2008 DODGE CALIBER Complaints

2008 DODGE CALIBER SUB FRAME/K-FRAME FRONT END CROSSMEMBER COMPLETELY RUSTED THRU CAUSING THE DRIVER SIDE LOWER CONTROL ARM TO RIP FREE FROM FRAME (SEPERATING PART OF FRAME, WITH LOWER CONTROL ARM) FROM REST OF FRAME. THIS LEFT DRIVER WITH NO CONTROL OF AFFECTED WHEEL WHICH TURNING IT 90 DEGREES OUT FROM NORMAL OPERATING POSITION. LEFT OPERATOR WITH NO ABILITY TO STEER WHILE DRIVING ON MAIN PRIMARY (35 MPH SPEED LIMIT) TWO LANE ROAD. CAR SLID TO HALT IN MIDDLE OF ROAD. CAR NEEDED TO BE TOWED. DODGE/CHRYSLER APPARENTLY KNEW OF THIS PROBLEM AND NEVER NOTIFIED OWNER. PLEASE SEE ATTACHED NOTICE. FRONT AND REAR CROSSMEMBER CORROSION (X69 WARRANTY EXTENSION) - 2008-2012 DODGE CALIBER & JEEP COMPASS/PATRIOT OEMDTC JULY 17, 2017 15 COMMENTS NHTSA ID NUMBER: 10140027 MANUFACTURER COMMUNICATION NUMBER: 23-007-17 REV. B SUMMARY FRONT AND REAR CROSSMEMBER CORROSION (X69 WARRANTY EXTENSION) THE DRIVER OF THIS CAR COULD HAVE BEEN KILLED OR SERIOUSLY HURT. IT IS UNFATHOMABLE THAT DODGE CHRYSLER WAS ALLOWED TO GET AWAY WITH NOT NOTIFYING POTENTIAL CRASH VICTIMS

THE FRONT CALIPERS WILL NOT ENGAGE WHEN BRAKE PEDAL IS PRESSED. THE BRAKE PEDAL SINKS TO THE FLOOR AND HAS NO STOPPING POWER. THE MASTER CYLINDER WAS REPLACED AND CALIPERS ARE NEW REPLACEMENTS. AFTER REPLACING THESE PARTS IT NOW SMELL OF BURNT BRAKE FLUID BUT THERE IS NO LEAK AND THE PROBLEM SEEMS TO WORSEN. THE FIRST TIME I WAS DOING 45-50 ON A COUNTY RD WHEN A ANOTHER CAR PULLED OUT 20 FEET AWAY AND I WAS TRYING TO SLOW DOWN WHEN I LOST THE FRONT BRAKES AS PISHED IN ON THE PUSHED IN ON THE BRAKES THE PEDAL SANK AND THEY DIDN'T ENGAGE. I THEN BOUGHT THE NEW CALIPERS AND IT WAS FINE FOR ABOUT A MONTH. THE SECOND TIME I WAS STUCK IN TRAFFIC ON A BUSY CITY STREET WHEN THE ABS BRAKES FAILED RESULTING IN ME RUNNING A RED LIGHT AND ALMOST GETTING HIT. IT HAS CORRODED AND TOOK HUNKS OFF ALUMINUM FROM MY FRONT DRIVER RIM. I HAVE NOT BEEN ABLE TO FIGURE OUT WHAT THE PROBLEM AND KEEP REPLACING PARTS FOR IT TO TEAR UP NEW ONES

TOOK VEHICLE IN FOR MAINTENANCE, TECHNICIAN TOLD US THE FRONT CROSSMEMBER IS RUSTED THROUGHOUT AND NEEDS REPLACEMENT. TECHNICIAN ADVISED IT'S A SAFETY ISSUE AND THIS MODEL WAS GIVEN EXTENDED WARRANTY UNDER X69 NOTICE, HOWEVER WARRANTY MAY HAVE ALREADY EXPIRED. I CONTACTED CHRYSLER REPRESENTATIVE AND THEY ADVISED THE VEHICLE WAS PART OF THE X69 NOTICE BUT WAS BEYOND THE EXTENDED WARRANTY THAT EXPIRED IN JUNE 2018. I AM THE SECOND OWNER OF VEHICLE BAND NEVER RECEIVED NOTICE OF THE ISSUE FROM CHRYSLER/DODGE. THE CROSSMEMBER RUST ISSUE APPEARS TO BE A COMMON PROBLEM WITH THIS MODEL. I AM REQUESTING AN INVESTIGATION AND RECALL FOR THIS PART.

