1997 FORD AEROSTAR Complaints

WHEN ACCELERATING CONSUMER HAD TO DEPRESS THE GAS PEDAL SEVERAL TIMES TO GET THE VEHICLE TO MOVE. WHEN THE VEHICLE MOVED THE THROTTLE GOT STUCK, AND REVVED VERY HIGH. DEALER INFORMED THE CONSUMER THAT THE THROTTLE LINKAGE HAD A STICKING PROBLEM. *AK

WHILE TRAVELING ON THE HIGHWAY AT APPROXIMATELY 70 MPH, THE TREAD ON THE REAR DRIVER'S SIDE TIRE SEPARATED RAPIDLY, WHICH RESULTED IN COMPLETE DESTRUCTION OF THE TIRE. *AK THE WHEEL WELL AND BUMPER WERE DAMAGED AS A RESULT OF THE TIRE FAILURE. THE TIRE WAS REPLACED AND IT FAILED AGAIN WHILE TRAVELING ON THE HIGHWAY. THE WHEEL WELL AND BUMPER WAS AGAIN DAMAGED. *PH *JB

CONSUMER NOTICED THAT REAR DRIVER'S SIDE RIM SPOKES ARE CRACKED. VEHICLE DID NOT HIT ANYTHING. *AK FOUR SPOKES WERE CRACKED COMPLETELY THREW. ANY MORE AND CONSUMER FACED LOSS OF WHEEL FROM THE VEHICLE. CONSUMER HAD THE SPARE PUT ON AND RIM REPLACED. CONSUMER LEARNED A PARTICULAR DEALERSHIP SELLS ONE OR MORE TO OTHER CUSTOMERS WITH THE SAME PROBLEM. ONE PARTICULAR CUSTOMER WENT TO THE DEALERSHIP WITH THREE DEFECTIVE RIMS. *PH

THE VEHICLE EXPERIENCED THE PROBLEM AS STATED IN RECALL # 97 V 204 000, HOWEVER THE VEHICLE IDENTIFICATION WAS NOT INCLUDED IN THE RECALL. *JB

VEHICLE WILL NOT RUN PROPERLY DUE TO THE TRANSFER CASE BEING DEFECTIVE. THERE IS A LOUD NOISE WHEN DRIVING. CONTACTED DEALER, AND THE DEALER NOTED THAT VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *YH

RIGHT FRONT SPINDLE AND KNUCKLE ASSEMBLY MALFUNCTIONED. DEALER HAS BEEN NOTIFIED. *AK RIGHT FRONT SPINDLE/KNUCKLE ASSEMBLY WAS REPLACED. RIGHT FRONT ROTOR, INNER AND OUTER WHEEL BEARINGS AND SEAL WERE ALL REPLACED. *TT

VEHICLE WAS IN A HEAD-ON COLLISION AND NEITHER OF THE AIR BAGS DEPLOYED. PLEASE PROVIDE MORE INFORMATION.*AK

FORD RECOMMENDS INCORRECT ADJUSTMENT OF REAR BRAKES, WHICH CAUSES OVERHEATING OF DRUMS AND EVENTUAL FAILURE OF AXLE SEALS, AXLE BEARINGS, AND TIRE ON THE RIM ATTACHED TO THE BRAKE DRUM. FORD STIPULATES THAT BRAKE SHOES ARE TO BE TOUCHING DRUM WHEN BRAKES ARE ADJUSTED. THIS RESULTS IN FRICTIONAL HEAT BUILD-UP, AND IS LIKELY TO BE A CONTRIBUTOR TO TIRE FAILURES REPORTED WITH THE FORD EXPLORER. THE FORD EXPLORER, AEROSTAR, AND RANGER ALL SHARE POWER TRAIN AND DRIVE TRAIN COMPONENTS. THIS PRACTICE HAS COST ME $000S ON MY 4 FORD AEROSTARS (1989, 1992, 1994, AND 1997 MODEL YEARS)

VEHICLE WAS SLOWING DOWN GOING 35-45MPH IN THE RIGHT SLOW LANE. WHEN BRAKES WERE APPLIED, VEHICLE PICKED UP MORE SPEED, CAUSING CONSUMER TO LOSE CONTROL. VEHICLE RAN INTO ONE OF THE BEAMS UNDER UNDERPASS OF THE HIGHWAY. UPON IMPACT, FRONT DRIVER'S AIR BAG DIDN'T DEPLOY. CONSUMER'S FACE HIT STEERING. CONSUMER HAD 16 STICHES IN BOTTOM LIP. CONSUMER HAD A CASE, AND WAS NOT ALLOWED TO CONTACT DEALER AT THIS TIME.*AK

WHEN IT RAINS/UNABLE TO OPEN DOOR LOCK FROM PASSENGER SIDE; UNEXPLAINED STALL CHECK/ENGINE LIGHT CAME ON/STARTED WITH NO PROBLEM