2002 FORD CROWN VICTORIA Complaints

POWER WINDOWS FRONT ELECTRIC WHEN YOU TOUCH REAR WINDOW BUTTON THE DRIVERS WINDOW GOES DOWN. *TR

THE ENGINE STALLED WHILE DRIVING, FOR NO APPARENT REASON. DRIVER (MY RETIRED MOTHER, AGE 72) HAD TO GET CAR OFF ROAD AND RESTART CAR TO CONTINUE. THE POWER STEERING DISABLED WHEN THE CAR ENGINE STALLED. THIS HAS HAPPENED MULTIPLE TIMES (2-3) OVER THE PAST MONTH, AND THE LOCAL FORD DEALERSHIP CANNOT REPLICATE THE PROBLEM AND IS UNABLE TO CORRECT IT. ON ANOTHER OCCASION THERE WAS A THUMPING NOISE AND THE CAR SLOWED CONSIDERABLY, BUT THEN PICKED BACK UP AGAIN. THE "ENGINE HEAT/THERMOMETER" LIGHT HAS FLASHED ALSO, BUT THE ENGINE TEMPERATURE HEAT IS NORMAL. I CONSIDER THIS A VERY DANGEROUS SITUATION FOR MY MOTOR IF IT WOULD HAPPEN IN A HEAVILY CONGESTED, HIGH TRAFFIC AREA AND COULD CAUSE A VEHICLE CRASHES. IT IS A VERY STRESSFUL SITUATION.

I HAD BEEN DRIVING 250 MILES OR SO AND DROVE DOWN A LONG WINDING INCLINE, AS THE ROAD FLATTENED OUT I HEARD A NOISE FROM THE ENGINE COMPARTMENT. THE NOISE SOUNDED LIKE A HOLE IN THE FIRST PART OF THE EXHAUST SYSTEM. I FOUND A SAFE PLACE TO PULL OVER AND TURNED OFF THE VEHICLE. THERE WAS A SLIGHT ODOR OF NATURAL GAS AS THIS VEHICLE IS FUELED WITH NATURAL GAS. AFTER THE ODOR PASSED, I OPENED THE HOOD TO FIND THAT THE #2 IGNITION COIL MOUNT WAS BROKEN, AND THE COIL AND SPARK PLUG ASSEMBLY WERE LOOSE IN THE SPARK PLUG WELL. MY INITIAL THOUGHT WAS THE SPARK PLUG HAD LOOSENED AND EJECTED. I ATTEMPTED TO RE-INSTALL THE SPARK PLUG BUT THE THREADS IN THE CYLINDER HEAD WERE INEFFECTIVE. THE SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD. I HAVE SUBSEQUENTLY FOUND OUT THAT THIS IS NOT AN UNCOMMON DEFECT FOR THESE FORD ENGINES. THE REPAIR INVOLVED REAMING AND TAPPING THE SPARK PLUG HOLE AND PLACING AN INSERT IN THE HOLE. THE SPARK PLUG COIL HAD TO BE REPLACED TOO. THE REPAIR COST WAS $450 AND THE REPAIR SHOP WARNED THAT THIS MAY HAPPEN AGAIN. THIS IS A DESIGN DEFECT THAT COULD POTENTIALLY BE DANGEROUS UNDER DIFFERENT CIRCUMSTANCES. IF I WAS NOT ABLE TO STOP IN A SAFE PLACE FAIRLY QUICKLY, THERE COULD HAVE BEEN MORE FUEL AIR MIXTURE ACCUMULATION UNDER THE HOOD AND SINCE THE SPARK PLUG WAS STILL OPERATIVE, AN IGNITION SOURCE WAS PRESENT TOO. *TR

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 TO 50 MPH ON NORMAL ROAD CONDITIONS PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL. THE "ABS" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND THE DRIVER WAS ABLE TO COAST INTO THE EMERGENCY LANE. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE FAILURE WAS RELATED TO THE REAR DRIVE SHAFT AXLE. NHTSA CAMPAIGN ID NUMBER 04V328000 (SUSPENSION;REAR) WAS RELATED TO THE FAILURE; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THERE WERE CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

1. WHILE DRIVING ,LED CIRCUITBOARD ,( UNDER DASHBOARD)BURNED UP EMITTING SMOKE INTO THE PASSENGER COMPARTMENT. IT BURNED A ONE INCH HOLE IN THE CIRCUITBOARD PLASTIC COVER . 2. FAILURE,THE PART BURNED UP, IT MAY HAVE BURNED BEFORE ALSO,BECAUSE WE HAVE HAD A BURNING SMELL BEFORE. 3. CAR WAS PARKED,TURNED OFF FOR ABOUT ONE-HALF HOUR , THEN DRIVEN 6 MILES HOME.,NO ADDITIONAL SMOKE WAS SEEN AT THIS TIME. PART HAS BEEN REMOVED BY OWNER .OLD PART IS AVAILABLE,PART # F8VB-14A597-AB. FUSE DID NOT BLOW AND CAR IS DRIVABLE WITH PART REMOVED. I THINK THIS PART IS A COMPONENT OF THE FACTORY INSTALLED ALARM SYSTEM. *TR

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING BETWEEN 55-60 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE BEGAN TO HESITATE AND VIBRATE. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THERE WAS AN INTERNAL COIL SHORTAGE. THE MISFIRE CYLINDER 5, COIL PACK, AND SPARK PLUGS WERE REPLACED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A SEPARATE OCCASION FOR THE IDENTICAL FAILURE AND THE MISFIRE CYLINDER 7, COIL PACK, AND SPARK PLUGS WERE REPLACED AT THAT TIME. THE FAILURE MILEAGE WAS 67,425 AND CURRENT MILEAGE WAS 68,045. UPDATED 03-27-09 *BF UPDATED 03/31/09.*JB

WHILE DRIVING THE LOW BEAMS WENT OUT ON CAR,20 MINUTES LATER HIGH BEAMS WENT OUT. ALL OTHER LIGHTS WORK PROPERLY, HEADLIGHTS HAVE NOT WORKED SINCE. CURRENTLY IN THE PROCESS TO REPLACE PART. *TR

JUST CRUISING THROUGH A PARKING LOT ON MY WAY INTO WORK AND HAD A SPARK PLUG BLOWOUT. DAMAGED THE SPARK PLUG COIL AS WELL. HAD TO BUY A NEW COIL, AND A HELICOIL KIT TO RE-TAP THE SPARK PLUG HOLE. *TR

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT OPENED THE HOOD, BUT IT FAILED TO OPEN AUTOMATICALLY. HE PLACED HIS HAND ON THE FENDER AND THE HOOD SUDDENLY FELL AND SLAMMED DOWN ON HIS HAND. THE CONTACT SUSTAINED SEVERAL BRUISES, CUTS, AND BLISTERS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 56,000. UPDATED 03/18/08. *LJ THE CONSUMER STATED AT THE TIME OF THE INCIDENT THE HOOD WAS RAISED TO THE FULL CAPACITY AND VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED STRUTS WERE REPLACED AT CONSUMER'S EXPENSE. UPDATED 03/18/08 *TR UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR

2002 FORD CROWN VICTORIA LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. *KB THE VEHICLE WAS DAMAGED AS A RESULT OF THE WHEEL COMING OFF. OHIO TRAFFIC CRASH REPORT# 10-89-0577. *JB