2007 FORD EXPEDITION Complaints

FIRST INCIDENT OCCURRED WHEN VEHICLE WAS TRAVELING 45 MPH. BRAKES WERE APPLIED TO SLOW DOWN BEFORE A CURVE. AT THE POINT THE FRONT WHEELS LOCKED UP AND THE VEHICLE BEGAN TO ROCK BACK AND FORTH AND SWERVE ON THE ROADWAY. TO PREVENT A ROLLOVER THE VEHICLE WAS STEERED OFF THE ROAD WHEN IT JUMPED AN EMBANKMENT AND PLOWED THROUGH 25 FEET MUD AND BRUSH BEFORE COMING TO A COMPLETE STOP. THE BRAKES WERE COMPLETELY INOPERABLE. THE VEHICLE WAS SHUT OFF AND LEFT UNTIL IT COULD BE TOWED OUT. AFTER A FEW HOURS THE CALIPERS RELEASED. THE SECOND INCIDENT OCCURRED WHEN VEHICLE WAS STOPPED AT A STOP SIGN. WHEN ACCELERATED WAS PRESSED THE FRONT WHEELS WERE LOCKED UP AND THE BACK WHEELS WERE SPINNING. VEHICLE WAS PUT IN PARK, SHUT OFF, RESTARTED AFTER A FEW MINUTES AND CALIPERS WERE STILL LOCKED UP. VEHICLE WAS TOWED HOME AND CALIPERS RELEASED AFTER A FEW HOURS. CAR HAD ONLY BEEN RUNNING FOR ABOUT 30 MINUTES WHEN THIS HAPPENED. AFTER DIAGNOSIS IT WAS DETERMINED THAT THE BRACKETS THAT HOLD THE BRAKE LINES ON THE FRONT FAILED AND WHEEL ROTATION WERE THROUGH THE LINES WHICH CAUSED THE BRAKE LINES TO INTERMITTENTLY COLLAPSE. ALL BRAKE LINES, CALIPERS, TIE RODS, SHOCK/STRUTS, BRAKES, ROTORS, UPPER CONTROL ARMS AND LOWER BALL JOINTS HAVE BEEN REPLACED ON BOTH FRONT AND REAR. VEHICLE HAD APPROXIMATELY 180,000 MILES WHEN BOTH INCIDENTS OCCURRED 3 MONTHS APART.

SEAT ROCKS BACK AND FORTH (FRONT AND BACK) WHEN ACCELERATING AND STOPPING. ADJUSTING SEAT DOES NOT HELP, ROCKS ON THE TRACK UP AND DOWN. CAN ROCK SEAT WHEN VEHICLE IS STATIONARY ALSO.

DELEVOPED A TICKING NOISE TIMING CHAINS WERE REPLACED ALL ROCKERS AND LIFTERS ARE IN GOOD SHAPE THE TRUCK LOOSES POWER IT STARTS UP ROUGH AT ABOUT 1800 RPM YOU CAN HEAR THE TICKING LOUD PAST 2000 RPM THE TICKING GOES AWAY I HAVE RECENTLY BEEN NOTIFIED THAT THESE ENGINES HAVE CAM PHASER PROBLEMS IT RECENTLY DEVELOPED A P0022 CODE WHICH IS INT CAM POSITION TIMING OVER RET BANK 2 I HAVE REPLACED THE VVT SELONOIDS AND STILL HAS THE SAME PROBLEM VEHICLE LOST POWER ON HIGHWAY SPEED DROPPED FROM 70 AND WOULD NOT GO PAST 30 VERY UNSAFE INCEDENT ON THE INTERSTATE

WHEN YOU DRIVE THE VEHICLE AND COME TO A STOP, IE: (INTERSECTION) THE VEHICLE WILL GO INTO NEUTRAL WHILE IT'S IN DRIVE AND UPON PRESSING THE ACCELERATOR PEDAL, IT ENTERS A SAFETY TYPE MODE WITH NO INDICATION AND WILL REMAIN IN GEAR ZERO FOR APPROXIMATELY 1-2 SECONDS AND THEN AS IT STARTS MOVING, IT DOES SO WITH VERY LITTLE POWER LEAVING THE VEHICLE IN DANGER OF GETTING STRUCK BY ANOTHER VEHICLE FROM CROSS TRAFFIC. AT THIS TIME, I HAVE NO IDEA WHAT IS CAUSING THIS ISSUE BUT IT SEEMS TO BE COMMON VIA THE INTERNET COMPLAINTS ON THE 6R80 TRANSMISSIONS ON FORD VEHICLES. THIS HAS HAPPENED TO ME 4 TIMES WHILE TRYING TO CROSS MULTI LANE HIGHWAYS BUT THE MOST RECENTLY CAME VERY CLOSE TO WHAT COULD HAVE ENDED INTO A MULTIPLE FATAL ACCIDENT WITH A SEMI TRUCK WHO WAS BARELY ABLE TO STOP IN TIME BEFORE I WAS ABLE TO CROSS A 3 LANE HIGHWAY. I HAVE BEEN ABLE TO HAVE THE VEHICLE GO BACK TO NORMAL BY SIMPLY SHUTTING OFF THE VEHICLE AND RESTARTING IT. WHAT MAKES THIS REALLY DANGEROUS, IS THE DRIVER SUCH AS ME BEING UNAWARE THAT MY VEHICLE IS IN A SAFETY RESTRICTED POWER OUTPUT WHEN THIS HAPPENS. NO WARNING UNTIL YOU COMMIT INTO A DEADLY SITUATION. PEOPLE REPORT THIS ISSUE ON THE INTERNET AS THE VEHICLE GOING INTO NEUTRAL BY ITSELF WHEN COMING TO A STOP. WHEN THEY TRY TO RESUME DRIVING THE VEHICLE RPMS WILL INCREASE AND THE VEHICLE MIGHT OR MIGHT NOT POP INTO GEAR SOFTLY OR FORCEFULLY. SOMETIMES WITH FULL ACCELERATION AUTHORITY AND SOMETIMES WITH A MAX ATTAINABLE SPEED OF 5 MPH OR LESS DEPENDING ON THE GRADIENT AND TERRAIN UNTIL YOU CAN REACH A SAFE SPOT AND RESTART THE VEHICLE.

