2020 FORD ECOSPORT Complaints

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the check engine and low oil pressure warning lights illuminated. The vehicle was taken to the dealer. The vehicle was diagnosed with an engine failure. The engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.

Was driving my vehicle 2020 Ford EcoSport, engine blew due to oil pump being internally belt driven and submersed in oil. It caused the belt to decay and plug my uptake which brings oil to the top of the engine. Paid for a tow to the nearest dealership after my vehicle failed driving 75 on an interstate down a mountain to Phoenix AZ. Lights went off and a low oil pressure light came on and the vehicle and in to limp mode and would not accelerate. It took the dealer a month to figure out and resolve my issue but over 2 months to get my car repaired and back to me. Ford accepted some responsibility and assisted in laying 60% of a $7,000 bill. This happened 2/8/2023. Got my car back end of April 2023 and within in the first month check engine light returned. Brought it to a dealer in Flagstaff AZ and discovered a sensor had gone bad (cam shaft sensor) and I paid over $209 for that to be completed and the previous dealer reinstalled my subframe incorrectly when they replaced the engine. Fast forward to yesterday 10/10/23 and I’m in my car with my new engine with less than 10,000 miles on it. I try to accelerate to highway speeds and check engine light comes on with a “see manual message” and it goes in to limp mode with no way to accelerate. I safely drove it 2 miles to the nearest Ford dealer in Lake Havasu AZ and was informed that my engine was blown once again due to a failed oil pump. I still owe on this car and it’s cost me so much money in repairs and rental cars and I’m going belly up financially because of it: huge safety issue and a terribly flawed engine design. It should never have been sold.

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed and going downhill, she briefly felt the vehicle jerk. The vehicle returned to normal functionality, but the failure had since become a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 26,000.

Going 55 mph down a local 2 lane road, I received a low oil pressure warning followed by loud knocking of the engine. I had to stop the car and have it towed home. Car has 76,000 miles on it and the oil level is perfect. Dealership blames oil pump failure, resulting in a new engine. Seems to be a reoccurring issue with the EcoSports

Low oil pressure light came on within minutes before total engine failure. This happened almost 1 month ago and is currently at an independent service contractor being repaired, requiring total engine replacement.

Engine blown while driving on freeway with child. No prior error lights on dash. Mechanic stated due to internal failure of oil belt, which frayed and exploded into engine. Car received all regular required maintenance & was inspected at oil change 60 days ago with no issues reported. Have diagnostic stating manufacturing failure.

Loss of engine oil pressure at highway speed causing engine and turbo failure. Vehicle is being repaired at dealer under warranty but it has been months and I’ve had no assistance with a vehicle replacement

On 9/23, the vehicle was traveling on !-94 in SE Michigan when it suddenly lost power. The vehicle had to be towed to a service center. The mechanic stated that the oil pump had failed, causing the engine to completely fail. The car was 3 years old, with 67.000 miles. Oil changes had been performed every 5K miles since the car was purchased. Because we did not purchase the ESP, we are now looking at $8K-$10K to get this fixed - we have no idea what to do. it needs a new engine.

I was driving the vehicle to work and after about 15 minutes of driving it, the low oil pressure light came on and started to lose speed. I was on a highway and had cars behind me and wasn't sure what to do. I attempted to speed up so I could pull over at a gas station, but I was not able to go above 20 mph. I had to quickly pull over to the side of the road. After a few minutes, I attempted to get back on the road to reach a gas station near by, but was not able to get above 15-20 mph. I put my flashers on and attempted to make it to the gas station and finally made it and called a tow truck. I had to call in to work that day. The car was towed to our home and I called our local Ford dealer to make an appt to check it out. I was not able to get a service appt for 3 months! I had tobhave the vehicle towed to the dealership and they told me the oil pump was bad and I would need to have the engine replaced and it would cost me $6,000. It's ridiculous to have a car for 3 years and 64,000 and have to replace the engine!!! This conveniently happened right after the warranty ran up. I had just had the turbocharger replaced and the vacuum pump a couple minutes prior to the low oil pressure issue! No reason this should happen on a 3 year old car that has had the maintenance kept up on it.

While driving it’s dropping rpm’s. It feels like it’s going in and out of gear while driving and even does it in cruse. While switching gears on take off it jerks each gear like it’s struggling. Rpm’s jump 500/1000 all the time even at idol.