2001 FORD ESCAPE Complaints

ON OR AROUND APRIL 15, 2005 MY 2001 FORD ESCAPE VIN [XXX]SUNROOF BEGAN TO MALFUNCTION. THAT IS, THE ROOF DID NOT MOVE FORWARD OR BACKWARD. I TOOK THE VEHICLE TO MY LOCAL FORD DEALER TO DETERMINE THE PROBLEM. THE SERVICE ADVISOR NOTIFIED ME THAT THE RACK FORD PART NUMBER [XXX]WOULD HAVE TO BE REPLACED. I FEEL THAT WITH SUCH LITTLE USE (MAYBE A TOTAL OF 3 HOURS OVER 4 YEARS) THIS FORD PART SHOULD NOT HAVE GONE BELLY UP. IN MY OPINION, UNDER NORMAL USE, THIS PART SHOULD NOT NEED TO BE REPLACED IN SUCH A SHORT TIME WITH SUCH LITTLE USE. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DT: ON THE LEFT FRONT WHEEL OF THE VEHICLE THEIR IS NOISE COMING FROM THE AXLE. THERE IS A LOT OF MOVEMENT IN THE BRAKE PEDAL, AND THE VEHICLE PULLS TO LEFT. *NM *SB

I AM THE ORIGINAL OWNER OF A 2001 FORD ESCAPE XLT V6, 4 WHEEL DRIVE. MY TRUCK CURRENTLY HAS 75000 MILES OF USE. I FEEL THE INCIDENT I CHOSE TO WRITE ABOUT IS A SIGNIFICANT SAFETY ISSUE AS IT INVOLVES A MALFUNCTION OF THE ANIT-LOCK BRAKING SYSTEM (ABS) WHICH SIGNIFICANTLY REDUCES BRAKING ACTION (ON DRY PAVEMENT!) WHEN IT OCCURS. I AM ALSO AWARE OF AT LEAST TWO OTHER FORD ESCAPE OWNERS THAT HAVE EXPERIENCED THE SAME FAILURE. THE FAILURE CAUSES THE ABS TO ACTIVATE ON DRY PAVEMENT, WHEN ABSOLUTELY NO SLIPPAGE IS OCCURRING AT ANY WHEEL. THE ACTIVITY OF THE ABS SYSTEM ACTUALLY SIGNIFICANTLY REDUCES BRAKING CAPACITY AND CAUSES THE BRAKE PEDAL TO GO DOWN NOTICEABLY FURTHER THAN NORMAL WHEN ATTEMPTING TO STOP. ONLY A QUICK AVOIDANCE MANEUVER ALLOWED ME TO AVOID REAR-ENDING THE CAR IN FRONT OF ME. PUMPING THE BRAKES DOES NOT HELP SINCE THE ABS HYDRAULIC CONTROL MODULE IS MODULATING THE BRAKES AT SUCH A RATE, PUMPING THE BRAKE DOES NOT PRODUCE A FIRMER PEDAL. I HAVE TRACED THE PROBLEM TO A FAULTY ABS SYSTEM ROTATION TRANSDUCER DESIGN ON THE FRONT WHEELS OF THE ESCAPE. THE TRANSDUCER IS BASICALLY A SPLINED RING ABOUT 8MM WIDE. THE RING IS APPARENTLY FRICTION FIT ONTO THE HALF-SHAFT NEAR THE FRONT CV JOINTS JUST INSIDE OF THE FRONT HUB ASSEMBLY. A SENSOR APPARENTLY PICKS UP THE PEAKS OR VALLEYS IN THE SPLINED RING AS IT ROTATES PAST THE SENSOR TO DETERMINE WHEEL ROTATION SPEED. IT IS THE SPLINED RING THAT FAILS, MINE ACTUALLY SPLIT ACROSS ITS WIDTH CAUSING IT TO LOOSEN AND MOVE AWAY FROM THE SENSOR. THIS APPARENTLY CAUSES THE ABS SYSTEM TO OPERATE ERRATICALLY AND ACTUALLY CAUSE A SIGNIFICANT REDUCTION IN BRAKING CAPACITY ON DRY PAVEMENT! THIS ERRATIC BEHAVIOR WILL OCCUR 5-10 TIMES BEFORE THE ABS CONTROLLER DETERMINES THERE IS SOMETHING WRONG AND SWITCHES OFF THE ABS SYSTEM. THIS ILLUMINATES THE ABS INDICATOR LIGHT ON THE INSTRUMENT PANEL AND DOES RESTORE NORMAL BRAKING PERFORMANCE. THIS CYCLE WILL REPEAT ITSELF EACH TIME THE TRUCK IS SHUT OFF AND RESTARTED!!

