FLEETWOOD Complaints

TL* THE CONTACT OWNS A 2012 FLEET WOOD BOUNDER RV. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 5,900. UPDATED 05/10/12*LJ

TL* THE CONTACT OWNS A 1995 FLEETWOOD AMERICAN DREAM RV WITH A SPARTAN CHASSIS, MODEL NUMBER: 2242 (MOUNTAIN MASTER). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE POWER STEERING FAILED AND DRIVING BECAME DIFFICULT. THE CONTACT STATED THAT THE FAILURE WAS CAUSED BY THE AIR COMPRESSOR PUMP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TWICE FOR REPAIRS TO THE POWER STEERING AND THE AIR COMPRESSOR PUMP BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,916. UPDATED 05/08/12*LJ THE CONSUMER STATED THE POWER STEERING AND THE BRAKE FAILED WHILE MAKING A TURN. IT WAS DISCOVERED THE AIR COMPRESSOR FOR THE BRAKES WAS BROKEN. THE AIR COMPRESSOR WAS DESIGNED FOR THE POWER STEERING PUMP TO BOLT TO THE BACK SIDE OF THE AIR COMPRESSOR THAT RUNS THE POWER STEERING PUMP. UPDATED 05/30/12

1. RADIATOR TANK CRIMP FAILURE. EXCESSIVE CORROSION DUE TO UNDETERMINED ORIGIN CAUSED TANK CRIMPS TO RUST TO THE POINT OF FAILURE. VEHICLE WAS KEPT EXCESSIVELY CLEAN AND DRY. CRIMPS CANNOT BE SEEN VIA NORMAL WALK AROUND INSPECTION. ENTIRE RADIATOR HAD TO BE REPLACED. 2. TRANSMISSION CONTROL MODULE. CORROSION ON "J" CONNECTORS BETWEEN TRANSMISSION AND ENGINE CAUSED SHORT AND FAILURE OF NON PROTECTED TCM. TRANSMISSION WOULD NOT SHIFT. DISPLAY INDICATED "TCM FAILURE". TCM AND J CONNECTORS HAD TO BE REPLACED. CONNECTORS CANNOT BE SEEN VIA NORMAL WALK AROUND INSPECTION. TCM IS NOT PROTECTED FROM SHORTS. 3. ENGINE BLOW- BYE. OIL BLOW-BYE IS EJECTED FROM THE ENGINE DIRECTLY ONTO THE ENGINE SIDE OF THE RADIATOR THEREBY CAUSING THE RADIATOR FINS TO CLOG AND PREVENT ENGINE COOLING. FREIGHTLINER KIT TO FIX ISSUE HAS NOT BEEN PUBLICIZED, BUT WAS MADE STANDARD ON SUBSEQUENT BOUNDER MODELS.FREIGHTLINER KIT HAD TO BE INSTALLED AND ENGINE COMPARTMENT CLEANED. ENGINE SIDE OF RADIATOR CANNOT BE SEEN VIA NORMAL WALK AROUND INSPECTION. *TR

THE 2004 FLEETWOOD DISCOVERY HAS FAULTY WINDOWS THAT COULD POTENTIALLY CAUSE DANGER TO DRIVERS, PASSENGERS, AND OTHER DRIVERS DUE TO LACK OF VISIBILITY. I AM AN OWNER AND WOULD LIKE FLEETWOOD TO RECTIFY THIS PROBLEM IMMEDIATELY BEFORE IT IS TOO LATE! *TR

TL* THE CONTACT OWNS A 2004 FLEETWOOD PROWLER FIFTH WHEEL TRAILER. THE CONTACT STATED THAT THE WELDS OF THE CROSS MEMBERS ON THE CHASSIS WERE FRACTURED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V289000 (STRUCTURE) BUT THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS NOT AVAILABLE.

