2021 FORD BRONCO SPORT Complaints

The contact owns a 2021 Ford Bronco Sport. The contact stated that the vehicle was taken to a vehicle inspection station, and the contact was informed that the test could not be performed due to a faulty sensor. The contact was informed by a mechanic at the inspection station that the vehicle might be under recall. The local dealer was notified of the failure, and the contact was informed that the vehicle was not included in the recall. The contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 32,000.

The car caught fire the morning of Dec 11, 2024 while the vehicle's owner was driving their children to school. There are photos and a fire report is being generated. The vehicle's owner and her children could have been killed. Early indications are that the fire was caused by the same faulty engine/exhaust system defect that the owner has been complaining to Ford about for years. It is assumed the fire report will confirm that. For the past two or more years the vehicle has been emitting exhaust fumes into the passenger compartment of the vehicle while driving. This has caused the vehicle's owner and her children to get sick and forced them to drive the vehicle with the windows down at all times even in cold weather. Ford's dealers have confirmed the problem several times, but either could not or refused to fix it. A summary of the vehicle's service history is included below: 35,662 miles Customer states inside of vehicle smells like exhaust. 37,431 miles Inside of vehicle smells like exhaust. 39,856 miles inside of vehicle smells like exhaust. confirmed customers concern found cat warped at mating surface to turbo replacement required. 46,832 miles Fumes getting inside the Cab, seems to be blowing in from vents. Misdiagnosed as blower motor electrical smell and missed broken catalyst. 47,300 miles Customer had car towed into shop stating car was shaking and smelled flumes inside the car. Verified concern that exhaust smell was present in car and loud noise was coming from engine, found catalytic converter had broken at flange to turbo causing exhaust leak. Recommend new catalytic converter, removed and replaced catalytic converter. Low pressure fuel injectors are leaking. Verified customer concern, found fuel seeping out of all 3 low side injectors, recommend injector replacement, remove and replaced all 3 low side fuel injectors, found no other leak at this time. Found injectors were leaking fuel. 47,829 miles Check engine light. Remove and replace purge valve.

My daughter was operating the vehicle when it unexpectedly lost power and came to a stop without warning. The instrument panel began flashing, and she was unable to restart the vehicle to move it out of traffic. A jump-start was required to get the vehicle operational. It has been taken to Koons Ford Annapolis for evaluation. Vehicle mileage is aprox. 27,000

Torque converter failure at 100,000 miles. Car hesitates when it accelerates creating delay when going from stop to start.

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle started losing motive power. A message advising a power train failure was displayed. The driver was able to exit the highway at 15 MPH. The vehicle was driven to a nearby dealer, where the computer was rebooted; however, the failure recurred several times while driving. The vehicle was taken back to the dealer several times, and the transmission was rebuilt. The contact stated that the failure had been recurring while driving. The contact stated while her husband was driving 70-80 MPH, the vehicle lost electrical power and stalled. The check engine and the power train warning lights were illuminated. The driver was able to pull to the side of the road. The vehicle was able to restart but failed to exceed 15 MPH. The driver continued driving on the shoulder of the roadway. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and informed the contact that the repair could not be covered due to the mileage on the vehicle. The failure mileage was approximately 1,310.

The contact owns a 2021 Ford Bronco Sport. The contact stated while the vehicle was parked, the windshield washer fluid was leaking out of the front camera. The windshield fluid warning light was illuminated. The failure occurred on several occasions. The vehicle was towed to a dealer to be diagnosed; however, the dealer informed the contact that a cause for the failure was not found. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown. The VIN was not available.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at undisclosed speeds and while in reverse, the instrument panel occasionally flickered. The battery failure warning light illuminated intermittently. In addition, the contact stated that while attempting to start the vehicle, the engine failed to turn over. AAA was contacted and arrived on the scene to replace the battery. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 24V267000 (Electrical System, Power Train); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.

Bought 12-1-23 got recall 24V-267 fix and then the vehicle started to die at red lights if the autostart/stop wasn't turned off. On 12/9/24 apparently the turbo went out. Unsure how only 95,345 miles. The driver window get stuck down anytime at a drive thru. Will have to turn off vehicle completely and restart for it to roll back up.

On two occasions vehicle has turned off while in drive. Have taken to dealership without a resolution. After vehicle is off for several minutes (unable to turn anything on including hazards) vehicle starts up and computer resets without any warnings. Unable to put the vehicle in neutral to move off the road while occurring.

Since performing a manufacturer update to the Sync technology system, my touch screen has not functioned properly, including the back up camera. The screen goes black or freezes on the rear view camera even when in drive and moving forward. Each time this happens, the system has to be rebooted.