2008 FORD ESCAPE HYBRID Complaints

DRIVING AT 35MPH ABS LIGHT CAME ON THEN CHECK BRAKES FOLLOWED BY BRAKE REGEN DISENGAGED. THIS CREATED NO STOPPING OF VEHICLE AND RUNNING THROUGH STOP LIGHT. FORTUNATELY, THERE WERE NO VEHICLES COMING FROM OTHER DIRECTIONS. STILL NO BRAKES AND APPEARS TO BE A KNOWN ISSUE BY PUBLIC AND FORD.

-VEHICLE ABS (ANTI-LOCK BRAKE SYSTEM) LIGHT CAME ON AND DASH SAID 'CHECK BRAKE SYSTEM' AND 'REGEN BRAKES DISABLED'. THANK GOODNESS I WAS PARKED WHEN THE ISSUE OCCURRED AND WHEN I TRIED TO DRIVE AWAY, I WAS ABLE TO TEST THE BRAKING ABILITY AND QUICKLY TURNED THE CAR BACK OFF. -GRINDING NOISE WHEN DEPRESSING THE BRAKE PEDAL. SOUND CAME FROM FRONT OF CAR AFTER CAR WAS TURNED OFF -WAS ABLE TO START CAR PROPERLY AFTER 4+ ATTEMPTS AND WAITING 15-20 MINUTES -THIS WAS AN INTERMITTENT PROBLEM THAT COULD HAVE REOCCURRED AT ANY TIME (EXTREMELY DANGEROUS) -CONTACTED THE MANUFACTURER (FORD) TO EXPLAIN THE ISSUE AND HOW (AT THE TIME) THERE WERE 80+ SIMILAR ISSUES REPORTED TO NHTSA. -COST QUOTES RANGED FROM $4,800-$7,000 TO REPLACE HCU (HYDRAULIC CONTROL UNIT), MASTER CYLINDER, ABS MODULE REPLACEMENT -THIS IS A MANUFACTURER'S DEFECT IN THE BRAKING SYSTEM (DTC C1478) AND EXTREMELY DANGEROUS. VEHICLE SHOULD BE RECALLED -WHEN CONTACTED, FORD DID NOT OFFER ANY ASSISTANCE AND SEEMED TO NOT CARE ABOUT THE ISSUE -- I WILL NEVER BUY ANOTHER FORD AGAIN -FORD WAS AWARE OF ISSUE (SSM 45870) AND CHOSE TO DO NOTHING ("SOME 2005-2008 ESCAPE/MARINER HYBRID VEHICLES MAY EXPERIENCE THE ABS WARNING INDICATOR ILLUMINATED WITH THE FOLLOWING DIAGNOSTIC TROUBLE CODES (DTCS) C1478, C1479, C1480 OR C1481. REFER TO WORKSHOP MANUAL (WSM), SECTION 206-09 INSPECTION AND VERIFICATION PROCEDURE UNDER DIAGNOSIS AND TESTING. IF NO FAULTS ARE IDENTIFIED WHILE PERFORMING THE INSPECTION AND VERIFICATION PROCEDURE AND BEFORE REPLACING THE ABS HYDRAULIC CONTROL UNIT (HCU) VERIFY THE CALIPER FLEX HOSES ARE THOROUGHLY INSPECTED FOR DAMAGE, INTERNAL RESTRICTIONS OR SWELLING. DAMAGED CALIPER FLEX HOSES CAN GENERATE THESE PRESSURE CONTROL PLAUSIBILITY DTCS.")

TL* THE CONTACT OWNS A 2008 FORD ESCAPE HYBRID. WHILE DRIVING APPROXIMATELY 75 MPH, THE CONTACT NOTICED A RATTLING NOISE EMERGING FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO METRO FORD (5422 WAYNE TERR, MADISON, WI 53718) WHERE IT WAS DETERMINED THAT THE ENGINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.

