1995 FORD EXPLORER Complaints

ON JUNE 7, 2003 THE RIGHT SIDE TORSION BAR BROKE COLLAPSING THE FRAME ONTO THE RIGHT FRONT TIRE. A METAL INSPECTOR HAS INSPECTED THE PART AND INDICATED THAT IT IS A MANUFACTURING DEFECT. I WENT TO MY FORD DEALER, THE PARTS MANAGER AT THE DEALERSHIP SAID TOO BAD IT HAPPENED NOW BECAUSE MY CAR IS A 1995 AND THE WARRANTY IS UP WITH NO COVERAGE FOR REPLACING THIS PART. WE WILL NEED TO PURCHASE BOTH THE RIGHT HAND PART AS WELL AS THE LEFT HAND PART #S F57A-BC RUB & F57A-BC LUB AND HAVE THEM INSTALLED. I CAN SEND PICTURES OF THE DEFECTIVE PART. *JB

WHILE TRAVELING ON THE HIGHWAY AT HIGHWAY SPEED, PASSENGER SIDE REAR TIRE ( FIRESTONE RADIAL ATX P235/75R15 ) HAD FULL TREAD SEPARATION FROM TIRE. WAS ABLE TO SLOW AND PULL OFF OF THE SIDE OF THE HIGHWAY ONLY TO FIND DAMAGE TO THE RIGHT REAR OF MY '95 FORD EXPLORER. TREAD PIECE HAD COME OFF THE TIRE AND UP HITTING THE LOWER PORTION OF THE FENDER BENDING IT UPWARD TOWARD THE SUPPORTS FOR IT AND THEN HITTING THE PASSENGER REAR TAIL LIGHT COMPLETELY BREAKING IT ENOUGH TO NEED FULL REPLACEMENT. AFTER HITTING THE LIGHT, IT CAME DOWN AND HIT THE PASSENGER REAR DOOR WINDOW AND LEAVING MULTIPLE BLACK TIRE/RUBBER MARKS DOWN THE DOOR TILL IT HIT THE RUNNING BOARD ON THE SIDE.*JB

EACH OF THE 4 DOOR LOCK MECHANISMS (PASSENGER & DRIVER) HAVE BROKEN AT ONE TIME AFTER 100,000 MILES, PREVENTING THE OCCUPANT OF THAT SEAT FROM OPENING THE CAR DOOR FROM THE INSIDE. DOORS COULD BE OPEN FROM THE OUTSIDE (BY ROLLING THE WINDOW DOWN AND OPENING IT USING THE OUTSIDE DOOR HANDLE). THE DRIVER'S DOOR LOCK IS CURRENTLY BROKEN - IF THE DRIVER IS INSIDE WITHOUT KEYS (KEYS ARE NECESSARY TO TURN ON POWER SO THE DOOR WINDOW CAN BE ROLLED DOWN), HE MUST THEN CLIMB OVER THE CENTER CONSOLE TO EXIT THROUGH THE PASSENGER DOOR. AS MENTIONED, THE DRIVER SIDE DOOR LOCK IS CURRENTLY NON-OPENABLE FROM THE INSIDE, BUT ALL OTHER DOORS HAVE HAD THE SAME DEFECT. THERE IS A NEOPRENE DOOR LOCK PART THAT BREAKS AFTER 100,000 MILES OR SO (I WOULD GUESS), WHICH CAUSES THIS PROBLEM. *NLM

THE VEHICLES POWER STEERING FLUID LEAKED AND CAUSED LOSS OF POWER STEERING. *NLM

THE RECLINER ON THE DRIVERS SEAT BROKE, WHICH CAUSED THE SEAT TO RECLINE BACKWARDS, THE DEALER REPLACED THE BOLT. *JB

ENVIRONMENTAL CONTROL SYSTEM, 1995 FORD EXPLORER -AIR FLOW BLEND DOOR FAILURE CAUSED WINDSHIELD TO COMPLETELY FOG OBSCURING VIEW FORCING EMERGENCY PULL OVER AND STOP ON INTERSTATE. OTHER DRIVERS WERE FORCED TO TAKE EVASIVE ACTIONS TO AVOID COLLISION. *NLM

I WAS DRIVING A 95 FORD EXPLORER SOUTH BOUND ON US 95 AT APPROXIMATELY 70 MPH, WHEN THE VEHICLE BEGAN ACCELERATING ON IT'S OWN. WHEN I TOOK MY FOOT OFF THE ACCELERATOR THE VEHICLE KEPT ACCELERATING ON IT'S OWN EVEN WITH THE CRUISE CONTROL OFF AND MY FOOT OFF THE ACCELERATOR PEDAL. I THEN TRIED TO APPLY THE BRAKES BUT SINCE THE VEHICLE WAS ACCELERATING THE EXPLORER JUST SHOOK. I ALSO DOUBLE CHECKED THE CRUISE CONTROL AND IT WAS IN FACT OFF AND TRIED TO PUMP THE GAS TO SEE IF THE PEDAL WAS STUCK BUT NEITHER WORKED. WHEN THE VEHICLE REACHED APPROXIMATELY 85 MPH I ATTEMPTED TO SHIFT INTO NEUTRAL WHEN THE VEHICLE SKIDDED OUT OF CONTROL. THE SKID MARK WAS ABOUT 350 FEET LONG AND THEN THE EXPLORER LEFT THE ROAD AND ROLLED A FEW TIMES UNTIL IT CAME TO A STOP ON THE DRIVER'S SIDE WITH THE ENGINE STILL ROARING. THE ENGINE ONLY STOPPED WHEN PASSENGER TURNED OFF THE IGNITION KEY SINCE THE DRIVER WAS UNCONSCIOUS. *JB

TENSIONER BELT WAS GOING INTO IT'S FRAME HOLDER. WHILE OPENING THE HOOD AND TRUCK RUNNING SERPENTINE BELT MIGHT HAVE BREAK HAVE BEEN CUT APART AND INJURING THE PERSON LOOKING FOR THE PROBLEM. 3-OTHER EXPLORER HAD THE SAME PROBLEM WHILE I WAS WITH THE MECHANIC.

TRANSMISSION FAILED. FROM PARK TO REVERSE OR DRIVE TOOK 8-10 SEC'S FOR IT'S POSITION. DEALER SAYS NOTHING WRONG. TRANS. SPECIALISTS CHARGED $2500.00 FOR REBUILT FORD TRANS.

FRONT SUSPENSION; THE RIGHT FRONT WHEEL AND STERRING WHEEL VIBRATE AND SHIMMY AT ALL SPEEDS. THE TRUCK HAS NEVER SAT RIGHT IT ALWAYS SEEMS TO BE LEANING.