DAMON Complaints

AFTER GOING THROUGH STOP AND GO TRAFFIC IN HARRISBURG PA THE BRAKES GAVE OUT COMPLETELY WITH THE BRAKE PEDAL GOING TO THE FLOOR IN SLOW TRAFFIC. THERE WAS A TINY BIT OF BRAKING AND THE VEHICLE COASTED ON THE SHOULDER TO A STOP. LOTS OF SMOKE FROM THE BRAKES FRONT AND REAR. REPAIR WAS OVER $2200 TO CHANGE THE LEFT REAR BRAKE CALIBER THAT HAD HUNG UP. FRONT RIGHT BAKE OVER HEATED AS WELL MELTING THE SPEED SENSOR AND CABLE. WORKHORSE/INTERNATIONAL CLAIMS THAT THIS P32 CHASSIC IS NOT PART OF THE BRAKE RECALL EVEN THOUGH IT HAS DEFECTIVE BRAKE CALIBERS. 2001 DAMON DAYBREAK RV ONLY HAS 16K MILES. IT WOULD BE WISE TO ADVISE ALL WORKHORSE P32 CHASSIS RV OWNERS THAT THEIR RV COULD CATCH FIRE OR FAIL TO STOP AND BE INVOLVED IN AN ACCIDENT. I WOULD LIKE TO ENCOURAGE THE DOT TO FORCE WORKHORSE/INTERNATIONAL TO DO THE RIGHT THING AND RECALL THIS CHASSIS AND REPLACE THE BRAKE CALIPERS.

WINDSHIELD WIPERS FAILED IN THE MIDDLE OF THE GLASS DURING A RAINSTORM. VERY DANGEROUS. THE MOTOR IS RUNNING SO HAS POWER BUT THE LINK TO THE ARMS IS STALLED OUT WITH DRIVE ARM JAMMED AGAINST THE MOUNTING BOLT. 28" ARMS ARE TOO LONG SO HAVE BEEN REPLACED WITH 24" BLADES AS USED IN 2007. DEFECTIVE WINDSHIELD WIPER ASSEMBLY WITH LINKAGE. THIS IS THE SECOND ASSEMBLY TO FAIL WITHIN 3 YEARS ON THE SAME MOTORHOME.

ALTERNATER BECAME RED HOT AND STOPPED WORKING . NOW THERE IS NO REPLACEMENT FOR THIS ALTERNATER WHICH IS AN INTERNATIONAL PART THAT SHOULD COST ABOUT $300 BUT NO. INTERNATIONAL WANTS ME TO PAY , WITH PARTS AND LABOR JUST UNDER $2500 FOR THIS FIX . THIS NEEDS TO BE A WARRENTY OR RECALL . MY COACH WAS ON THE VERGE OF CATCHING FIRE. LUCKY FOR MY FAMILY AND I , I SMELLED SOMETHING WAS WRONG ! WE WERE IN MOTION !

THE DAMON MOTORHOME HAS A TWO PIECE WINDSHIELD THAT HAS AN INHERENT PROBLEM AS THE UNIT GET OLDER THE WINDSHIELD WILL UNEXPECTEDLY POP OUT OF THE RUBBER SEAL. IT SEEMS AS IF THE FLEXING OF THE FRONT CAP CAUSES THE WINDSHIELD TO POP OUT OF THE RUBBER SEAL AT THE TOP IN SOME CASES TO 1 INCH, 6-8 INCHES IN LENGTH. THIS CREATES A PROBLEM WHEN YOU'RE DRIVING ALONG THE ROAD AND IT POPS OUT. IT ALLOWS WATER TO COME IN AND MAKE YOU WONDER IF THE ENTIRE WINDSHIELD WILL FALL OUT OR WORSE BLOW IN ON THE DRIVER AND PASSENGER. THE MANUFACTURER, THOR WILL NOT HONOR THE PROBLEM AND BLOW IT OFF. IT IS UNDERSTOOD THAT THIS IS A PROBLEM ON ALL MODELS WITH TWO PIECE WINDSHIELDS.

SEE NHTSA RECALL11V-248 EXTERIOR LIGHTING, TAIL LIGHTS. THIS RECALL WAS FOR 2011 DAMON AVANTI ON FREIGHTLINER CHASSIS (DAIMLER TRUCKS); HOWEVER, 2011 DAMON AVANTI MOTORHOMES WERE ALSO BUILT ON WORKHORSE CHASSIS (NAVISTAR). MY MOTORHOME HAS BEEN HAVING THE SAME TAIL LIGHT PROBLEMS (FRIENDS TRAVELING BEHIND STATING MY BRAKE LIGHTS WERE NOT WORKING). WHILE TRAVELING IN CANADA LAST YEAR, AFTER I WAS TOLD THEY WERE NOT WORKING I CONTACTED THOR MOTOR COACH CUSTOMER SERVICE AND A REP TOLD ME TO TURN A NUT UNDER THE BRAKE PEDAL; I DID THIS AND BRAKE LIGHTS CAME ON BUT ALSO THE AMBER LIGHTS. THE BRAKE LIGHTS HAVE CONTINUED TO NOT WORK INTERMITTENTLY (AND I DON'T KNOW WHEN THEY ARE NOT WORKING). THOR MOTOR COACH CUSTOMER SERVICE TOLD ME THEY COULD NOT HELP.

