1998 DODGE RAM 2500 Complaints

THE THROTTLE LINKAGE IS A RECALL. I TOOK IT TO DOUGLAS CHRYSTLER JEEP DODGE RAM DEALER IN VENICE, FL AND THEY SAID THEY COULDN'T HELP ME BECAUSE THE RECALL HAD ALREADY BEEN PERFORMED ONCE. SEEING THAT IT IS A SAFETY RECALL I WAS UNDER THE IMPRESSION THAT THEY WOULD TAKE CARE OF IT BUT WHEN I CALLED THEY SAID THEY CAN ONLY REPLACE A RECALL ITEM ONCE. VEHICLE LUNGES FORWARD WHEN I AM AT A STOP LIGHT AND IDLES HIGH.

HAZZARD: INTERMITTENT HEAD LAMP OPERATION (LOW AND/OR HIGH BEAM CUT-OFF) CAUSE: UNKNOWN. SAFETY ISSUE: KEEPING THE HEADLAMPS ON WHILE DRIVING (DODGE RAM 1998.5 2500 4X4 QUAD CAB SLT; 5.9L 24V CUMMINS DIESEL; 47RE; STOCK (NO FOG LIGHTS); 170,000 MILES). PROBLEM: HEADLAMPS (LOW AND/OR HIGH BEAM), AND OCCASIONALLY, BUT NOT CONSISTENTLY THE DASHBOARD LIGHTS, CUT-OFF INTERMITTENTLY -- ACTUATING THE DASHBOARD MOUNTED HEADLAMP SWITCH (PUSH-PULL) RESTORES THE LIGHTS. TROUBLE SHOOTING/REPAIRS (EXECUTED BY A CERTIFIED AUTOMOTIVE REPAIR FACILITY): (1) CHECKED MULTIPLE GROUNDS (CLEAN AND TIGHT); (2) CHECKED FUSES; (3) CHECKED OUTPUT FROM GENERATOR (STEADY - APPROX. 14.5 WITH "NO LOAD"; BATTERIES - NEW 6/18); (4) CHECKED CIRCUITS (VERIFIED CONTINUITY AND RESISTANCE); (5) REPLACED STEERING COLUMN MOUNTED MULTIFUNCTION SWITCH; (6) REPLACED "HEADLAMP/SECURITY" RELAY; (7) REPLACED HEADLAMP/DASHBOARD LIGHTING COMBINATION SWITCH (REPLACED 22 MONTHS AGO (167,000) - ORIGINAL FAILED. NOTE: DASHBOARD ABOVE SWITCH - WARM TO TOUCH. (8) REPLACED HEADLAMP BULBS (BOTH). NOTE: NO DIAGNOSTIC TROUBLE CODES SET. NEXT ACTION: REPLACING THE HEADLAMP/DASHBOARD COMBINATION SWITCH AGAIN. OEM REPLACEMENT SWITCH INSTALLED AT APPROXIMATELY 167,000 MILES MAY BE MALFUNCTIONING. A VISUAL INSPECTION OF THE SWITCH DID NOT INDICATE SIGNS OF OVERHEATING. ACTUATING THE SWITCH INDICATES NORMAL OPERATION. SPECULATION: A "CCD BUS COMMUNICATION ERROR" IS OCCURRING; PULSE FROM PCM (?) TO HEADLAMP CIRCUIT MAY NOT YIELD THE LEVEL OF RESISTANCE REQUIRED RESULTING IN THE INTERMITTENT "CUT-OFF". TECHNICAL ADVICE/GUIDANCE/ASSISTANCE EITHER DIRECTLY FROM THE MANUFACTURER (FIAT CHRYSLER AUTOMOTIVE), OR THROUGH THE DODGE RAM DEALERSHIP NETWORK IS REQUIRED TO CORRECT THIS HAZARDOUS CONDITION.

