2019 FORD ECOSPORT Complaints

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that after exiting the freeway, the low oil pressure warning light illuminated, the vehicle vibrated, and the check engine warning light illuminated. The contact attempted to pull into a gas station but instead pulled over to the side of the road and turned off the vehicle. The contact exited the vehicle and checked the oil level, and the oil level was at the proper level. After waiting for approximately 30 minutes, the vehicle was restarted. The contact attempted to drive, and the engine seized. The vehicle was hauled by a friend to the residence. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The vehicle remained at the residence and had not been driven since the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

The contact owns a 2019 Ford EcoSport. The contact stated that while driving approximately 60-65 MPH, the vehicle jerked, lost automotive power, or stalled on several occasions. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was restarted after approximately 5 minutes. The vehicle was taken to the dealer, where an unknown interim repair of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) was performed twice; however, the failure persisted. The vehicle was taken back to the dealer, where the contact was informed that failure might be unrelated to the recall, and that further diagnostic tests were needed. The vehicle was not diagnosed or repaired. The failure mileage was approximately 60,682.

The contact owns a 2019 Ford Escape. The vehicle was initially taken to the local dealer for NHTSA Campaign Number: 26V011000 (Equipment). The vehicle was taken back to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The contact stated that the engine had overheated. A diagnostic scanner was used to determine that the head overheat protection was active and there was no coolant in the coolant reservoir. The hose was not connected to the heater cooler. The donut gasket was not attached to the exhaust. There were no warning lights illuminated. The contact stated that the O-ring had failed to snap in place. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

I have had to put a new engine in my 2019 ford ecosport 3 times due to the open recall on the vehicle. It is currently at the ford dealership due to coolant leaking into the head gasket. The problems with the vehicle have been confirmed by the dealers. And no there were ZERO warnings or signs before the vehicle completely failed on us on the highway the first time. Then the same issue happened yet again and had to put my car in the shop again for another new engine due to the recall.

The vehicle’s engine losses power while driving. Low oil pump pressure appears on the dashboard. The problem has been confirmed by a dealer. There were no warning lamps prior to the failure. The problems started February 2026.

The contact owns a 2019 Ford EcoSport. The contact stated that while starting the vehicle, the low oil warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the oil pump had failed, which caused the engine failure. The contact was informed that the engine needed to be repaired. The vehicle was not repaired. The dealer informed the contact that the failure was related to a previous repair completed under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); where the oil pump tensioner assembly had not been replaced, and only the oil drive pump belt had been replaced. The dealer contacted the manufacturer to request an engine replacement due to the recall-related failure. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 38,000.

I am writing to formally file a complaint with the National Highway Traffic Safety Administration regarding an unresolved safety recall on my 2019 Ford EcoSport. On February 18, 2026, at approximately 9:01 A.M., I contacted my local dealership, El Cajon Ford, to schedule the recall repair. I was informed that the required recall parts are on indefinite backorder and that there is no estimated date for availability. This leaves my vehicle unrepaired for a known safety defect with no clear timeline for remedy. Additionally, during that same conversation, I informed the dealership that my check engine light is currently illuminated, which raises further concerns given the open safety recall. I was told that if I bring the vehicle in for diagnostic testing and the issue is determined not to be related to the recall, I would be responsible for a $209 diagnostic fee. I am concerned that this creates a financial barrier to determining whether the warning light may, in fact, be related to the known safety defect. I regularly transport my [XXX] child in this vehicle. Continuing to operate a vehicle subject to an open safety recall — particularly one involving a potentially serious safety-related defect — places my family at unnecessary risk. The indefinite delay in parts availability undermines the purpose of a federally mandated safety recall. Under federal law, manufacturers are required to provide a free and timely remedy for safety-related defects. An open-ended delay with no estimated repair date does not appear to meet that standard and leaves consumers without meaningful protection. I respectfully request that NHTSA review this matter, investigate the delay in recall remedy availability, and take appropriate action to ensure that affected consumers are not required to continue operating potentially unsafe vehicles without a timely repair or interim solution. Thank you for your attention to this serious safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car went in for recall. Ford replaced engine because they claim a bolt broke. I have taken the car about 300 miles since I received it back and the engine light appeared. I let them know. Light went off and I had another important meeting to make in DFW . This time wrench and engine light came on . It sat at airport for 2 days. Then I got back in , no warning lights on but I got home with more warnings then. Engine was super hot and making humming noise. The next day warning light again. I took videos and called Ford . They have refused to help me. I just had a new engine installed because of a recall.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed and coming to a stop, the vehicle shuddered. No warning light was illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but confirmed that parts were not yet available. The failure mileage was approximately 96,000.

Complaint Summary: My 2019 Ford EcoSport has experienced repeated failures of a known recall-related engine defect. The engine was replaced once due to the recall, and less than a year later the same defect occurred again. The vehicle stalled on the highway, creating a serious safety hazard. Despite multiple recall repairs, the defect persists. Ford denied my buyback request without proper review. I am requesting NHTSA investigation into the effectiveness of this recall remedy. Have had two failed attempts under this recall to correct the situation, which is putting me and my family at risk. This is especially concerning because my special-needs son travels with me in the vehicle.