2002 FORD ESCAPE Complaints

MY COMPLAINT IS ABOUT THE MASTER CYLINDER AND THE REAR DOOR LATCH. I CALLED THE FORD DEALER AND COMPLAINED ABOUT MY MASTER CYLINDER LEAKING, THEY TOLD ME THAT RECALL WAS ALREADY PERFORMED ON MY VEHICLE IN 2012. I WANTED TO KNOW WHY WOULD MY MASTER CYLINDER BE LEAKING AGAIN TWO YEARS LATER? I WONDER IF THIS JOB WAS EVER DONE. I DON'T FEEL THAT THE CUSTOMER SHOULD HAVE TO PAY FOR A JOB THAT WASN'T PERFORMED. MY OTHER COMPLAINT IS MY REAR DOOR LATCH. I WENT TO THE DEALER AND TOLD THEM THAT I WAS HAVING A PROBLEM WITH MY REAR DOOR LOCKING AND OPENING. THE SERVICE DEPARTMENT TOLD ME I HAD TO PAY FOR THIS SERVICE. NOW I SEE THERE WAS A RECALL ON THE REAR DOOR LATCH BUT I WAS NOT INFORMED ABOUT THIS RECALL NOR DID I RECEIVE A RECALL LETTER. I WANT TO KNOW HOW I GO ABOUT HAVING THESE SERVICES COMPLETED. *TR

NEIGHBOR WOKE ME SAYING MY CAR WAS ON FIRE. CAR WASN'T ON, THE KEY WAS NOT IN, AND IT HAD SAT OVERNIGHT. CALLED FIRE DEPARTMENT AND FIRE PUT OUT. CAR IS TOTALED BECAUSE THE FIREMEN HAD TO BREAK INTO THE ENGINE COMPARTMENT. ENGINE AREA BURNED WITH NOTHING BUT METAL VISIBLE AND A MELTED BATTERY. I HAVE PICTURES. *TR

TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE TRAVELING 25 MPH, THE FRONT LOWER CONTROL ARM FRACTURED AND THE WHEEL DETACHED FROM THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT INDICATED THAT THERE WAS RUST ON THE FRONT END OF THE LOWER CONTROL ARM AND THE SUBFRAME. ALSO, THE SUBFRAME WAS RUSTED THROUGH ON THE FRONT PASSENGER SIDE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO REPLACED THE FRONT LOWER CROSS MEMBER AND THE FRONT SUBFRAME. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE: BODY). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,145. UPDATED 01/23/15*LJ UPDATED 6/3/2015 *JS

TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED FIFTEEN TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH ON UNEVEN PAVEMENT, THE STEERING WHEEL SUDDENLY TURNED APPROXIMATELY 45 DEGREES TO THE RIGHT. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE PASSENGER SIDE SUBFRAME WAS RUSTED AND CORRODED, WHICH CAUSED THE LOWER CONTROL ARM TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,900.

THE CABLE CONNECTIONS FOR THE PASSENGER SIDE FRONT AIRBAG IS FAULTY CAUSING THE AIRBAG SENSOR LIGHT TO COME ON OCCASIONALLY INDICATING THAT THE CONNECTIONS ARE LOSE. THIS HAPPENS ESPECIALLY IN COLD WEATHER. I DID SOME RESEARCH ON THIS ISSUE. THIS ISSUE HAS BEEN REPORTED BY MANY FORD OWNERS. THE DEALERSHIP WANTS TO CHARGE $300 TO REPLACE THE CABLING, BUT THE ISSUE IS WITH A $30 CONNECTOR UNDER THE SEAT. *TR

TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V165000 (POWER TRAIN). WHILE DRIVING IN REVERSE, THE VEHICLE LOST POWER AND STALLED. WHEN DRIVING IN HOT WEATHER OR AFTER A CERTAIN AMOUNT OF TIME, THE VEHICLE WOULD STALL IN THE MIDDLE OF TRAFFIC. A MECHANIC STATED THAT THE PCM/TCM POWER TRAIN NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