TL* THE CONTACT OWNS A 1998 DODGE RAM 2500. THE CONTACT STATED THAT THE ENTIRE DASHBOARD CRACKED AND PIECES WERE FALLING OFF. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

TL* THE CONTACT OWNS A 1998 DODGE RAM 2500. THE CONTACT STATED THAT THE FRONT PASSENGER AND DRIVER SEAT BELTS WOULD NOT RELEASE OUT OF THE BUCKLES AND THE SEAT BELT WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED PERIODICALLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

TL* THE CONTACT OWNS A 1998 DODGE RAM 2500 EQUIPPED WITH FOUR MASTERCRAFT COURSER AXT (NA) TIRES, SIZE: 285/75/R16/ (NA). THE TIRES WERE PURCHASED IN JANUARY OF 2018. WHILE DRIVING APPROXIMATELY 65 MPH AND PULLING A TRAILER, THE FRONT PASSENGER TIRE SUDDENLY BLEW OUT. DURING THE INCIDENT, THE FRONT PASSENGER RIM WAS DESTROYED. THE CONTACT INDICATED THAT THE EXACT TIRE PRESSURE WAS CHECKED BEFORE STARTING THE TRIP. THE MANUFACTURER AND LOCAL DEALER (ELLISTON REPAIR AND TIRE IN FREDRICKTOWN, OHIO WERE NOTIFIED. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN. THE TIRE FAILURE MILEAGE WAS 100.

VEHICLE PARKED IN DRIVEWAY. UPON GETTING IN VEHICLE, I FOUND BOTH THE DRIVER'S SIDE AND PASSENGER SIDE SEAT BELTS LOCKED IN THE RETRACTED POSITION. I STOPPED AT A LOCAL DEALERSHIP FOR PART #P56043003AD AND WAS INFORMED THIS PART ON NATIONAL BACK ORDER. THIS SEAT BELT TIMER CONTROL MODULE IS NECESSARY FOR THE SEAT BELTS TO FUNCTION AS DESIGNED. TRUCK CAN ONLY BE DRIVEN WITHOUT SEAT BELTS IN USE.

I WAS PULLING A CAR FROM INDIO CA TO PHX. AZ WHEN IT STARTED TICKING AND SMOKEING AND LOST POWER I PULLEDOVER CHECKED THE OIL AND IT WAS 2 QUARTS LOW IT HAD NEVER USED OIL BEFORE THIS IT NEVER GOT HOT THOUGH I SLOWED WAY DOWN AND BARELY MADE IT HOME.

BRAKE LINE RUSTED OUT AND FAILED CAUSING LOOSE OF BRAKE IN TRAFFIC. ONCE FUEL TANK WAS REMOVED THIS EXPOSED THE PROBLEM AREA. REAR WIRING HARNESS RUNS DIRECTLY AGAINST THE FUEL LINE TRAPPING ROAD GRIM, WATER, SALT, CAUSING CORROSION AT THIS POINT.

THE UPPER INTERIOR DASH PANEL CRACKING INTO MANY PIECE. DURING ACCIDENT THE PANEL WILL COME A FLYING MISSILE OF PARTS HITTING OCCUPANCIES IN THE COMPARTMENTS AND SMALL CHILDREN. I WAND THE CHRYSLER CORPORATION TO REPAIR IT ASAP. ITS ACCIDENT WAITING TO HAPPENED.

THE PASSENGER SIDE LOWER REAR ARM SUPPORT BRACKET WELD ARE CRACKING TWISTING TEARING FROM MAIN FRAME RAIL. THE FRAME WELD IS TEARING HORIZONTALLY AND ACROSS SAME RATES. THE CRACK ARE NEXT TO WELDS AN SOME LOCATION TEARING CIRCLING ROTATING. THE VEHICLE NEVER OPERATED OFF-ROAD AND MILEAGE IS 171,550 MILES. THE CRACK ARE 65% AND VEHICLE UNFIT TO BE OPERATED SAFETY. I WAS VERY FORTUNATE I DIDN'T HAVE A ACCIDENT. THE VEHICLE WOULD HAVE ROW OVER ON I LEFT SIDE WITHOUT NO WARNING . I WAS PREFORMING VEHICLE BRAKE INSPECTIONS AND I NOTICE RUST ON THE LOWER REAR SUPPORT HANGER WHICH HOLD THE LOWER ARM BRACKET AND COIL SPRING. I AM VERY FORTUNATE THAT I DIDN'T LOAN MY VEHICLE TO MY RELATIVES. I HAVE PICTURES AVAILABLE. I WANT THE CHRYSLER CORPORATION TO REPAIR THIS ASAP!!!