2004 FORD ESCAPE Complaints

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT ACCELERATOR PEDAL WAS DEPRESSED BUT THE ACCELERATOR PEDAL WENT TO THE FLOORBOARD, AND THE VEHICLE FAILED TO ACCELERATE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE ACCELERATOR CABLE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 04V574000 (VEHICLE SPEED CONTROL), BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,400.

RIGHT REAR FENDER WELL RUSTED AWAY SHOWING INSIDE OF TRUNK LINER AND MAKING LOUD BANGING NOISES

SHOCK FRAME SUPPORT ON RIGHT REAR SIDE COMPLETELY RUSTED OUT MAKING VEHICLE UNSAFE TO DRIVE ALONG WITH ENTIRE AREA RUSTING OUT PREMATURELY. I CAN SEE THE OUTSIDE THRU MY SPEAKER GRILL. HOW COULD THIS NOT BE A SAFETY RECALL WHEN IT IS CLEARLY A FORD DEFECT? REPAIR QUOTES IN THE $2000- $2500 RANGE.

OUR 2004 FORD ESCAPE IS MAKING METALLIC CREAKING, SQUEAKING AND GROANING SOUNDS FROM THE PASSENGER SIDE REAR. THE SOUND IS TRIGGERED BY JUST SITTING IN THE STATIONARY CAR AND ROCKING BACK AND FORTH. IT BECOMES CONSTANT AS SOON AS THE VEHICLE STARTS MOVING. THERE ARE ALSO OCCASIONAL HEAVY METALLIC THUMPS OR KNOCKS ON THE PASSENGER SIDE OR UNDERSIDE OF THE CAR, AND THE RIDE IS ROUGH. THE PASSENGER SIDE REAR INNER METAL WHEELHOUSE IS EXTREMELY RUSTY. A FEW HOLES ARE SEVERAL INCHES SQUARE & GO ALL THE WAY THROUGH INTO THE INTERIOR OF THE CAR. PART OF THE RUST IS VERY NEAR WHERE THE TOP OF THE SHOCK ABSORBER BOLTS INTO THE WHEELHOUSE. THE WHEELHOUSE METAL IS SO RUSTY THAT I CAN FLEX IT WITH MY HAND AND CAUSE THE CREAKING SOUNDS. I BELIEVE THE HEAVY METALLIC THUMPS ARE CAUSED WHEN THE CONICAL BUMPER INSIDE THE TOP OF THE SPRING BOTTOMS OUT AND HITS THE SUSPENSION MOUNTED TO THE BOTTOM OF THE SPRING. THIS LIKELY HAPPENS BECAUSE THE SHOCK ABSORBER CANNOT STOP IT, SINCE THE RUSTY WHEELHOUSE BENDS SO MUCH. THIS SERIOUS SAFETY PROBLEM IS HEAVILY DOCUMENTED ON THE INTERNET BY A VERY LARGE NUMBER OF PEOPLE. THE TOP OF THE SHOCK ABSORBER COULD CRASH THROUGH THE WHEELHOUSE AND PROTRUDE INTO THE CAR INTERIOR, INJURING OCCUPANTS OF THE CAR. THIS WOULD MAKE LOSS OF CONTROL MORE LIKELY. IT WOULD BE EXTREMELY DANGEROUS IF THE SHOCK ABSORBER BREAKS FREE AND BECOMES TANGLED UP WITH THE REAR WHEEL OR PUNCTURES THE TIRE. THIS CAR IS A UNIBODY CONSTRUCTION, SO THIS WHEELHOUSE IS SUPPOSED TO PROVIDE STRUCTURAL STRENGTH FOR THAT PART OF THE CAR. IN THE EVENT OF A CRASH THIS RUSTY WHEELHOUSE WILL DISINTEGRATE AND NOT PROPERLY ABSORB THE CRASH ENERGY LIKE IT IS SUPPOSED TO. THIS MAKES IT MORE LIKELY THAT THE OCCUPANTS WILL GET INJURED. PLEASE FORCE A VEHICLE RECALL ASAP WHICH MAKES FORD MOTOR CO. REPLACE THIS DANGEROUS WHEELHOUSE WITH ONE THAT HAS A SAFER, NON-RUSTING DESIGN.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEATBELT ALARM PRE-TENSIONER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 45 MPH, A LOUD BANGING NOISE WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER WHEEL WELL, AND THE SHOCK ABSORBER TOWER WERE SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 144,000.

WE OWN A 2004 ESCAPE. THAT TWO WEEKS AGO CAUGHT FIRE DUE TO THE ABS CONTROL MODULE. WE ALSO HAVE HAD BRAKE LINES GO BAD DUE TO PART FAILURE TWICE. AND THE TOTAL OF THREE ALTERNATORS. NOW WE HAVE SPOKEN TO FORD REGARDING THE 01-03 FIRE ISSUE. BUT THEY WILL NOT DO ANYRHING TO CONSIDER THE 04 EVEN THOUGH IN RESEARCHING THE ACTUAL RECALL IT WAS THE SAME ISSUE. I WOULF LIKE TO SEE THIS HAPPEN. WE ARE SELLING OUR VEHICLE TO THE SEALER SUE TO LACK OF RELIABILITY. BUT WANTED TO VET THE WORD OUT ON THIS ISSUE. OUR ENGINE ALSO IDLE AND TRIES TO PULL THE VEHICLE FORWARD EVEN WITH THE BRAKES APPLIED. THIS IS DUE TO A FAULTY IDLE AIR CONTROLL VALVE.

2004 FORD ESCAPE. REAR RIGHT WHEEL HUB RUST/CORROSION AROUND STRUT ASSEMBLY. SAFETY ISSUE WITH REAR SHOCK. KNOWN PROBLEM WITH 2004 TO 2006 FORD ESCAPE DESPITE RUST PROOFING. RUSTS AROUND AREA FOR STRUT LEADING TO STRUCTURAL COMPROMISE OF THIS ASSEMBLY. UNSAFE TO DRIVE.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED OVER A BUMP IN THE ROAD, THE VEHICLE EMITTED A CLUCKING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHICH INDICATED THAT THE FRONT SUSPENSION BAR WAS FRACTURED. THE FRONT SUSPENSION BAR WAS REPLACED. THE CONTACT ALSO STATED THAT THE BRAKE LINES ALSO FAILED DUE TO CORROSION. THE BRAKE LINES WERE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 125,715. ..UPDATED 02/01/16 *BF *JS