1992 FORD ESCORT Complaints

POOR WORKMANSHIP ON FRONT SEATBELTS. THEY ARE AUTOMATIC, HANG UP IN THE TRACK ALL THE TIME, CAUSING A SAFETY HAZARD. LAP BELT IS ALL THAT WORKS. *AK

WIRING HARNESS INSULATION OBVIOUSLY CUT DURING ASSEMBLY. SHARP METAL EDGES ON INSIDE OF LIFTGATE AND "D" PILLAR WERE THE CULPRIT. BARE WIRES AND CUT WIRES WERE SHORTING TO CHASSIS GROUND. FIRE POTENTIAL WAS SERIOUS. INTERMITTANT 3RD BRAKE LIGHT, REAR WINDOW DEFROSTER AND HATCH LIGHT WERE NUISANCE PROBLEMS. OTHER COMPLAINANTS ON THIS SIGHT HAD 3RD BRAKE LIGHT MELT DOWN AND FIRE... THIS COULD BE A DEFINITE CAUSE IN THE WAGONS AND SHOULD BE LOOKED AT CLOSER IN THE SEDANS. ALSO, I WAS READING THE COMPLAINTS ON THIS CAR AND, THOUGH IT HAS BEEN FAIRLY RELIABLE FOR ME, I HAVE EXPERIENCED THE UNCONTROLLED THROTTLE ACCELLERATION OR STICKING ON 2 OCCASIONS. BOTH TIMES WERE DURING LONG TRIPS AND BOTH TIMES THE SYMPTOMS WOULD NOT DISAPPEAR UNTIL AFTER TURNING THE IGNITION OFF AND THEN BACK ON. THERE IS SOMETHING TO THE OTHER'S COMPLAINTS. LASTLY, THE LEFT REAR SEAT BELT WILL NOT RETURN. I ALSO NOTICED AN ALARMING NUMBER COMPLAINTS OF SEAT BELT FAILURES ON THIS VEHICLE. THE SEAT BELT RETURN MECHANISM IS A FAULTY DESIGN. THE ASSEMBLY CAN SPREAD APART, ALLOWING THE RETURN SPRING TO LOOSE IT'S TENSION. THERE REALLY SHOULD BE A SAFETY RECALL OR INVESTIGATION ON THE SEAT BELT ASSEMBLIES IN THIS VEHICLE. THANKS.

A PART ON RETRACTING MECHANISM THE PULLS THE SEAT BELT UP AND DOWN AND AROUND THE OCCUPANT BROKE AWAY FROM THE FRAME, CAUSING THE SEAT BELT TO BECOME INOPERABLE. PLEASE GIVE ANY FURTHER DETAILS. *AK

CONSUMER EXPERIENCING ONGOING PROBLEMS WITH VEHICLE EQUIPMENTS: 1.) REAR SEAT BELT FAILED TO RETRACT; 2.) BRAKE LIGHT BUILB WOULD OVERHEAT, CAUSING PARTS TO MELT; AND 3.) VEHICLE WOULD INTERMITTENTLY ACCELERATE WHILE SHIFTING GEARS OR AT A STOP POSITION. DEALER/ MANUFACTURER NOTIFIED, AND REFUSED TO REPAIR UNLESS COST GOES TO CONSUMER. *AK

MULTIPLE ELETRICAL FAILURES IN INSTRUMENTATION AND PANEL CONTROLS. ABRUPT FAILURE OF DASH LIGHTS THAT ILLUMINATE SPEEDOMETER AND OTHER CRUCIAL INSTRUMENTATION. ALSO, MULTIPLE FAILURES OF ELECTRICALLY POWERED PASSIVE RESTRAINTS, CONFINING FRONT PASSENGERS IN SEATS WITH INABILITY TO DISABLE RESTRAINT (SHOULDER BELT). MULTIPLE ELECTRICAL FAILURES OF OTHER DASH INSTRUMENTATION/CONTROLS TO INCLUDE HEATING/COOLING/FAN/RADIO AND SIGNALS. IN REGARD TO SECOND COMPONENT, INABILITY TO PROPERLY INSTALL INDEPENDENT CHILD SAFETY SEAT IN RIGHT FRONT (PASSENGER) SEAT, EVEN WITH MANUFACTURER-SUPPLIED "LOCKING CLIP" AS BELTS CANNOT BE PROPERLY B SECURED UNDER ANY CIRCUMSTANCES. *AK

OWNER WAS NEVER NOTIFIED OF RECALLS CONCERNING THE OFFSET TOE ADJUSTING PIN OR THE FUEL PUMP SENDING ASSEMBLY.

REAR SPRINGS, I RUN A REPAIR FACILITY AND ALMOST EVERY 90,S FORD ESCORT WE SEE HAS BROKEN REAR SPINGS, THIS SEEMS TO BE A VERY COMMON PROBLEM AND I BELIEVE IT WARRANTS A RECALL OF SOME SORT TO FIND OUT WHY SO MANY BREAK THE REAR SPRINGS IN HALF, I DO NOT OWN ONE OF THESE CARS AND I WOULD NOT BUY ONE FOR THIS REASON, PLEASE LOOK INTO IT FOR THE SAFTEY OF ALL THOSE WHO DRIVE ONE. *MJS

WHILE DRIVING IGINITON SWITCH WAS VERY HOT. WHEN THE CONSUMER WENT INTO THE STORE THE VEHICLE CAUGHT ON FIRE DUE TO THE IGINITON SWITCH BEING HOT AND BURNED THE STARTER. *AK

AUTOMATIC SEATBELT ON DRIVER SIDE IS JAMMED/STUCK IN THE MIDDLE, WILL NOT MOVE OR RETRACT. COULD CAUSE LOSS OF PROTECTION DURING AN ACCIDENT.

WHILE DRIVING 60MPH THE THROTTLE WOULD STICK. CAN HAPPEN AT ANY SPEED ABOVE 55MPH. HAVE TO TURN VEHICLE & WAIT 15MINUTES & THEN RESTARTED VEHICLE. BEEN TO DEALER 7-9 TIMES FOR SAME PROBLEM. *AK