FUEL TANK STRAP HAS CORRODED AND BROKEN AND THE FUEL TANK COULD FALL OUT OF THE VEHICLE AND RESULT IN A FUEL SPILL AND/OR FIRE. THERE IS ALSO A RUST HOLE IN THE FUEL TANK METAL PROTECTIVE COVER THE SIZE OF MY HAND AND THE FUEL CELL IS EXPOSED. HAVE NOTIFIED FORD AND THEY DECLINED TO REMEDY THE PROBLEM CITING THERE IS CURRENTLY NO RECALL. FORD HAS ALSO TOLD ME IT IS NOT SAFE FOR ME TO CONTINUE TO DRIVE THE VEHICLE. I HAVE TAKEN PHOTOS OF CORRODED PARTS WHICH I WILL SUBMIT UPON REQUEST TO MY EMAIL ADDRESS WHICH IS : [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY CAR IS INCLUDED IN THE RECALL FOR THE RUSTED OUT SUBFRAME. IT HAS AT LEAST 2 OBLONG RUSTED OUT HOLES NEAR THE CONTROL ARM. IT WAS TAKEN TO THE DEALER. THEY INSTALLED A CROSS BRACE. 3 DIFFERENT DEALERS TOLD ME THE BRACE WILL HOPEFULLY, IF I AM LUCKY, HELP ME PULL OVER WITHOUT CRASHING WHEN (NOT IF) THE SUBFRAME GIVES AWAY AND THE CONTROL ARM FALLS OFF. TWO OF THE THREE LITERALLY TOLD ME, "GOOD LUCK." I FEEL IF FORD REALIZES THE ISSUE IS SERIOUS ENOUGH FOR A RECALL THEY SHOULD PROPERLY FIX THE PROBLEM. *TR

ON AUGUST 26, 2014, I WENT TO FAIR OAKS FORD LINCOLN DEALERSHIP SERVICE IN NAPERVILLE, ILLINOIS FOR SAFETY RECALL NOTICE 14S02 / NHTSA RECALL 14V-165 REPAIRS, AND I ASKED THEM TO CHECK AN ISSUE WHERE WHEN BRAKES ARE APPLIED, THERE IS A SCRAPING/GRINDING NOISE, FOLLOWED BY A KNOCKING NOISE, WHICH CAN AFFECT RELIABLE STOPPING AND THE VEHICLE STEERING STABILITY. SAFETY RECALL REPAIRS WERE COMPLETED, THEN IT WAS REPORTED THAT THE MECHANIC "PUSHED BACK" THE VACUUM PLATE COVER FOR THE ROTOR ON THE DRIVER'S SIDE TO RESOLVE THE SCRAPING/GRINDING/KNOCKING ISSUE WHEN APPLYING THE BRAKES. THE ISSUE WITH THE BRAKING ACTION AND SUBSEQUENT NOISES AND RESPONSE OF VEHICLE EXHIBITED ITSELF AGAIN BY THE SECOND STOPLIGHT AWAY FROM THE FAIR OAKS FORD DEALER LOCATION. TWO DAYS LATER, ON AUGUST 28, 2014, I TOOK MY 2002 FORD ESCAPE TO GEARHEAD AUTO SALES & REPAIR IN GLEN ELLYN, ILLINOIS FOR AN INSPECTION AND REPAIR COST ESTIMATE. ON THE LIFT, THE ISSUE WAS APPARENT TO THE MECHANIC AT GEARHEAD TO BE THE RIGHT FRONT AXLE BEING FAULTY, AND HE REPLACED THE RIGHT FRONT AXLE, WITH BOOTS, CLAMPS AND GREASE. MY ISSUE IS THAT THE FORD DEALER MECHANIC INSPECTED AND REPAIRED MY VEHICLE FOR THE FORD SAFETY RECALL NOTICE 14S02 / NHTSA RECALL 14V-165 IN THE SAME PROXIMITY ON THE PASSENGER SIDE OF THE VEHICLE WHEN IT WAS ON THE LIFT, BUT HE FAILED TO FIND AND REPORT THE EASILY SEEN FAULTY RIGHT FRONT AXLE PROBLEM THE GEARHEAD MECHANIC PROMPTLY REPORTED TO ME. INSTEAD, THE FORD REPRESENTATIVE FALSELY POINTED TO THE DRIVER'S SIDE FRONT BRAKE ROTOR VACUUM PLATE BEING OUT OF PLACE AS BEING THE ISSUE CAUSING THE SCRAPING/GRINDING/KNOCKING NOISE WHEN APPLYING THE BRAKES. IS THERE ANY TIE TO THE "CORROSION-RELATED SEPARATION" SAFETY RECALL ISSUE THAT LED TO THE FAULTY RIGHT FRONT AXLE CONDITION? SINCE MY UNEMPLOYMENT OVER THE PAST 3 YEARS, MY FORD ESCAPE HAS RARELY BEEN DRIVEN, AND ONLY IN MY LOCAL AREA. *TR