FLEETWOOD Complaints

WHILE TRAVELING ON RT 70 EAST AT APROX, 60 MPH I HEAR A CLUNK FROM UNDER THR VEHICHLE. I PULLED OVER AND WAS ABLE TO GET UNDER THE VEHICHLE AND FOUND ONE BOLT MISSING FROM THE DRIVERS SIDE "U " BRACKET HOLDING THE STABILIZER BAR TO THE FRAME AND THE OTHER BOLT ONLY HAND TIGHT. WHEN I CHECKED THE PASSENGER " U " BRACKET BOTH BOLTS WERE ONLY HAND TIGHT. *TR

I WAS INFORMED OF 2 SAFETY RECALLS FOR THIS VEHICLE, TUTHILL, AND SPARTAN CHASSIS WON'T MAKE THE NECESSARY REPAIRS, CITING THE AGE OF THE VEHICLE, I WASN'T AWARE OF THE RECALLS UNTIL THIS YEAR, AND NOW AM WORRIED ABOUT THE SAFETY OF THE VEHICLE, AND CAN'T AFFORD TO HAVE THE REPAIRS DONE. *TR

POWER LIFT ROOF SYSTEM FAILURE DUE TO RECALL # 07V-464 HOW DO I GET THIS FIXED AND WHO IS TAKING CARE OF THIS RECALL *TR

POWER ROOF LIFT SYSTEM BROKE ROOF FELL DUE TO RECALL #07V- 464 . NHTSA ODI # 10237683 I NEED TO KNOW WHO IS TAKING CARE OF THIS RECALL AND HOW I CAN GET MY TRAILER FIXED AND BE SAFE TO USE. *TR

AFTER OWNING MY FLEETWOOD RV FOR ONLY 4 YEARS, AND KEEPING IT HOUSED INDOORS, ALL OF THE DOUBLE-PAINED WINDOWS HAVE FAILED AND FOGGED OVER. IT IS NEAR IMPOSSIBLE TO GET A CLEAR LOOK THRU THE SIDE REAR VIEW MIRRORS BECAUSE OF THE DETERIORATION OF THE WINDOWS. THIS CREATES A VERY DIFFICULT SITUATION WHILE DRIVING AND WILL LEAD TO NEEDLESS ACCIDENTS. I HAVE COMPLAINED TO FLEETWOOD BUT TO NO AVAIL. IT WILL COST THOUSANDS OF DOLLARS TO HAVE THE FAULTY WINDOWS REPAIRED. A QUICK SEARCH OF THE INTERNET INDICATES THAT THIS ENDEMIC OF FLEETWOOD RV'S PRODUCED FROM 2000-2010. IT SHOULD BE THE RESPONSIBILITY OF FLEETWOOD TO CORRECT THIS ISSUE BUT THEY REFUSE. PLEASE LOOK INTO SIMILAR COMPLAINTS MADE BY THE MANY RV OWNERS WHO HAVE COMPLAINED ON THE INTERNET AND HAVE SPECIFIED THAT THEY WERE FILING COMPLAINTS WITH NHTSA. THANK YOU *TR

WHILE DRIVING ON INTERSTATE THE MMDC (MULTIPLE MODULE DATA COMPUTER) WENT HEY-WIRE. ALL GAUGES TURNED OFF. NO SPEEDOMETER, FUEL GAUGE, TEMP, OIL ETC... ALSO THE RV "JAKE" BREAK (ENGINE BREAK) FAILED TO ENGAGE. SEARCH OF THE INTERNET INDICATES THAT THIS HAS BEEN AN ON-GOING ISSUE WITH FREIGHTLINER'S MMDC THUS PUTTING MANY LARGE TRUCKS ON THE ROADS, AND THE PEOPLE AROUND THEM, IN DANGER. THE UNIT IS MADE BY MEDALLION INSTRUMENTATION SYSTEMS. PLEASE LOOK INTO THE NUMBER OF MMDC FAILURES (AFTER MARKET SALES) TO SEE IF IT WARRANTS A RECALL. I HAVE A FLEETWOOD RV BUT APPARENTLY THESE THINGS ARE IN A LOT OF RV'S AND POSSIBLY BIG RIGS ALL OVER THE COUNTRY. *TR

