2020 FORD ECOSPORT Complaints

Teenage was driving home from school when the oil pump failed and the engine stalled out cause lost of power to the car and would not start back up she could of been seriously injured if it was not for being right next to a driveway when it happened. This is all over the Internet about how the engine is destroying itself from the inside out. Cannot believe there has not been a recall on this.

The contact owns a 2020 Ford EcoSport. The contact stated that while his daughter was driving out of a parking lot, the low oil pressure warning light illuminated, and the engine made an abnormally loud sound. The contact's daughter parked the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE23015 (Engine and Engine Cooling). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 78,000.

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at undisclosed speeds, the check engine warning light illuminated. The vehicle was taken to the local dealer, where the PCM was reset. The vehicle was repaired, but the failure recurred. The contact stated that while driving at approximately 35 MPH, the oil light illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the oil pump had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 84,000.

Only July 8, 2023 I was driving 75MPH in a 75MPH zone approximately 200 miles from home when I received a warning on my dash "change oil soon." I pressed OK to dismiss the alert. Immediately after my oil pressure light came on, and my check engine light. The car started to sputter and I lost power. On the highway, far from home my children and I suddenly had no power and were in danger. I was scared and had the car towed at my expense to the closest dealership. Here I was told the engine needed to be replaced because of a known issue with the tensioner belt in these engines. My engine was seized. I have been without a car since that date.

Oil pump failure causing entire motor to need to be replaced. Motor failed at 60,400 miles just outside of warranty while going down the interstate at 70 miles an hour. Ford has offered to do nothing with the repair and the engine is on back order for 6 months. This is a know issue already under investigation by the NHSTA and i want to add my case.

Received a low oil pressure notice, followed by a bangining sound and a check engine light. Towed it to a dealership and was informed I needed a new motor due to my oil pump failing

Driving down the road and Low Oil Pressure Light comes on car loses all power had to coast to try to get off the road got to a stop. The ford app shows power train malfunction ended up having it towed to a Ford dealership

Vehicle had oil change prior to oil change date/miles, drove vehicle less than 2 miles away from Oil shop. low oil pressure light turned on. Was unable to drive it back home. Was taken to ford dealership and was notified I need a new engine due to "metal shavings found in engine"

I have a 2020 Ford EcoSport that was 3 years old and had 84000 miles on it. As I was driving down the highway I lost all oil pressure and the engine seized up. As I was 47 miles away from home I became stuck in the side of the road upon taking it to a local mechanic they reported the oil pump chain has failed and the entire engine will need to be rebuilt. The car had had all usual repairs and maintenance and regular oil changes

My 2020 Ecosport with 25k needed the rear differential replaced because the clutch coupling locked causing a grinding noise in the rear. The car was unsafe to drive and the rear axle assembly needed replacement.