DRIVING MY CAR AND THE ABS AND BRAKE WARNING LIGHT CAME ON AND BRAKES FAILED TO WORK PROPERLY. PAUL MILLER FORD OF LEXINGTON KY.SAID I NEEDED TO REPLACE NCU AND MASTER CYLINDER AT A COST OF $9000. THERE HAS BEEN NUMEROUS COMPLAINTS I'VE DISCOVERED AFTER RESEARCHING THIS PROBLEM. THE CAR IS STILL AT THE DEALER SO I DON'T HAVE PAPER WORK YET.

TL* THE CONTACT OWNS A 2008 FORD ESCAPE HYBRID. WHILE THE CONTACT'S SON WAS DRIVING AT AN UNKNOWN SPEED, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO HEARD AN ABNORMAL NOISE. THE CONTACT WAS ABLE TO STOP THE VEHICLE AFTER DEPRESSING THE BRAKE PEDAL MULTIPLE TIMES. THE CONTACT STATED THAT THE EMERGENCY BRAKE, CHECK BRAKE SYSTEM, AND ABS WARNING INDICATORS WERE ILLUMINATED. THE CONTACT STATED THAT THE REGENERATIVE BRAKES DISABLED WARNING MESSAGE WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ABS MODULE NEEDED TO BE REPLACED. THE CONTACT CALLED NEWINS BAY SHORE FORD (219 W MAIN ST, BAY SHORE, NY 11706, (631) 665-1300) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 90,500. *AS CONSUMER NO LONGER OWNS THE VEHICLE.*JB

112,000 MILES WHILE DRIVING, VIBRATION FROM RIGHT FRONT OF VEHICLE. ABLE TO STOP. CHECK ENGINE AND BRAKE WARNING LIGHTS. REGENERATIVE BRAKE DISABLED. VEHICLE TO DEALERSHIP WITH DTC - C1480. INTERNAL FAILURE OF THE HYDRAULIC CONTROL UNIT FOR THE ABS. COST OF REPAIR OVER $5000 FOR HYBRID SPECIFIC REPLACEMENT PART NUMBER 2C286. NUMEROUS REPORTS OF THE PART FAILING ON INTERNET AND THIS SITE. WITH THE PRICE THE HCU QUOTED TO BE $4700, I JUST THE REST OF THE PARTS IN THIS VEHICLE MUST BE REALLY INEXPENSIVE (CHEAP) GIVEN THE ORIGINAL $28,000 PRICE TAG.

I HAD ALL THE BRAKES STUCK WHILE DRIVING. ABS AND BRAKE WARNING LAMP WENT OFF ALONG WITH REGEN BRAKES DISABLED. MECHANIC`S DIAGNOSIS WAS ABS PUMP AND CONTROL MODULE NEED TO BE REPLACED. COST ABOUT 4500$ TOTAL.

TL* THE CONTACT OWNS A 2008 FORD ESCAPE HYBRID. WHILE DRIVING, THE ANTILOCK AND SERVICE BRAKE WARNING INDICATORS ILLUMINATED. ALSO, WHEN THE BRAKE PEDAL WAS DEPRESSED, IT TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HYDRAULIC CONTROL UNIT FAILED AND NEEDED TO BE REPLACED. THE CONTACT CALLED RAY SKILLMAN FORD AT (317) 884-7164 (LOCATED AT 1250 US-31, GREENWOOD, IN) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

ABS LIGHT ON - BRAKES WORK MOST OF THE TIME, BUT NOT RELIABLE. REGEN LIGHT ALSO ON. THE PROBLEM OCCURS INTERMITTENTLY, ALMOST ALWAYS SHORTLY AFTER STARTING THE VEHICLE. ON 2 OCCASIONS IT OCCURRED WHILE DRIVING ON THE INTERSTATE AND FORCED THE VEHICLE TO SLOW TO 20MPH.

TL* THE CONTACT OWNS A 2008 FORD ESCAPE HYBRID. WHILE DRIVING 35 MPH WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE FAILED TO COME TO A COMPLETE STOP. THE BRAKE AND ABS WARNING INDICATORS ILLUMINATED. IN ADDITION, THE CHECK BRAKE SYSTEM AND SYSTEM REGEN BRAKE DISABLE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED, BUT THE CONTACT WAS UNABLE TO SPEAK WITH A REPRESENTATIVE. THE FAILURE MILEAGE WAS 211,000.