2020 FORD ESCAPE Complaints

The contact owns a 2020 Ford Escape. The contact stated that upon opening the driver's side, the door fractured. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the spot weld on the driver's side door had fractured from the inside. The vehicle was not repaired. The manufacturer was contacted and provided a case number. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 39,976.

Front Driver side door, door check is broken. Issue identified by dealership after taking it for evaluation. Per dealer, entire door needs to be replaced.

Door welds broke. Ford is refusing to assist in covering. Repair shop is saying this is fords responsibility and a defect.

drivers door started making a grinding metal on metal noise and no longer able to lower drivers window. took vehicle to local ford dealer for known recall and mentioned problem to service writer. 30 minutes later was told to pick up car drivers door problem requires door replacement by a collision shop for broken welds in door and recall part is back ordered 2-3 months. Googled door problem and see it is a well known manufacturing defect in this model. Problem makes it difficult to pay tolls, use a parking ramp, or anything that requires opening window without exiting vehicle.

I bought the car in February, 2021. 11 months later the rear shocks had both failed and were replaced by dealer on 01/13/2022, at 9572 miles. One year later the shocks have again failed! Ford has refused to cover them under warranty, claiming that shock failure in one year is normal wear. This is a severe safety issue that affects vehicle handling and it needs to be addressed.

The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I heard a series of loud pops coming from the vicinity of my driver door hinges, while inside the vehicle with the door closed, over the course of several days. I could not identify exactly where they came from until the driver door stopped operating properly. Upon inspection I could see several small holes in the front inside edge of the driver door and after comparing them to the passenger side door they were clearly the location of spot welds holding the check arm inside the door. I took the vehicle to the dealer and was informed that they expected me to pay out of pocket to repair this obvious material defect. I then contacted Ford Customer Relations and was again informed that Ford would offer no remedy for this problem. The complaint number assigned by Ford is CAS-42808154-Y3S6L2. This is a clear safety concern because my driver door no longer operates correctly. The driver window also no longer operates. The door swings wildly without the stability of the check arm and often fails to latch properly when closing. As of the time of filing this complaint, I have not conducted any repair of the defective door because I cannot afford to do so at this time. This means that the problem is still completely available for inspection should anyone desire to do so.

The weld spots inside the drivers side door control arm snapped resulting in the door barely being usable

The contact owns a 2020 Ford Escape. The contact stated while attempting to shift into drive, the gear selector failed to shift out of park. There was no warning light illuminated. The vehicle was towed to the dealer and the shifter cable was replaced; however, the failure reoccurred. The vehicle was not diagnosed. The dealer was contacted and stated that the vehicle needed to be diagnosed. The manufacturer was contacted, and a case was filed. The contact was informed that the vehicle needed to be diagnosed. The failure mileage was 44,447.

The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.