUES, FUEL PUMP ISSUES OR EVAP SYSTEM ISSUES DUE TO THE FACT THAT NO REPORTABLE CODES ARE BEING THROWN WHEN THE VEHICLE HAS THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE EMITTING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT UNDER CARRIAGE WAS RUSTED. THE TECHNICIAN STATED THAT THE VEHICLE COULD NOT BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000.

MY WIFE WAS TURNING INTO OUR DRIVEWAY AN COLLIDED WITH A SNOWMOBILE. THE DRIVER SIDE AIRBAG DEPLOYED. THERE WAS A PROBLEM WITH THE INFLATOR (SEALED OVER) AND THE AIRBAG EXPLODED PUTTING SHRAPNEL INTO HER BODY. BECAUSE OF THE LOCATION OF THE AIR BAG AND THE BODY MOST OF THE SHRAPNEL WENT INTO HER CHEST, WITH THE AIRBAG PLATE BREAKING APART STRIKING HER IN THE CHIN BREAKING HER JAW IN THREE PLACES. IF IT HADN'T BEEN FOR A GREAT AMBULANCE CREW SHE WOULD HAVE BLED TO DEATH. SHE WAS IN A TRAUMA HOSPITAL FOR 3 AND 1/2 MONTHS. SHE HAS PERMANENT MUSCLE AND NERVE DAMAGE, THE JAW IS NOT ALIGNED CORRECTLY SO HE HAS PROBLEMS EATING.