I REPLACED THE AIR COMPRESSOR AND IT WAS WORKING FINE BUT THEN STARTED BLOWING HOT AIR, THE MECHANIC CHECKED ALL THE LINES AND FOUND THAT THE EMERGENCY BRAKE CABLE WAS NOT SECURED CORRECTLY AND HAD RUBBED A HOLE IN THE HIGH SIDE HOSE AND WAS LEAKING REFRIGERANT OIL. NOW MY OPTIONS ARE EITHER DOING AWAY WITH THE BACK AIR CONDITIONER OR REPLACING THE HOSE WHICH IS $600.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE REVERSING OUT OF THE DRIVEWAY, THE BRAKES AND BOTH FRONT WHEELS SEIZED AND WOULD NOT TURN. AS A RESULT, THE VEHICLE REMAINED STUCK IN THE MIDDLE OF THE STREET. THE CONTACT SHUT OFF THE ENGINE AND REMOVED THE KEYS FROM THE IGNITION. THE VEHICLE WAS RESTARTED AND THE GEAR WAS PLACED IN NEUTRAL. THE CONTACT'S HUSBAND HAD TO PULL THE VEHICLE BACK INTO THE DRIVEWAY VIA A ROPE. THE CONTACT SPRAYED THE WHEELS WITH A TYPE OF SEIZURE UNLOCK SPRAY AND THE VEHICLE WAS ABLE TO BE DRIVEN A DAY LATER. IN ADDITION, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE CALIPERS SEIZED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.

MY TIRES WONT STAY INFLATED, THE AIR KEEPS COMING OUT DAILY, THERE IS NO LEAKS OR ANYTHING , ALSO I ALMOST CAUSED A ACCIDENT , I HIT A CURB

AS SOON AS YOU START THE VEHICLE THE BATTERY SYMBOL DISPLAYS ON THE DASH, IT GOES ON AND OFF CHIMING REPEATEDLY, THEN SWITCHES FROM BATTERY SYMBOL TO WRENCH SYMBOL AND THEN MY ENTIRE GAUGE CLUSTER STARTS. EVERY LIGHT GOES ON AND OFF REPEATEDLY, THE RPM GAUGE AND MPH DROPS TO ZERO AND THE ENGINE CLUNKS REALLY LOUD (WHILE DRIVING), THE AC OR HEAT WILL COMPLETELY TURN OFF AND ON, THE HEADLIGHTS FLICKER AND DIM ON AND OFF AT NIGHT WHILE DRIVING, BAD VIBRATION, LOUD GROWL TYPE IDLE SOUND, THE RADIO SHUTS OFF, WHEN YOU TURN THE HEATER ON IT REPEATEDLY CLUNKS IN THE REAR OF THE VEHICLE UNTIL YOU TURN AC ON AGAIN OR SHUT IT OFF, REAR AIR SUSPENSION LIGHT GOES ON AND OFF WHILE DRIVING. THIS ALL HAPPENS WHENEVER IT WANTS. I SHUT OFF THE CAR AND RESTART AND THE PROBLEM WILL STAY GONE AND DRIVE NORMAL UNTIL IT COOLS AGAIN AND THEN RESTART THE VEHICLE. THIS VEHICLE HAS BEEN TESTED AT 3 SHOPS AND TURNED AWAY BY ALL BECAUSE THEY DON'T KNOW WHERE TO START AS THEY ARE SCANNING THE VEHICLE AND 17 CODES CAME UP. THEY STARTED TESTING EACH ITEM WITH A CODE AND ALL CAME BACK AS FUNCTIONING PROPERLY. SO I BELIEVE IT'S EITHER ELECTRICAL OR ONE OF THE BRAINS/COMPUTERS OF THE VEHICLE?. IT IS BECOMING A SAFETY CONCERN AND I NEED HELP.

MY INTERIOR DOOR HANDLE SPRINGS OUT AND HAS TO BE FORCE BACK IN PLACE. I'M TOLD THERE WAS A RECALL AND IT WAS FIXED. I'M NOT ARGUING THAT SOME TIME HAS PASSED BUT IF THAT'S THE CASE WHY IS THIS HAPPENING EXACTLY AS THE RECALL STATE.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED AND THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD AND TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A SENSOR NEXT TO THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHILE DRIVING 60 MPH, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 219,935.