AFTER REACHING 100K MILES, I TOOK THE CAR TO THE DEALERSHIP TO HAVE THE TRANSMISSION FLUSHED. SINCE THEN MY TRANSMISSION OVER HEATS WHEN I DRIVE 65 OR MORE MPH. I BROUGHT IT BACK TO THE SAME DEALER ABOUT A YEAR LATER AND THEY WANTED TO CHARGE ME $1500. I WALKED OUT! I DRIVE 64 MPH TO KEEP IT FROM OVER HEATING.

I HAVE HAD MY 2008 DODGE CALIBER SINCE 2009. SINCE THEN I HAVE REPLACED BOTH TIE RODS 4 TIMES. I JUST HAD THEM DONE AGAIN ABOUT 1 1/2 YEARS AGO AND THEY ARE BROKEN AGAIN. I HAVE CHANGED THE BALL JOINTS AS WELL.. THIS IS RIDICULOUS AND SHOULD HAVE BEEN RECALLED I READ A LOT OF FORUMS AND EVERYBODY COMPLAINS ABOUT THE SAME THING.

RECENTLY PURCHASED A 2008 DODGE CALIBER(OHIO). ON INITIAL DRIVE RETURNING WITH VEHICLE I NOTICED A VIBRATION COMING THROUGH STEERING WHEEL. UPON INSPECTION, WAS INFORMED THE TIE ROD ENDS AND CONTROL ARMS BOTH COULD USE REPLACEMENT, BUT COULD HAVE BEEN CAUSED BY THE MORE IMPORTANT BAD FRONT AND REAR CROSSMEMBERS AS WELL AS FRONT AND REAR CRASH BARS, BOTH HAVE SEVERE RUST DEVELOPMENT WITH METAL DETERIORATION WHICH COULD IMPOSE A SAFETY CONCERN DOWN THE ROAD. WAS ADVISE TO LOOK INTO REPLACEMENT. REACHED OUT TO ONE OF THE LOCAL DEALERSHIPS AND WAS INFORMED IT WAS A BULLETIN, HAD AN EXTENDED WARRANTY, BUT AM OUTSIDE OF 10 YEAR PERIOD. RUST FROM CROSSMEMBER IS NOW IN PROCESS OF TRANSFERRING TO ACTUAL FRAME AND COMING THROUGH AS HOLES IN ROCKERS NOW AS WELL. DEALERSHIP OFFERING NO HELP AFTER STATING THE ENHANCED SAFETY CONCERN. HARD TO BELIEVE AN 08 CAN DETERIORATE SO FAST. YOU WOULD THINK WITH THE COMPLAINTS AND T.S.B. AS WELL AS SAFETY CONCERNS, SEEING STILL ORIGINAL PARTS THAT HAVE BEEN WARRANTIED TO REPLACE BUT HAVE NOT ON THIS VIN, GETS NO HELP AT ALL. *TR

WHILE DRIVING MY CAR SPEED LOWERED AND THE TRANS TEMP LIGHT AND ESP LIGHT AND TRACTION CONTROL AND ETB MODULE LIGHT CAME CAR WON'T GO OVER 40 AND REMAINS IN LIMP MODE EVEN AFTER TAKING IT TO THE SHOP

WHILE MY WIFE WAS DRIVING, THE FRONT SUBFRAME CROSSMEMBER RUSTED THROUGH, CAUSING HER TO LOSE CONTROL OF THE CAR AND SHE COULD NOT SAFELY OPERATE IT WITHOUT REPAIR. I MANAGED TO GET IT TO A FIRESTONE FOR THEM TO LOOK AT AND THEY REFERRED ME TO A DEALER AND TOLD ME NOT TO DRIVE IT ANYMORE BECAUSE IT IS UNSAFE. THIS IS A PROBLEM THAT DODGE KNEW ABOUT, BUT FAILED TO NOTIFY ME ABOUT. I ONLY FOUND OUT ABOUT THE PROBLEM FROM THE DEALERSHIP, WHO TOLD ME THAT THE EXTENDED WARRANTY THAT COVERS THIS PROBLEM HAD EXPIRED IN 2018 AND THAT I WOULD BE RESPONSIBLE FOR THE COST OF ANY REPAIRS. I OWNED THE CAR DURING THAT TIME AND I DID NOT KNOW OF THIS PROBLEM, SO I COULD NOT ACT ON GETTING IT REPAIRED. THIS NEVER SHOULD HAVE BEEN AN EXTENDED WARRANTY, THIS SHOULD HAVE BEEN A RECALL BECAUSE OF THE POTENTIAL TO KILL PEOPLE WHEN THE SUBFRAME RUSTS OUT. MY WIFE WAS DRIVING IN A PARKING LOT AT THE TIME AT A RELATIVELY LOW SPEED, BUT HAD THIS HAPPENED ON A HIGHWAY IT COULD HAVE KILLED HER AND MY SON, AS WELL AS OTHERS ON THE ROAD. NUMBER: 23-007-17 REV. B GROUP: BODY DATE: MARCH 10, 2017 *TR

