2013 FORD C-MAX ENERGI Complaints

CAR GOES DEAD AND 12-VOLT BATTERY IS BEING DRAINED BECAUSE FAULTY COMPUTER PROGRAMMING LEAVES ELECTRICAL MODULES ON EVEN WHEN THE CAR IS TURNED "OFF." UNCLEAR IF ITEMS THAT REMAIN ELECTRICALLY "HOT" POSE DIRECT SAFETY PROBLEMS, BUT CONSUMERS RISK BEING UNABLE TO START/RESTART THE CAR IN EMERGENCY OR NORMAL SITUATIONS. FORD DECLINES TO PAY FOR REPROGRAMMING THIS FAULTY DESIGN BEYOND THE NORMAL WARRANTY TIME (EVEN WHEN THE CAR IS COVERED BY A FORD EXTENDED "PREMIUM" WARRANTY). IN MY CASE, THE CAR WAS PARKED AT MY HOME AND THE BATTERY FAILED - TWICE IN A FEW WEEKS - OVERNIGHT IN WARM SUMMER WEATHER. I URGE YOU TO EXAMINE WHAT SYSTEMS ARE BEING LEFT ON AND TO URGE OR REQUIRE FORD TO CORRECT ITS DESIGN DEFICIENCIES. THANKS.

REAR (HATCHBACK) LATCH FAILS TO RELEASE RESULTING IN A DOOR WILL NOT OPEN CONDITION. BECAUSE THE LATCH RELEASE WAS ACTIVATED, DRIVING OR ROAD VIBRATION MAY CAUSE THE DOOR TO OPEN UNEXPECTEDLY AND EJECT CARGO WHILE THE VEHICLE IS IN MOTION. HATCHBACK FAILS TO OPEN AFTER ELECTRONIC RELEASE IS ACTIVATED AND MUST BE "JIGGLED" TO OPEN. HATCHBACK LATER OPENED WHEN THE VEHICLE WAS IN MOTION. REAR DOOR IS NOT COVERED BY NHTSA CAMPAIGN NUMBER: 16V643000.

TL* THE CONTACT OWNS A 2013 FORD C-MAX ENERGI. WHILE DRIVING 70 MPH, THE STOP VEHICLE NOW INDICATOR ILLUMINATED. THE VEHICLE BEGAN TO LOSE POWER AND SLOWED TO A STOP WITHIN 200 YARDS. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 104,163. UPDATED 05/16/17*LJ UPDATED 05/26/2017 *JS

FORD HAS YET TO PROVIDE DEALERS WITH PARTS TO REPAIR RECALLED DEFECTIVE DOOR LATCHES IN THIS VEHICLE. THE RECALL NOTICE SAYS FORD HAS KNOWN ABOUT THIS ISSUE SINCE AT LEAST FEBRUARY 2015 - NEARLY TWO YEARS AGO - AND ISSUED THE FORMAL RECALL NOTICE IN SEPTEMBER 2016. ARE THEY MAKING ANY EFFORT TO RESOLVE THIS? IT WOULD SEEM A MECHANICAL FIX LIKE THIS SHOULD NOT TAKE MONTHS OR YEARS TO RESOLVE - ESPECIALLY ON A CAR WHICH HAS HAD RELATIVELY LIMITED SALES. I HOPE YOU WILL CHECK ON THIS AND URGE FORD TO PROMPTLY MAKE THE PROMISED FIX.

TL* THE CONTACT OWNS A 2013 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE DOOR LATCH FAILED AND THE DOOR WAS DIFFICULT TO OPEN AND CLOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). THE DEALER AND MANUFACTURER WERE CALLED ON MULTIPLE OCCASIONS AND STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE FAILURE MILEAGE WAS 26,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2013 FORD C-MAX ENERGI. WHEN CHARGING THE VEHICLE, THE OUTLET LOCATED IN THE WALL MELTED AND THE SIDE OF THE CORD USED TO CHARGE THE VEHICLE, WHICH PLUGGED INTO THE WALL, ALSO MELTED. THE VEHICLE WAS UNABLE TO BE CHARGED. THE DEALER WAS INFORMED OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.

THE FORD EV CHARGE CORD (FORD PART NO. FM58-10B706AC) THAT CAME WITH MY 2013 CMAX ENERGI DRAWS TOO MUCH CURRENT AND IS A FIRE HAZARD. I JUST FILED A VEHICLE COMPLAINT (NO. 10904811) WITH PHOTOGRAPHS OF THE MELTED CORD AND BURN MARKS ON MY OUTLETS, DESCRIBING THE HAZARD IN DETAIL. IT IS LIKELY THAT THIS CORD OR A SIMILARLY DESIGNED CORD IS USED WITH THE FORD FOCUS ENERGI AND FORD FUSION ENERGI SO THIS HAZARD SHOULD BE INVESTIGATED AS AN EQUIPMENT DEFECT AND NOT JUST A VEHICLE DEFECT.

