2020 FORD EXPLORER Complaints

I JUST PULLED OUT FROM A PARKING LOT INTO TRAFFIC AND THERE WAS A LOUD CLUNK AND WARNING LIGHTS APPEARED ON THE DASH. ONE SAID "SERVICE ADVANCETRAC" AND THE OTHER SAID "4WD FAULT SERVICE REQUIRED." THE VEHICLE WOULD NOT SHIFT OUT OF LOW GEAR AND WOULD NOT ACCELERATE OVER 25MPH. THEN, SEVERAL OTHER WARNING LIGHTS CAME ON, SUCH AS "PRE-COLLISION ASSIST NOT AVAILABLE." I TOOK THE VEHICLE TO THE DEALERSHIP THE NEXT DAY AND THEY WERE UNABLE TO REPAIR/RESOLVE THE ISSUE.

THE ELECTRONICS IN SYNC HAVE BEEN GENERATING BLUE SCREENS, WHICH DISABLE: TRONT & REAR SENSORS & CAMERAS, FRONT & REAR COLLISION AVOIDANCE, CRUISE CONTROL, LANE DEPARTURE, AND ADVANCETRAC. FORD THUS FAR IS UNABLE TO FIX ISSUE. 3 ATTEMPTS HAVE BEEN MADE TO FIX THIS, A 4TH IS PENDING. FORD SUPPOSEDLY HAS NO REPAIR PARTS AVAILABLE FOR THIS ISSUE. VEHICLE SAFETY IS AN ISSUE. TWO FORD CASES HAVE BEEN OPENED: FORD VEHICLE BUY BACK CASE NO.[XXX]CRM:0688061 FORD SYNC PROBLEMS CASE NO.[XXX]CRM:0382088 INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

ON OCCASION, THE BRAKES DO NOT WORK PROPERLY WHEN THE CAR IS FIRST PUT INTO DRIVE OR REVERSE AFTER STARTING. WHEN SHIFTING INTO DRIVE OR PARK WITH THE FOOT FIRMLY ON THE BRAKE, THE VEHICLE BEGINS TO MOVE, AND THE BRAKE PEDAL DOES NOT DEPRESS ALL THE WAY AND DOES NOT STOP THE VEHICLE FROM MOVING. IF YOU ATTEMPT TO PUMP THE BRAKES, THERE IS A HARD STOP THAT PREVENTS THE BRAKE PEDAL FROM GOING ALL THE WAY TO THE FLOOR. THE ONLY WAY TO STOP THE VEHICLE IS TO PUT IT BACK INTO PARK. *TR

AFTER STARTING THE VEHICLE IN PARK AND WITH BRAKE DEPRESSED SHIFTING TO REVERSE THE CAR MOVES REGARDLESS OF BRAKE PRESSURE APPLIED. ISSUE ONLY STOPS AFTER PUMPING THE BRAKES OR SHIFTING BACK TO PARK OUR NEUTRAL. ALL SITUATIONS HAVE BEEN ON FLAT LAND AND HAS OCCURRED WITH MULTIPLE DRIVERS. BRAKE PEDAL IS NOTED TO BE 'HARD' WHEN EVENT OCCURS, ALMOST LIKE IT IS LOCKED.

TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE FAILED TO RESPOND. THE CONTACT STATED THAT SEVERAL UNKNOWN WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 10,200.

TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THERE WAS AN ABNORMAL SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE RESIDENCE AND THE CONTACT DISCOVERED AN UNKNOWN LEAK. THE VEHICLE WAS TAKEN TO BOGGUS FORD (2521 SOUTH EXPRESSWAY 83, HARLINGTON, TX 78550 (956)423-2580, TO BE INSPECTED. THE CONTACT WAS INFORMED THAT WHEN THE TRANSMISSION COOLANT SYSTEM CAME IN CONTACT WITH AIR, THE TRANSMISSION COOLANT LINES WOULD LEAK. THE TRANSMISSION FLUID SYSTEM WAS REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.