FUEL INJECTION PUMP FAILURE DUE TO INADEQUATE FUEL DELIVERY. THIS PUMP IS A BOSCH VP44 PUMP AND ACCORDING TO THE CUMMINS BLOG WEBSITES AND THE FACTORY AUTHORIZED DEALER, THIS PART HAS A 100% FAILURE RATE. WHEN THE PUMP FAILS THE ENGINE SHUTS OFF AND DOESN'T RESTART. MY VEHICLE IS A 25000 POUND MOTOR HOME, AND WHEN IT DIES OUT AT FREEWAY SPEEDS CAN BE VERY DANGEROUS. BOSCH AND CUMMINS KNOW ABOUT THE PROBLEM, BUT ARE UNWILLING TO ASSIST THE CUSTOMER IN ANY WAY EVEN THOUGH THEY ADMIT THAT IT IS A DESIGN FAULT. IN THEIR WORDS "WE ADMIT THAT IT WASN'T OUR BEST DESIGN". ACCORDING TO THE BLOGS THIS IS THE ISSUE: THE MOST COMMON MECHANICAL FAILURE OF THE VP44 PUMP IS RUPTURING OF THE DIAPHRAGM IN THE FRONT OF THE INJECTION PUMP. THE DIAPHRAGM RUPTURES ALLOWING THE TIMING PISTON TO VIBRATE AND DAMAGE THE FRONT COVER UNTIL FUEL BYPASSES. THIS WILL CAUSE THE DREADED CHECK ENGINE TROUBLE CODE P0216. WHEN THIS OCCURS YOUR BOSCH VP44 INJECTION PUMP MUST BE REPLACED. THE RUPTURING OF THE DIAPHRAGM IS CAUSED BY A POORLY DESIGNED LIFT PUMP. WHEN THE LIFT PUMP DOES NOT SUPPLY THE INJECTION PUMP WITH THE CORRECT AMOUNT OF FUEL PRESSURE (A MINIMUM OF 5PSI UNDER LOAD AT WIDE OPEN THROTTLE) THE DIAPHRAGM THEN DOESN'T HAVE ENOUGH POSITIVE PRESSURE AND RUPTURES. DODGE HAS RECOGNIZED THIS PROBLEM AS THEY WILL NO LONGER EVEN SELL THE LIFT PUMP THAT GOES ON THE SIDE OF THE BLOCK, THEY REPLACE IT WITH A UNIT THAT IS NOW MOUNTED IN THE TANK. I HAVE ASKED FOR ASSISTANCE BUT WAS OFFERED NOTHING. THE COST TO CHANGE THIS PART IS OVER $3000.00 DOLLARS, BUT EVEN MORE IMPORTANT IS THE FACT THAT THEY HAVE A DESIGN WHICH IS INHERENTLY DANGEROUS. HAD THIS HAPPENED 10 MILES LATER, I WOULD HAVE BEEN HALF WAY UP A MOUNTAIN ROAD. ON A DIESEL MOTOR HOME WHEN THE ENGINE DIES, YOU LOOSE BRAKES, POWER EVERYTHING.

BOTH FRONT WINDSHIELDS PARTIALLY POPPED OUT OF THEIR FRAME LEAVING OPEN GAPS BETWEEN THE WINDSHIELDS AND THE GASKET ALLOWING WIND AND WATER TO ENTER THE VEHICLE. THIS IS THE THIRD (OR FORTH) SUCH OCCURRENCE SINCE I PURCHASED THE RV IN 2000. IT SEEMS TO HAPPEN IN VERY HOT WEATHER. REPAIR PERSONNEL AT RV GLASS REPLACEMENT ESTABLISHMENTS HAVE MENTIONED THAT THE OPENING FOR THE FRONT WINDSHIELDS DOES NOT PRECISELY FIT THE FLEETWOOD SUPPLIED WINDSHIELDS AND GASKET. I AM NOT SURE WHETHER THE ROOT CAUSE OF THE PROBLEM IS RELATED TO THE EXPANSION/CONTRACTION OF THE GLASS OR THE SOFTENING OF GASKET MATERIALS UNDER HOT WEATHER CONDITIONS, A MANUFACTURING FLAW IN THE WINDSHIELD OPENING, THE FLEXING WINDOW OPENING DURING VEHICLE OPERATION, OR SOME COMBINATION OF ALL OF THESE. *TR

TL* THE CONTACT OWNS A 2005 FLEETWOOD PROWLER RV. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND NOTICED IT BECAME DIFFICULT TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE BRAKE WIRE HAD MELTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.

TL* THE CONTACT OWNS A 1998 FLEETWOOD TRAILER. THE CONTACT STATED THAT HE HEARD A LOUD NOISE COME FROM THE DOMETIC REFRIGERATOR INSIDE THE TRAILER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE REFRIGERATOR MOTOR AND A YELLOW SUBSTANCE WAS LEAKING FROM THE BOTTOM OF THE REFRIGERATOR. THE CONTACT STATED THAT HE CONTACTED THE MANUFACTURER ABOUT THE FAILURE AND THEY INFORMED HIM THAT A REPAIR HAD PREVIOUSLY BEEN PERFOMRED ON THE VEHICLE UNDER A MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED AGAIN. THE FAILURE MILEAGE WAS 5000. THE VIN WAS NOT AVAILABLE.