THE O/D LIGHT STARTED FLASHING .I DROVE THE VEHICLE ABOUT 5 MILES TO MY DRIVEWAY.WHEN I WENT TO MOVE THE CAR IT WOULDN'T GO IN REVERSE. CONTACTED DEALER WITH NO RESULTS. SENT CAR TO TRANSMISSION SHOP AND HAD A REBUILT TRANSMISSION PUT IN.

WAS STRUCK IN THE REAR END BY ANOTHER VEHICLE, EVIDENTLY, AFTER THAT THE TWO FRONT HUB BEARINGS WENT BAD. DEALERSHIP STATED IT WAS NOT DUE TO ACCIDENT.*AK

TRANSMISSION FAILURE RESULTING IN UNSAFE OPERATING CONDITIONS. VEHICLE DEVELOPED INTERMITTENT SHUDDER DURING ACCELERATIONS ALONG WITH INTERMITTENT LOSS AND SLIPPING OF FORWARD GEARS. HAZARDOUS CONDITIONS WHEN MERGING WITH TRAFFIC OR UNDER NORMAL DRIVING CONDITIONS SINCE CONDITION WAS UNPREDICTABLE AND VEHICLE DID NOT RESPOND TO DRIVER'S INPUT. APPEARED TO HAPPEN MOSTLY IN COLD WEATHER CONDITIONS. FAILURE ALSO RESULTED IN NON COMPLIANCE WITH FMVSS REGULATIONS SINCE SHIFT LEVER DID NOT CORRESPOND ACCURATELY TO OPERATOR'S INTENDED VEHICLE DRIVING MODE (I.E NO FORWARD MOTION WHEN SHIFT SELECTOR WAS IN DRIVE POSITION). MULTIPLE TECHNICAL SERVICE BULLETINS EXIST FOR THIS CD4E AUTO TRANSAXLE RELATING TO THIS FAILURE MODE IN FORD SYSTEM AND ALSO ON NHTSA WEBSITE, SO CONDITION IS KNOWN AND IS WIDESPREAD ON MANY VEHICLES. CREATED VERY HAZARDOUS DRIVING SITUATIONS BEFORE CATASTROPHIC FAILURE RESULTING IN INOPERATIVE VEHICLE.*AK

WHILE DRIVING AT APPROXIMATELY 35 MPH, ANOTHER VEHICLE WAS TURNING IN FRONT OF CONSUMER'S VEHICLE, CAUSING IT TO SWERVED AROUND THE VEHICLE TRYING TO AVOID AN ACCIDENT. IN THE PROCESS, IT HIT ANOTHER VEHICLE. UPON IMPACT, AIR BAGS FAILED TO DEPLOY. *AK

HISSING NOISE COMING FROM BRAKES. STOPS WHEN I DEPRESS THE BRAKES AND RETURNS UPON TAKING MY FOOT OFF BRAKES. THIS CANNOT BE GOOD. MECHANICS PRETENDED THAT THEY DID NOT HEAR THIS. MUST BE AN EXPENSIVE FIX BECAUSE I HAVE BEEN STONE WALLED. *JB

2001 ESCAPE STALLS REPEATEDLY WHEN STARTING AND WHEN IDLING AT STOP LIGHTS. THIS PROBLEM HAS BEEN INTERMITTENT SO FORD DEALER HAS BEEN UNABLE TO FIX. USUALLY ONLY HAPPENS WHEN THE ENGINE IS HOT. HAS NOT CAUSED AN ACCIDENT YET. THIS IS A 4 CYLINDER MANUAL TRANSMISSION SO IT DOES NOT FALL UNDER THE PREVIOUS RECALL.*AK

NEW FIRESTONE TIRE IN REGULAR PASSENGER VEHICLE USAGE. FOUR DESTINATION LE TIRES P23570R16 PURCHASED AS REPLACEMENTS OF OEM TIRES. WITHIN 10,000 MILES THE SIDEWALL BUBBLES FORMING TWO LARGE BLISTERS ON ONE TIRE. NO EXTERNAL DAMAGE CAUSED THIS CONDITION. FIRESTONE REPLACED THE TIRE. DEFECT WAS LEFT AT THE FIRESTONE OUTLET.*AK