WINDSHIELD POPPING OUT OF RUBBER GASKET WE BOUGHT THE 2004 DAMON MOTORHOME NEW AND HAVE HAD MANY PROBLEMS WITH WATER LEAKING AROUND THE WINDSHIELD RUBBER GASKET. IN THE LAST YEAR WE HAVE HAD THE WINDSHIELD POP OUT OF THE RUBBER GASKET CAUSING LARGE AMOUNTS OF WATER TO COME IN DURING RAIN STORMS. WE SEALED THE WINDSHIELD THE BEST WE COULD TO KEEP OUT THE RAIN BUT THE GLASS WAS COMING OUT FURTHER AND FURTHER. WE TOOK IT TO A DEALER AND THEY REMOVED THE WINDSHIELDS AND CLEANED THE RUBBER GASKET. AFTER A COUPLE OF DAYS USE THE WINDSHIELD POPPED OUT AGAIN ON THE TOP. THE DEALER THEN DECIDED THE COACH NEEDED A NEW RUBBER GASKET. THE DEALER THEN WENT REPLACED THE GASKET AND RE-INSTALLED THE WINDSHIELDS. AFTER A WEEK OF USE THE TOP OF THE GLASS WAS POPPED OUT OF THE NEW RUBBER GASKET. THE DEALER DOES NOT KNOW WHAT TO DO KNOW. THE DAMON COMPANY NOW THOR MOTOR COACH, PO BOX 1486 ELKHART, INDIANA 46515 SHOULD BE MAKING A RECALL TO FIX THIS PROBLEM. IT IS HAPPENING ON MANY OF THE OLDER DAMON MODELS FROM 2002 - 2009

TL* THE CONTACT OWNS A 2007 DAMON DAYBREAK EQUIPPED WITH GOODYEAR TIRES UNISTEEL TIRES, SIZE: 245/70/R19.5 (NA). WHILE DRIVING AT APPROXIMATELY 65 MPH, THE REAR OF THE VEHICLE VIBRATED AND THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED. AFTER THE VEHICLE WAS PARKED, THE FRONT DRIVER SIDE TIRE BLEW OUT WITHOUT WARNING. THE CONTACT OBSERVED THAT THE BLOW OUT WAS ON THE INNER WALL OF THE TIRE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE TIRE WAS NOT REPLACED. THE DOT NUMBER WAS UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 14,107.

THIS YEAR ON OUR ANNUAL FAMILY VACATION WE HAD 2 TIRE FAILURES, ONE OCCURRED TRAVELING DOWN THE HIGHWAY AND WAS THE INNER REAR TIRE DRIVERS SIDE OF THE REAR DUAL WHEELS. THE OTHER FAILURE OCCURRED AFTER THE RV HAD BEEN PARKED FOR 20 MINUTES IN MY DRIVEWAY. THE TIRE EXPLODED AFTER THE RV HAD BEEN PARKED FOR OVER 20 MINUTES. UPON INSPECTION OF THE TIRE FAILURE IT WAS A INNER SIDEWALL (ENGINE FACING) BLOWOUT AT THE 11:00 O'CLOCK POSITION. I HAVE CONTACTED GOODYEAR ABOUT THE FAILURE AND THEY HAVE REFERRED ME TO A SERVICE CENTER FOR THE TIRE TO BE INSPECTED. THE TIRE SIZE IS 245/70R/19.5 THIS FAILURE IS IN ITS NATIVE STATE SINCE THE EXPLOSION. IT WOULD BE IN THE NATIONAL HIGHWAY TRANSPORTATION SAFETY ADMINISTRATION INTEREST TO HAVE THIS PARTICULAR ASSET IN TACT.

THE LCD WHICH DISPLAYS CRITICAL ENGINE INFORMATION HAS BAD PIXELS, WHICH MAKES IT DIFFICULT, IF NOT IMPOSSIBLE TO ASSESS OPERATING CONDITIONS. I UNDERSTAND THAT THIS IS A VERY COMMON FAULT WITH THE ACTIA DISPLAY USED IN THE WORKHORSE CHASSIS. *TR

AUTO PARKING BRAKES APPLIES WHILE DRIVING DOWN ROAD. THIS HAS HAPPENED TO US THREE TIMES. *TR