1992 FORD AEROSTAR Complaints

WHILE DRIVING ON THE HIGHWAY ALL OF SUDDEN THE REAR ABS WARNING LIGHT INTERMITTENTLY CAME ON. DIDN'T CONTACT THE DEALER OR MANUFACTURER. *AK

WHILE THE DRIVER WAS GOING AT 65 MPH, THE FRONT LEFT TIRE SEPARATED FROM THE VEHICLE CAUSING DAMAGE FRONT BRAKE ASSEMBLY. (OHIO TRAFFIC CRASH REPORT) YH

PLASTIC FUEL LINE FAILURE/SPLIT RESULTING IN LEAKAGE OF FUEL AND VEHICLE FIRE. *MJS

ENGINE GASKET/VALVE COVER GASKET/REAR MAIN SEAL, AND OIL PAN GASKET NEEDED REPLACEMENT. DEALER/MANUFACTURER NOTIFIED. PROVIDE FURTHER DETAILS. *AK

TRANSFER CASE THAT WAS PUT IN BY DEALER ENGAGES UP TO 70 MPH. THIS COULD CAUSE CAR TO LOSE CONTROL. *AK

AFTER REPAIR OF RECALL 99V094000 WERE DONE, TRANSFER CASE PROBLEMS BECAME WORSE . DEALER INSPECTED THE VEHICLE SEVERAL TIMES, TRANSMISSION CROSS MEMBER SUPPORT REPLACED AND REAR END BEARINGS AND CARRIER HOWEVER VEHICLE STILL HAD ROUGH SHIFTING, UNABLE TO FIX DEFECT. *AK

REPACED HEADLIGHT SWITCH TWICE BECAUSE OF LIGHTS GOING OUT AT NIGHT WHILE DRIVING. ORIGINAL SWITCH APPEARED AS IF IT HAD GOTTEN HOT. AFTER JUMPER ON THE WIRING HARNESS WAS INSTALLED AFTER RECEIVING RECALL NOTICE IN EARLY 1999, LIGHTS HAVE BEEN DOING GREAT UNTIL THIS EVENING, WENT OUT LIKE PREVIOUS TIMES. A COUPLE OF DAYS AGO THE DOOR AJAR LIGHT ON DASH WAS CLICKING ON AND OFF.*AK

LIGHTS FAILED AFTER REPLACEMENT OF MULTIFUNCTION SWITCH/LIGHTS FAILED AGAIN-DEALER RESPONSE

AIR BAG LIGHT FLASHES CODE OF 3/2 INDICATING THAT THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF AN ACCIDENT. SWITCH HAS BEEN REPLACED AT LEAST 4 TIMES AND WITHIN A YEAR FAILS AGAIN. FORD REFUSES TO REPLACE IT ANYMORE. DURING RECENT ACCIDENT AIRBAG DID NOT DEPLOY.

WHILE DRIVING ON THE ROAD ANOTHER DRIVER SIGNALED CONSUMER TO STOP BECAUSE TRANSMISSION WAS LEAKING. MECHANISM IN THE TRANSMISSION WAS BROKEN. TRANSFER CASE WAS CAUSING THE LEAK, AND THIS COULD CAUSE A FIRE. *AK *ML