2021 FORD BRONCO SPORT Complaints

Recall 25S76 announced on 7/16/25 is still not completed. Ford states parts still not available. After 7 months, there seems to be no sense of urgency on Ford's part or their supplier's part. when will parts be available?

This vehicle is subject to NHTSA Recall 25V467 involving potential fuel injector cracking and risk of fuel leaking onto the engine, creating a fire hazard. The recall status shows “Remedy Not Yet Available,” leaving the defect unresolved. While driving, the vehicle suddenly displayed an engine overheating warning and immediately entered limp mode, causing abrupt loss of power. The vehicle decelerated unexpectedly and was not able to maintain normal driving speed. This created a dangerous situation in active traffic and required a safety tow. The sudden power reduction could have resulted in a rear-end collision or loss of vehicle control. There were no prior overheating warnings immediately before this incident. The failure occurred abruptly. A warning message appeared at the time of the event, followed by limp mode activation. The vehicle had to be towed to a dealership for inspection. Given that the open recall involves fuel injector cracking and potential fuel accumulation near hot engine components, there is concern that the unresolved recall condition may be related to engine overheating and loss of power. The vehicle remains under an active fire-risk recall, yet no repair remedy is available. Owners are left operating vehicles with a known safety defect and no corrective action timeline. The defect has not been remedied because parts are not available. The vehicle was inspected by a dealership after the overheating event. The primary safety concern is the combination of an open fire-risk recall and a sudden overheating/limp mode event causing abrupt power loss in traffic, creating a serious risk of injury. Due to this open recall with no available remedy, the vehicle cannot be listed or rented on a peer-to-peer vehicle sharing platform, resulting in loss of legitimate income. The vehicle was previously eligible for use, but is now restricted solely because the safety recall remains unresolved without a repair solution. Owners are financially impacted.

Since my car hit 40000 miles it has had nothing but issues. I've had it in the shop at least 10 times. My brakes went out while driving with my [XXX] old, I've had loss of power, smell of exhaust in the cabin for the last 3 months and dealership says it can't be fixed, yesterday I had complete engine failure while on the freeway. Stalled and wouldn't start back up for 5 min. The dealership has never fully fixed anything but has only updated the computer system. I feel very unsafe in this vehicle. We still owe on this vehicle so trading it in is not an option since its not even worth the down payment I put down. It has a fuel injector recall that can't be fixed yet due to not having the parts available. What are we suppose to do if we can't drive the vehicle and can't buy a new one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car check engine light came on, I came home parked the car, in about 5 minutes the cars embarked in flames, the car burned down to the ground. The safety of my entire home (flames caught onto house) and neighbors home was at risk. The burning car was inspected by Fire Chief of Christiana Fire Company

I am experiencing pulsing and lunging while accelerating and cause loss of power and unsafe driving.

LOSS COMPLETE POWER WHILE DRIVING IN RUSH HOUR TRAFFIC. THE DASHBOARD LIT UP BUT NO POWER. THE TOW TRUCK DRIVER TRIED TO CHARGE BATTERY IT WAS NOT THAT. HE WAS DUMBFOUNDED ON WHAT HAPPENED. I SAT IN A VEHICLE ON A BUSY ROAD IN RUSH HOUR FOR OVER AN HOUR BECAUSE i HAD NO SAFE PLACE TO GO. NO WARNING SIGNALS PRIOR, NO NOISES. JUST DIED WHILE IN USE. WAS TOWED TO FORD DEALERSHIP, WAS TOLD 48 HRS LATER ITS DRIVING FINE. THEY CANT FIND AN ISSUE. I AGAIN EXPLAINED I LOSS COMPLETE POWER AND WAS PUT IN A VERY DANGEROUS SITUATION AS WELL AS THE FACT THE TEMPERATURE OUTSIDE WAS IN THE 20S. THE VEHICLE IS STILL AT SERVICE WITH NO ANSWERS, THIS IS THE 4TH SERVICE IN LESS THAN 60 DAYS WITH ISSUES. 2 WHERE TRANSMISSION, 1 WAS A GAS VALVE

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at 25 MPH, the vehicle started jerking abnormally. There were no warning lights illuminated. The contact had received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The vehicle was taken to the local dealer, where it was diagnosed, and it was determined that the failure was due to the torque converter. The contact was informed that the transmission fluid needed to be flushed and refilled. The vehicle was not repaired. The manufacturer was contacted and offered to cover 60 percent of the cost of the repair. The failure mileage was approximately 85,000.

My passenger seat heater caught on fire, it was very scary but I was able to put it out with sugar after I pulled over and figured out where the smell was coming from. I took it to my dealer for an inspection but I feel as though they were just trying to cover their side of everything and said “the seat heater did not cause the fire unfortunately”. I am currently in contact with ford and my insurance company. My insurance so far just says they need to investigate more but also that my claim is closed so I’m honestly just at a loss and confused about that and will be reaching out to them again soon. There was no warning at all and I’m glad I caught it when I did because I had glasses cleaner in my passenger side door that is very flammable.

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and there was an abnormal sound coming from the vehicle while driving. The contact was unable to determine the location of the sound. The vehicle was taken to the local Auto Zone, where an undisclosed system failure had occurred. No further information was available. The failure mileage was 77,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, there was a grinding sound coming from the engine compartment. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, parts for the recall repair were not yet available. The vehicle was taken to a dealer, but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 39,000.