2020 FORD ESCAPE Complaints

The contact owns a 2020 Ford Escape. The contact stated while opening the front driver’s side door the contact felt the door falling off the hinge. When the contact entered the vehicle and attempted to roll down the window, the window failed to roll down. The vehicle was taken to the dealer and stated that the front driver’s side door was defective and needed to be repaired. The vehicle was repaired. On another occasion while opening the front passenger’s side door, the contact heard a popping sound coming from the door. The vehicle was taken to the dealer again and the contact stated the that the door was defective, and that the door needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that a half of the repair cost would be covered. A case was filed. The failure mileage was 38,000.

The contact owns a 2020 Ford Escape. The contact stated the welds fractured on the front driver’s side door. The contact stated that the front driver’s side door and window failed to close properly. The contact took the vehicle to the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 37,800.

The inside wheel boot fills with water and boot liner gets moldy causing breathing issues. It is apparently a known issue and Ford has no resolution. I also have a driver's side window that has issues since the day I bought and all the Ford dealership quick fixes has not resolved the issue. They reset the up/down of the windows and it keeps going out of alignment so that when then window is pushed up it overshoots the sensor and comes back down.

At about 30,000k miles, began to hear a creak/pop sound when opening and closing the front d/s door. This past weekend, at about 30,075 miles, there was a loud noise when opening and closing the door, and noted that 3 spot welds appear to have popped and pulled through the sheet metal. These held the safety 'check arm' in place inside the door. In researching the matter, I located that you already have this noted (SSM 50150) on vehicles with high usage profiles. I am a regular driver. This is NOT a fleet vehicle. I'm lucky in that the car is under warranty and will hopefully be repaired with zero costs, HOWEVER, this is nothing that any Ford Escape owner should have to deal with, at all, through the LIFE of the vehicle. Furthermore, the same spot welds and check arm apparatus appears to be used on the other car doors, so my guess is that this too can pose an issue. Ford should honor these repairs well beyond any bumper to bumper warranty period, as well as disclose IF the replacement door is using an improved weld or fastening system. ***!!! THIS IS A SAFETY ISSUE because without the arm check functioning properly the door can fly into passing or oncoming traffic unexpectedly, causing injury to the driver of the Escape and/or any oncoming vehicle that slams into said failing door assembly which could result in the loss of control of their vehicle!!! *** My car is in the shop now where I hope this will be part of a covered claim to document. Apparently, I may have to wait months for new front door assembly.

Driver door detached from body by normal opening the door. The window is unable to lower down and the door is unable to be opened and closed. It seemed the door was attached by three small welded spots which seemed unsecured due to the doors natural weight.

The contact owns a 2020 Ford Escape. The contact stated that he noticed six holes and one large crack located on the front driver’s side door. The contact then stated that the weld hinges had also cracked. The vehicle was taken to the dealer where it was diagnosed that the top center hinge had fractured from the spot weld and needed to be replaced. The contact was then advised to take the vehicle to an auto repair shop for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was not covered under warranty. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 47,767.

The driver side door pops and cracks when opened and is difficult to open and close now. I am concerned that I will not be able to open or close, and if I cannot close my door I cannot put the car into gear so I am concerned that there will be multiple different opportunities to leave me stranded. I have pictures of both driver side and passenger side doors showing that the weld on the driver side door are all broken off. I cannot afford to fix this problem myself and also it is nothing that I have done to this vehicle to cause this problem.

The contact owns a 2020 Ford Escape. The contact stated that the weld on the driver's side front door had fractured. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was determined that the door weld check unit had fractured. The vehicle was not repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 60,000.

Drivers door began making a clunking/popping/scratching noise when opening without incident or cause. Window will only roll down approximately 4 inches. No warning lamps or messages present. The noise and the metal on metal feeling when opening or closing is getting worse and the door is getting harder to close. I am worried it may fall off at anytime, or if it is repaired that it will be replaced with the same defective materials and will happen again at anytime. It may be inspected on request.

Vehicles driver door check arm failed and it appears to have detached. A loud popping sound can be heard. Occurred at 64,500 miles. No collision and no inappropriate use.