WHILE DRIVING MY MOTOR HOME WHICH IS BUILT ON A 1999 FORD CHASSIS I LOST POWER AND HAD TO COAST TO THE SIDE OF THE ROAD. IT DID NOT SHUT COMPLETELY OFF BUT I HAD NO POWER TO CONTROL THE SPEED. I TURNED THE VEHICLE OFF AND TRIED TO START IT AND IT STARTED. AS WE DROVE OFF IT RAN FINE THE REST OF THE TRIP HOME.WHEN I WAS HOME I SCHEDULED TO HAVE IT SERVICED BY MY LOCAL FORD DEALER.THEY PUT IT ON THEIR SCANNER AND FOUND TWO CODES.THE CODES WERE CLEARED AND THEY TEST DROVE IT AND RESCANNED IT AND IT WAS OK. ON 23 FEB 2011 IT WAS IN THE SHOP FOR THE SAME PROBLEM AND IT WAS SCANNED A CODE CAME UP AND A SENSOR WAS REPLACED. THE NEXT MORNING IT WAS TEST DRIVEN AND RETEST WAS OK.THE FOLLOWING WEEK I TOOK OFF ON A TRIP TO FLORIDA FROM PA. THE FIRST TIME IT LOST POWER WAS ON THE BELTWAY AROUND WASHINGTON DC. I CONTINUED TO HAVE THIS PROBLEM OFF AND ON THE WHOLE TRIP DOWN TO FLORIDA. WHEN WE PULLED OFF TO THE SIDE OF THE ROAD EACH TIME IT HAPPENED I WOULD SHUT THE VEHICLE DOWN AND IT WOULD RESTART AND DRIVE AWAY TILL THE NEXT TIME I LOST POWER.WE DECIDED TO CUT OUR VACATION SHORT AND TRY TO GET HOME. WE TRIED TO DRIVE AT TIMES WHEN TRAFFIC WAS NOT HEAVY BECAUSE IT WAS AT TIMES BECOMING A BIT UNSAFE. WE MOSTLY TRIED TO STAY OFF THE INTERSTATE ROADS. BUT COULD NOT ALWAYS DO THAT. WE FORTUNATELY GOT HOME OK. ON MARCH 25,2011 I HAD IT TO THE DEALER AGAIN AND THEY TEST DROVE IT A NUMBER OF TIMES AND CHECKED FOR CODES AND NOTHING CAME UP. I RECENTLY HAD THE FUEL PUMP REPLACED AND I HAVE THE SAME PROBLEM WITH IT LOOSING POWER WHILE I AM DRIVING. I AM AFRAID TO DRIVE THE VEHICLE AS I FEEL IT IS NOT SAFE. *TR

I OWN A 2006 FLEETWOOD PROVIDENCE MOTOR HOME WITH A SERIOUS SAFETY ISSUE. THE DUAL PANE WINDOWS ARE OBSTRUCTED BY A GASEOUS FOG DUE TO THE FAILURE OF THE SEAL BETWEEN THE GLASS. I WOULD ACCEPT THAT ONE, POSSIBLY TWO DUAL PANE WINDOWS MAY LOSE THEIR SEAL AND FOG OVER TIME BUT EVERY WINDOW ON THIS VEHICLE IS FOGGED TO THE POINT OF MAKING IT UNSAFE TO DRIVE. I HAVE DIFFICULTY SEEING TRAFFIC THROUGH THE SIDE VIEW MIRRORS. MY VEHICLE IS OUT OF WARRANTY BUT AT 5 YEARS AND 19,000 MILES BUT THERE IS NOTHING AN OWNER CAN REASONABLY DO TO "MAINTAIN" THE WINDOWS TO KEEP THIS FROM HAPPENING. BASED ON LIMITED RESEARCH OF OWNER SITES AND INDUSTRY PUBLICATIONS, THIS PROBLEM IS NOT LIMITED TO FLEETWOOD ALONE. IT'S A COMMON ISSUE AMONG ALL CLASS A MOTORHOME OWNERS OF ALL MAKES. THE MOTORHOME MANUFACTURER OR THE WINDOW MANUFACTURER SHOULD HAVE SOME RESPONSIBILITY FOR THE SAFETY OF THE MOTORING PUBLIC. I SEND THIS TO YOU AS YOU MAY BE AWARE OF ACTIONS TAKEN BY THE INDUSTRY OR YOU CAN POSSIBLY HELP WITH A RESOLUTION. *TR

HAVE A SPRINTER MOTOR HOME WITH KUHMO TIRES MODEL # ROAD VENTURE AT, SIZE LT215/85R-16. THE RIGHT REAR TIRE FAILED AND TREAD SEPARATED FROM TIRE. I HAD THE SPARE TIRE INSTALLED BY A TIRE DEALER TO REPLACE THE DEFECTIVE TIRE. THE TIRE DEALER KEPT THE DEFECTIVE TIRE. *TR

WHILE TRAVELING SOUTH ON INTERSTATE 85 NORTH OF MONTGOMERY, AL, THE CARLISLE TRAIL RADIAL TIRE BLEW OUT CAUSING $7000+ IN DAMAGE TO MY RV. CARLISLE SENT ME 5 REPLACEMENT TIRES BUT DENIED MY CLAIM FOR DAMAGES. *TR

TL* THE CONTACT OWNS A 2007 FLEETWOOD REVOLUTION RV. THE CONTACT WAS DRIVING 55 MPH WHEN THE ANTI-LOCK BRAKE WARNING LAMP ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 30,000.