THE 120 VOLT, 12 AMP CHARGE CORD THAT CAME WITH MY CAR (FORD PART NO. FM58-10B706AC) IS OVERHEATING CREATING A FIRE HAZARD. THE END OF THE CORD THAT PLUGS INTO THE WALL HAS MELTED AND THE PLUG HAS LEFT BURN MARKS ON THREE DIFFERENT ELECTRICAL OUTLETS ON MY HOUSE WHERE I PLUG THE CAR IN TO CHARGE. PHOTOS OF THE MELTED CORD AND OUTLET BURN MARKS ARE ATTACHED. THERE IS A DESIGN FLAW IN THAT THE CONTROL UNIT BUILT INTO THE CORD IS TOO HEAVY AND PULLS THE PRONGS FROM THE OUTLET AND IF A PRONG IS ONLY PARTIALLY PLUGGED INTO THE OUTLET IT DRAWS MORE CURRENT THAN THE CORD CAN HANDLE. FORD IS AWARE OF THE PROBLEM AND ADVISED (FORD EV HELP LINE 1-800-392-3673) THAT THE CORD SHOULD NOT BE LEFT HANGING IN MID-AIR AND NEEDS TO BE PROPPED UP WHEN PLUGGED IN. THOSE INSTRUCTIONS ARE NOT IN THE OWNERS MANUAL OR ON THE CORD, NOR WERE THEY COMMUNICATED TO CMAX ENERGI OWNERS. FORD ASSERTS THAT THE CORD IS NOT COVERED BY ITS EXTENDED 8-YEAR, 80,000 MILE WARRANTY FOR ELECTRICAL COMPONENTS FOR THE CMAX ENERGI, SO THIS PART IS NOW OUT OF WARRANTY. IT IS VERY EXPENSIVE (I WAS QUOTED $975 BY FORD TO REPLACE THE CORD). THUS IT IS HIGHLY LIKELY THAT OWNERS WILL DEFER REPLACING THE CORD AND KEEP USING IT, BECAUSE IT STILL WORKS EVEN THOUGH THE PLUG IS PARTIALLY MELTED. THIS CORD IS HIGHLY LIKELY TO RESULT IN FIRES AND MAY BE RESPONSIBLE FOR THE TWO CMAX ENERGI GARAGE FIRES IN FLORIDA I READ ABOUT IN THE PRESS LAST MONTH. I AM HAPPY TO PROVIDE MORE INFORMATION IF YOU WANT TO CONTACT ME.

WHILE DRIVING ON AN INTERSTATE AT NIGHT AT 70MPH THE CAR TURNED OFF ITS PROPULSION SYSTEM WITHOUT WARNING. A RED WARNING INDICATOR CAME ON STAYING STOP SAFELY NOW. MY WIFE WAS ABLE TO PULL TO THE SIDE OF THE INTERSTATE. SHE TURNED THE CAR OFF AND IT RESTARTED. THE NEXT DAY SHE DROVE IT TO THE SUPERMARKET. ON THE 2 MILE DRIVE HOME IT STOPPED MULTIPLE TIMES WHILE THE CAR WAS IN MOTION JUST LIKE IT HAD ON THE INTERSTATE. THIS SEEMS VERY SIMILAR TO THE PROBLEMS THAT LED TO A RECALL ON THE FORD FOCUS ELECTRIC, WHICH WAS MADE IN THE SAME PLANT AT THE SAME TIME IN 2013: HTTP://INSIDEEVS.COM/FORD-FOCUS-ELECTRIC-SHUTDOWN-PROBLEMS-WHILE-DRIVING-GET-OFFICIAL-AS-NHSTA-INVESTIGATES/.

TO WHOM IT MAY CONCERN, SOMEWHAT NORMALLY ON LONG CAR RIDES(NORMALLY ON THE HIGHWAY) THE CAR HAS A ELECTRICAL SHORT, CAUSING THE CAR TO USE UP ALL THE EV MILES IT HAS STORED. MEAN WHILE THE CAR STARTS TO SMELL LIKE BURNING ELECTRICAL, NO SMOKE IS SEEN BUT SMELL IS THERE. WHEN THE CAR IS PARKED AFTER THE ACCIDENTS , THE CAR GOES BACK TO NORMAL. THESE ACCIDENTS HAS HAPPEN OVER 10 TIMES, OVER THE PAST 2 YEARS. WE HAVE TOKEN THE CAR TO THE DEALER AT LEAST 4 TIMES FOR THIS PROBLEM AND NOTHING GETS FIXED. I THINK ALL THAT IS DONE IT RESETTING THE ELECTRICAL, YET THE PROBLEM CONTINUES AND BEEN HAVING MORE ELECTRICAL ISSUES. PROBLEMS WITH MY FORD MOBILE, RADIO NOT TURNING OFF AND SCREENS BLINKING.