2004 DODGE SPRINTER Complaints

TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT DISCOVERED OIL ON HIS DRIVEWAY. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THERE WAS A LEAKING PLUG ON THE TRANSMISSION THAT RELEASED THE OIL ONTO THE DRIVEWAY. THE CURRENT MILEAGE WAS 17,000 AND FAILURE MILEAGE WAS 15,000.

TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT DISCOVERED OIL ON HIS DRIVEWAY. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THERE WAS A LEAKING PLUG ON THE TRANSMISSION THAT RELEASED THE OIL ONTO THE DRIVEWAY. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 35,000.

WHILE TRAVELING ON I-70 FROM FREDERICK TO CUMBERLAND IN 2004 DODGE SPRINTER PLEASURE-WAY RV, NOTICED A REVVING IN THE ENGINE. GOING UP FIRST STEEP MOUNTAIN, THE ENGINE DROPPED 10 MPH FROM 65 TO 55. DROVE THROUGH HAGERSTOWN AND GOT ON I-68 TO CUMBERLAND. GOING UP THAT MOUNTAIN, THE RV LOST POWER IN EVERY GEAR AND WENT INTO "LIMP HOME" MODE. PULLED OFF THE HIGHWAY AND CALLED TOW TRUCK. TOOK TO SPRINTER REPAIR SHOP WHO KNEW EXACTLY WHAT THE PROBLEM WAS - TURBO RESONATOR. TOOK APPROXIMATELY .7 OF AN HOUR TO REPLACE WITH A NEW PART. THIS SHOULD BE A RECALL. IN RESEARCHING THE ISSUE - THIS HAS HAPPENED TO MANY PEOPLE. IT IS NOT SAFE TO BE CLIMBING MOUNTAINS WITH TRACTOR TRAILER AND VEHICLE TRAFFIC AND HAVE THIS HAPPEN. *TR

THERE IS CURRENTLY A COMPLAINT FOR THE 2500 DODGE SPRINTERS, FOR VALVE STEM FAILURE. WHAT ABOUT THE 3500? I'VE HAD THREE VALVE STEM FAILURES SO FAR AND NO RECOURSE. WHY IS THE 2500 DIFFERENT THAN THE 3,500? TWO HAPPENED ON THE HIGHWAY AND ONE JUST LET GO WHILE PARKED. LUCKILY TWO WERE ON THE REAR DUALS AND I HAD THE OTHER TIRE TO BEAR THE WEIGHT. *TR

ENGINE STALLS INTERMITTENTLY, WITH OR WITHOUT A/C. CAN HAPPEN AT ANY TIME AFTER START UP AND AT ANY SPEED WITHOUT WARNING. SOMETIMES CAN HAPPEN AFTER VEHICLE GOES OVER A BUMP (EVEN SMALL ONES), DURING TURNS, MOVING OFF FROM A TRAFFIC LIGHT. THIS IS HIGHLY DANGEROUS. DEALER DID INSTALL KIT TO PREVENT POTENTIAL STALLING DUE TO OPERATION OF HEAVY DUTY REAR A/C DURING TURNS (KNOWN PROBLEM) BUT NO EFFECT. ENGINE RESTARTS WITHOUT HESITATION AFTER IGNITION KEY IS SWITCHED OFF AND THEN TURNED ON. DEALER HAS CARRIED OUT AN EXTENSIVE ELECTRICAL CHECK WITH NO RESULTS AND CANNOT DUPLICATE EVENT. *TR

TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WHILE DRIVING 65 MPH, THE VEHICLE SPEED DECREASED DRAMATICALLY. THE ENGINE WARNING LIGHT ILLUMINATED AFTER THE VEHICLE DECREASED IN SPEED. HE TOOK THE VEHICLE TO THE DEALER ON NINE OCCASIONS AND THEY REPLACED THE ERG VALVE, TURBO MANIFOLD, AND THE TURBO RESONATOR. THE CONTACT STATED THAT IMMEDIATELY AFTER THE REPAIRS WERE MADE HE EXPERIENCED A SIMILAR FAILURE. THE FAILURE MILEAGE AS 51,000 AND CURRENT MILEAGE WAS 78,000.

RACK AND PINION WAS REPLACED AFTER LEAKAGE OCCURED AT 27000 MILES. IT IS LEAKING AGAIN BUT NOT COVERED UNDER DRIVE TRAIN WARRENTY AND DODGE REFUSES TO REPLACE IT. HOWEVER IF THIS IS A REOCCURING PROBLEM YOU SHOULD INSIST THAT DODGE MODIFY THE DESIGN AND EFFECT A RECALL.

FAN PULLEY DISLODGES AND TEARS UP THE FRONT ACCESSORIES. DURING EXTENSIVE TRAVELS I HAVE FOUND DOZENS OF SPRINTERS HAVING HAD THE SAME PROBLEM. I THINK THAT THE DESIGN OR MATERIALS THAT MAKE UP THE PULLEY ARE FLAWED AND YOU SHOULD INVESTIGATE. I FURTHER BELIEVE THE DESCREPENCY BASED ON CONVERSATIONS WITH MECHANICS IS WELL KNOW TO DODGE YET IS ALSO COVERED UP BY DODGE.

TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WHILE DRIVING 65 MPH WITH CRUISE CONTROL ACTIVATED, THE VEHICLE SHUT DOWN WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER AND IT WAS TOWED TO THE DEALER. THE VEHICLE IS BEING DIAGNOSED BY THE DEALER AT THIS TIME. THE CURRENT AND FAILURE MILEAGE WERE 72,000.*AK

WHILE PARKED IN MY DRIVEWAY MY 04 3500 DODGE SPRINTER RIGHT REAR OUTSIDE TIRE SUDDENLY DEFLATED. THE VALVE STEM CORE HAD SEPARATED FROM THE RUBBER, CAUSING THE TIRE TO SUDDENLY DEFLATE. DODGE CLAIMS MY TRUCK IS NOT COVERED UNDER THE VALVE STEM RECALL. THIS IS THE 3RD. VALVE STEM TO FAIL. *AK