ON SUNDAY, JUNE 14TH, 2020 AT 12:10 PM, I WAS HEADED EAST BOUND ON A TWO LANE STATE ROAD WITH DOUBLE YELLOW LINES. MY VEHICLE (NEW FORD EXPLORER ST, 2407 MILES ON ODOMETER) WAS ON INTELLIGENT CRUISE CONTROL SET FOR 37 MPH AND IN 'NORMAL DRIVE' MODE. WITHOUT ANY WARNING, THE ENGINE BEGAN TO SHAKE VIOLENTLY AND THE CAR BEGAN TO SLOW DOWN. THE ENGINE APPEARED TO BE RUNNING BUT WOULD NOT ACCELERATE. THE VEHICLE CAME TO A COMPLETE STOP ABOUT 300 FEET FROM WHERE THE PROBLEM STARTED. THE ENGINE WAS STALLED AND WOULD NOT START. NO WARNING LIGHTS OR MESSAGES. CALLED AAA AND THEY CALLED LOCAL POLICE. AN OFFICER DIRECTED TRAFFIC AS I WAS BLOCKING THE RIGHT HAND LANE. THERE WAS NO SHOULDER TO PULL OFF ON. ROAD WAS IN RESIDENTIAL AREA WITH CURBS. A FLAT BED TOW TRUCK ARRIVED AT 12:35 PM AND TOWED THE VEHICLE TO MY LOCAL FORD DEALER. FAULT CODE SHOWED A DEFECTIVE CAMSHAFT POSITION SENSOR. THERE ALSO IS EVIDENCE THAT THE TIMING BELT HAS SLIPPED. SCORING CAN BE SEEN ON TOP OF #6 PISTON THROUGH BORESCOPE. THE #6 SPARK PLUG SHOWS IMPACT DAMAGE FROM PISTON. BATTERY IS DRAINING AND CAR IS GOING INTO SLEEP MODE. SERVICE DEPARTMENT MANAGER STATED THE ENGINE WILL LIKELY REQUIRE REPLACEMENT. THE DEALERSHIP CONTACTED FORD ENGINEERING AND ESTABLISHED A CASE NUMBER. DEALERSHIP IS WORKING WITH FORD ENGINEERING TO DETERMINE THE ROOT CAUSE OF FAILURE. A CATASTROPHIC ENGINE FAILURE OF THIS TYPE IS EXTREMELY DANGEROUS AND LIFE THREATENING. THREE DAYS EARLIER, A 140 MILE ROUND TRIP WAS MADE TO BOSTON WITHOUT INCIDENT. IF THE FAILURE HAD OCCURRED ON I-93 TRAVELING AT 70 MPH, THE END RESULT COULD HAVE BEEN DISASTROUS.

PASSENGER MIDDLE ROW CAPTAIN CHAIR WAS NOT LOCKED IN PLACE RESULTING IN CHILD OCCUPANT TO BE PROPELLED FROM SEAT IN REAR MOST POSITION ALL THE WAY TO FRONT MOST POSITION WHILE ABRUPTLY BRAKING CAUSING CHILD TO STRIKE REAR OF PASSENGER FRONT SEAT. UPON DEALERSHIP INSPECTION WE WERE INFORMED THAT THERE IS A TSB THAT STATED IF THE BATTERY IS DISCONNECTED OR DEAD FOR A PERIOD OF TIME REPROGRAMMING OF THE DOOR CONTROL MODULE WOULD BE REQUIRED TO RESET. PREVIOUS TO INCIDENT DEALER HAD DISCONNECTED BATTERY FOR REPLACING DOOR WINDOW SWITCH AND RETURNED VEHICLE TO US WITH THIS PROBLEM. THERE WAS NO WARNING OR INDICATION THAT THIS SEAT WAS UNSAFE TO BE OCCUPIED AND THAT REPROGRAMMING OF DOOR MODULE REQUIRED. ON TOP OF THE SAFETY CONCERN THIS WOULD ALSO MEAN THAT IF REPLACING A BATTERY YOU WOULD REQUIRE FORD TO SAFELY PERFORM THIS. SOMEONE IS GOING TO GET SERIOUSLY HURT HERE AND OBVIOUSLY FORD KNOWS ABOUT THE ISSUE WITH TSB RELEASED. *TR

TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE INSTRUMENT PANEL STATED THAT THE VEHICLE WAS DRIVING AT 85 MPH. THE SERVICE ENGINE SOON WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO GEWEKE FORD LOCATED AT 871 E. ONSTOTT RD, YUBA CITY, CA 95991, (530) 821-2121, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT AN UNKNOWN ELECTRONIC COMPONENT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 12,000.

THE VEHICLE WAS DRIVING ON A LOCAL HIGHWAY WHEN THE MESSAGE 'SERVICE CHARGE SYSTEM NOW'. THE BATTERY ICON APPEARED BRIEFLY ON THE DASHBOARD. I CONTINUED DRIVING AND THE SAME MESSAGE REAPPEARED EVERY 5 MINUTES. THE DEALER TOLD ME THEY DID NOT RECOGNIZE THE MESSAGE, AND TO BRING THE VEHICLE IN FOR SERVICE SOON. THEY RAN A 'DIAGNOSTIC ' AND DETERMINED IT NEEDED A NEW ALTERNATOR. THE VEHICLE IS SEVEN MONTHS OLD AND HAS LESS THAN 15,000 MILES. IT IS STILL IN FOR SERVICE AS THE DEALER DID NOT HAVE A REPLACEMENT ALTERNATOR IN STOCK. *TR