LUCKILY, I WAS ON A CITY STREET. THE VEHICLE LOST POWER AND SLOWED SIGNIFICANTLY, ALMOST STOPPING COMPLETELY AND BEGAN TO REBOOT AS IF IT WERE JUST BEING STARTED. I AM COMPLAINING BECAUSE I DO NOT FEEL IT TO BE SAFE FOR CONSUMERS ON ANY ROAD. I HAVE A 3 YEAR OLD SON AND I WOULD VERY MUCH LIKE DODGE TO FIX THIS PROBLEM BEFORE MY, OR ANYONE ELSE'S FAMILY, GETS WHIPLASH FROM A REAR COLLISION. I'M REACHING OUT TO NHTSA BECAUSE, I LACK THE TOOLS AND KNOWLEDGE TO FIX IT MYSELF, AND DON'T FIND IT FAIR THAT I PAY FOR A MISTAKE THAT DODGE MADE IN MAKING THE CAR. *TR

I PREVIOUSLY CALLED REGARDING ODI 11282835. THE FRONT AND REAR CROSS-MEMBERS WERE COMPLETELY RUSTED AWAY. THERE WAS AN EXTENDED WARRANTY AND THE ORIGINAL OWNER NEVER REPAIRED THE ISSUE THE WARRANTY EXPIRED 04/2018. CHRYSLER REFUSES TO FIX THE ISSUE. I PURCHASED THE VEHICLE 09/2019 AND DISCOVERED THE ENTIRE SUSPENSION HAD ROTTED OUT. THIS IS EXTREMELY DANGEROUS. IT IS PURSUANT TO THIS BULLETIN. CHRYSLER IS REFUSING TO REPAIR IT. SERVICE BULLETIN NUMBER: 23-012-14 GROUP: BODY DATE: MAY 19, 2014 THIS BULLETIN IS SUPPLIED AS TECHNICAL INFORMATION ONLY AND IS NOT AN AUTHORIZATION FOR REPAIR. NOTE: THIS ONLY APPLIES TO VEHICLES IN THE CANADIAN MARKET AND IN SALT BELT STATES WHICH INCLUDE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON, D.C., WEST VIRGINIA AND WISCONSIN. SUBJECT: FRONT AND REAR CROSSMEMBER CORROSION (X58 10 YEARS UNLIMITED MILEAGE) OVERVIEW: THIS BULLETIN INVOLVES INSPECTING THE FRONT AND REAR CROSSMEMBERS FOR PERFORATION / RUST THROUGH AND IF NECESSARY, REPLACE THE CROSSMEMBER(S). MODELS: 2007 PM CALIBER 2007 MK COMPASS, PATRIOT NOTE: THIS BULLETIN APPLIES TO VEHICLES BUILT ON OR AFTER AUGUST 26, 2005 (MDH 0826XX) AND ON OR BEFORE JULY 23, 2007 (MDH 0723XX). SYMPTOM/CONDITION: THE CUSTOMER MAY DESCRIBE A VIBRATION AT THE STEERING WHEEL OR MAY HAVE BEEN INFORMED BY A TECHNICIAN OR STATE VEHICLE INSPECTION THAT THE FRONT AND / OR REAR CROSS-MEMBER IS SEVERELY CORRODED. POLICY: WARRANTY PERIOD FOR CROSS-MEMBER PERFORATION / RUST THROUGH IS EXTENDED TO 10 YEARS. REIMBURSABLE WITHIN THE PROVISIONS OF THE WARRANTY.