1992 FORD AEROSTAR Complaints

MASTERCRAFT A/S IV P215/75R14 TIRE FAILED ON RIGHT REAR WHILE TRAVELLING BETWEEN 65-70 MPH ON INTERSTATE. TREAD SEPARATED FROM TIRE WHILE TIRE REMAINED INFLATED. TREAD CAUSED DAMAGE TO INTERIOR OF WHEEL WELL AND EXHAUST PIPE.*AK THIS WAS THE SECOND INCIDENCE ON THIS VEHICLE FOR THE SAME BRAND & MODEL TIRE AS THERE WAS A PREVIOUS FAILURE OF THE SAME TYPE SEVERAL YEARS AGO WITH SAME MODEL TIRE. PLEASE NOTE THAT UNDER TIRES YOUR WEB SITE DOES NOT ALLOW ME TO CHOOSE THE CORRECT SIZE AS THERE ARE ONLY TWO CHOICES.

THE SHIFTING LEVER IN THE STEERING COLUMN MALFUNCTIONED, WHICH CAUSED THE VEHICLE NOT TO SHIFT. PART# 2F0DC-7215 53. *AK THIS WAS DUE TO A MECHANICAL FAILURE AND MAY BE A MANUFACTURER DEFECT. THE PROBLEM WAS THE TRANSMISSION/SHIFT ACTUATING TUBE. *SCC *JB

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITH NO WARNING EHICLE WILL SHUT OFF, CAUSING CONSUMER TO PULL OVER, AND IT WILL BE HARD TO GET THE VEHICLE BACK STARTED.DEALER NOTIFIED.*AK

THE HEAD LIGHTS FLICKERED AND THEN WENT OUT, THE ALTERNATOR WAS REPLACED, HOWEVER THE PROBLEM CONTINUED. *JB

FIRST STARTED OUT A COUPLE OF MONTHS AGO. HEADLIGHTS WOULD FLICKER OFF AND THEN BACK ON. I FIGURED IT WAS NOTHING. NOW THE HEADLIGHTS FLICKER EVERY 30-60 SECONDS, CAN NOT DRIVE VEHICLE AT NIGHT, HAVE ALREADY BEEN PULLED OVER BY POLICE BECAUSE OF IT. I EXPLAINED TO THE OFFICER THERE MUST BE A PROBLEM WITH THE HEADLIGHTS. *JB

WHILE DRIVING AT HIGHWAY SPEEDS AT NIGHT, HEADLIGHT SWITCH (F49Z-11654-A), WITH AUTOLAMP OPTION, FAILED AND HEADLIGHTS STARTED FLASHING OFF AND ON THEN GOING OUT COMPLETELY. THIS HAS OCCURRED THREE TIMES, 9/98 AT 93,000 MILES (SWITCH REPLACED), 8/01 AT 145,000 MILES (NEW SWITCH AND BLOCK INSTALLED W/OLD WIRING) AND 10/02 AT 160,000 MILES (NEW SWITCH AND BLOCK W/NEW WIRING INSTALLED). VEHICLE NORMALLY DRIVEN WITH HEADLIGHTS ON FOR SAFETY SO USEAGE TIME ON SWITCH IS EXTENSIVE. EACH TIME LIGHTS WENT OUT, THE HEADLIGHT SWITCH CONTACTS, TERMINALS AND WIRE TERMINAL CONNECTORS HAD OVERHEATED AND DISCOLORED. THE OVERHEATING MELTED AND DISTORTED THE PLASTIC SWITCH CASE AND TERMINAL BLOCK (D3TZ-11A648-A), ALLOWING OR FORCING TERMINALS TO DISTORT OR MOVE. BOTH OF THE BATTERY POWER TO MAIN LIGHT SWITCH TERMINALS, A & B AND THE MAIN LIGHT SWITCH TO DIMMER SWITCH TERMINAL, WERE THE ONLY ONES OVERHEATED. DT

CHILD WAS ABLE TO SHIFT GEAR OUT OF PARK. VEHICLE WAS NOT ON AT THAT TIME. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

VEHICLE WAS IN PARK WITH KEY OUT OF IGNITION WHEN A TWO YEAR OLD CHILD WAS ABLE TO PUT VEHICLE IN NEUTRAL. VEHICLE WAS VERY DANGEROUS. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

WHEN CHANGING GEARS VEHICLE WILL SHAKE. WHEN TRAVELING AT 55 MPH THERE IS A BAD JERK IN VEHICLE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

CONSUMER WAS NOT ABLE TO TURN KEY TO SHUT OFF ENGINE. A PIN IN LINKAGE GOING TO THE IGNITION SWITCH HAD FALLEN OUT. CONSUMER REPAIRED HIMSELF.*AK